1996 Ford Escort Problems

THE DRIVER SIDE MOTORIZED SEAT BELT HAS CEASED FUNCTIONING AND IS NOW STUCK MIDWAY ALONG THE TOP PART OF THE SEAT BELT TRACK. THIS BEING THE CASE THE SEAT BELT WILL NOT PROTECT THE DRIVER IN THE EVENT OF A SUDDEN STOP. IN THIS POSITION IT IS LIKELY THAT IN A SUDDEN STOP THE DRIVER'S HEAD WOULD HIT THE WINDSHIELD AND A MORE SEVERE THAN NORMAL WHIPLASH IN THE NECK WOULD OCCUR. I HAVE NOTED THAT THERE ARE NUMEROUS COMPLAINTS ABOUT THIS SEAT BELT ISSUE FOR THIS VEHICLE ONLINE. I CONTACTED FORD CORPORATE AND THERE IS NO RECALL NOTICE OR CUSTOMER SATISFACTION. I THINK THIS IS UNACCEPTABLE ON FORD'S PART. AS A HEALTH CARE PROVIDER, WHO HAS WORKED IN A HOSPITAL NEUROSURGERY UNIT, THE POTENTIAL FOR A SERIOUS HEAD INJURY RESULTING FROM A MALFUNCTIONING SEAT BELT SUCH AS REPORTED ABOVE IS VERY REAL. IT SHOULD NOT BE AN OPTION FOR FORD TO NOT REPLACE SUCH A FAULTY SAFETY DEVICE - FORD SHOULD BE MANDATED TO REPLACE SUCH DEFECTIVE SAFETY DEVICES AND THERE SHOULD BE NO TIME LIMIT ON SUCH A REPLACEMENT OR RECALL. A MEDICAL LEGAL LIABILITY CASE WOULD COST FORD MORE THAN THE COST OF REPLACING THE DEFECTIVE SEAT BELT. *TR

I AM ADDING ANOTHER COMPLAINT TO THE VAST LIST OF PREVIOUS COMPLAINTS REGARDING MY 1996 FORD ESCORT AND THE FAILURE OF MY PASSIVE RESTRAINT SHOULDER BELT. IT HAS BEEN GIVING ME PROBLEMS FOR PROBABLY THE LAST 8-10 YEARS. IT WOULD INTERMITTENTLY STOP MID-TRACK AND "BOUNCING" THE DOOR AGAINST THE HINGE WOULD GET IT TO MOVE. TWO WEEKS AGO, IT STOPPED DEAD IN THE MIDDLE OF THE TRACK. I, TOO, COULD HEAR THE MOTOR TRYING TO MAKE IT GO. I LEFT IT ALONE AND ABOUT 4 DAYS LATER, IT RESUMED OPERATING. NOW A WEEK LATER, IT HAS FROZEN AGAIN, A LITTLE MORE FORWARD IN THE TRACK THAN PREVIOUSLY. I AM DISHEARTEN TO LEARN THAT OTHERS WHO HAVE TRIED THE PROCESS EXPLAINED IN THE OWNER'S MANUAL TO MANUALLY MOVE THE BELT IN THE TRACK HAS FAILED. I AM AT A LOSS AS TO WHY FORD, HAVING BEEN NOTIFIED OF SO MANY COMPLAINTS REGARDING THIS SAME EXACT FAILURE OF THEIR SAFETY EQUIPMENT, HAS CHOSEN TO IGNORE IT! I WILL NEVER BUY ANOTHER FORD PRODUCT IF THIS IS EVIDENCE OF HOW THEY TREAT THEIR FAITHFUL CUSTOMERS! CAN ANYTHING BE DONE ABOUT THIS??? *TR

1996 FORD ESCORT HAS HAD CYLINDER HEAD AND GASKET REPLACED FOUR TIMES. THE VEHICLE HAS LOW MILEAGE AND NOW IT'S JUST SITTING. **CC *NM

TIMING BELT BROKE WHILE DRIVING THE VEHICLE ON HIGHWAY. ALTHOUGH LUCKILY THERE WAS NO INJURY, I WAS SURPRISED TO FIND SIMILAR REPORT FROM THE INTERNET WHOSE VEHICLE WAS MANUFACTURED DURING THE SAME PERIOD. I THINK SOMEONE HAS TO INFORMED THE OWNER TO CHECK THE TIMING BELT OR RECCOMEND A REPLACEMENT BEFORE ANYONE GET HURT. THE VEHICLE IS FORD ESCORT LX 96, MANUFACTURE ON 12/95.*AK

THE VEHICLE WAS INVOLVED IN AN ACCIDENT, THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT DID NOT RESTRAIN THE CONSUMER AS DESIGNED, THE CONSUMER WAS INJURED. *JB *SCC

CONSUMER CRASHED INTO A TRUCK AND WAS REAR ENDED BY ANOTHER VEHICLE IN WHICH NEITHER OF THE AIR BAGS EXPERIENCED DEPLOYMENT UNTIL THE SECOND IMPACT, ONE PERSON WAS INJURED IN THE ACCIDENT. *SLC

I AM NOT SURE IF THIS IS THE CORRECT SECTION TO FILE THIS IN. I AM BEING UNSUCCESSFUL IN A CONTINUED EFFORT TO CORRECT A MALFUNCTION IN THE CHECK ENGINE LIGHT SENSOR. I HAVE DONE ALL I KNOW TO CORRECT THIS MATTER INCLUDING CHANGING THE LIGHT BULB WITH NO SUCCESS. THIS MALFUNCTION IS CONTINUING TO CAUSE ME NOT TO PASS A SIMPLE SMOG TEST. IS THERE ANY RECORD OF THERE BEING A MANUFACTURE DEFECT TO THIS PART. *TR

SPONTANEOUS VEHICLE COMBUSTION: Y 1996 FORD ESCORT WAS STUCK 3 HRS. IN TRAFFIC JAM ON MAJOR NASSAU COUNTY, NY ROUTE IN MIDDLE OF SNOW STORM. FIRE STARTED FROM ENGINE COMPARTMENT, SPREADING TO DASHBOARD. HAD FIRE DEPT. NOT QUICKLY ARRIVED ON SCENE TO EXTINGUISH FIRE, A CHAIN REACTION OF EXPLODING VEHICLES MIGHT HAVE ENSUED INVOLVING HUNDREDS OF DRIVERS. FIRE DEPT. DESCRIBED FIRE AS ELECTRICAL IN ORIGIN.*AK

ABNORMAL RATE OF REAR SPRINGS ON LATE 90'S FORD ESCORT STATION WAGONS. I AM A MECHANIC WITH BROWNIES AUTO REPAIR IN WALKERSVILLE,MD. I PERSONALLY HAVE REPLACED THE REAR SPRINGS ON AT LEAST 8 ESCORT WAGONS. I HAVE CHECKED OTHER ESCORT WAGONS AND FIND MOST BROKEN IN THE SAME SPOT. COULD PUNCTURE TIRE.

I NEVER HAULED ANYTHING HEAVY IN THE BACK OF MY STATION WAGON. THE REAR COIL SPRINGS WERE HOLLOW NOT SOLID AND FAILED BECAUSE THEY RUSTED THROUGH AS A RESULT OF WATER COLLECTING IN THE BOTTOM OF THE SUPPORT WHICH HOLDS THE BASE OF THE SPRING IN THE CORRECT POSITION. MY MECHANIC SAID THAT MANY TIMES WHEN YOU HIT A BUMP THE BROKEN SPRING WILL TWIST AND PUNCTURE THE SIDEWALL OF THE TIRE THAT IT IS ADJACENT TO THE SPRING. HE ALSO SAID THAT THE SAME SPRING FAILURE OCCURS WITH ALL THE FORD ESCORT STATION WAGONS. FORD SHOULD BE REQUIRED TO ISSUE A RECALL ON ALL THESE STATION WAGONS AND REPAIR THE PROBLEM. NLM

WHILE DRIVING SPEEDOMETER BECOMES ERRATIC; SPEEDOMETER ACCELERATES THREE TIMES, ACTUAL SPEED BEING DRIVEN. CANNOT DETERMINE MILEAGE ON VEHICLE. VEHICLE ALSO MAKES STRANG NOISE. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

SPEEDOMETER JUMPS ERRATICALLY AT SPEEDS ABOVE 50 MPH. NOT COVERED UNDER EXTENDED WARRANTY ALTHOUGH BROCHURE LEADS YOU TO BELIEVE SO. DEALERSHIP KNEW IT WAS THE SPEEDOMETER ITSELF AND NOT A DRY CABLE BECAUSE OF HISTORY OF SAME PROBLEMS. 2ND PROBLEM; AT APPOX 80,000 MILES THE DRIVERS SIDE REAR SEAT BELT WOULD NOT RETRACT. I RECOGNIZE THAT THINGS DO BREAK, BUT WHEN THE PASSENGER SIDE REAR SEAT BELT WOULDN'T RETRACT JUST A FEW MONTHS LATER, I CAME TO THE CONCLUSION THAT THERE IS A DESIGN DEFECT. *AK

TL* THE CONTACT OWNS A 1996 FORD ESCORT. WHILE DRIVING THE VEHICLE, THERE WAS A FUEL ODOR IN THE CABIN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL FILLER LINE FAILED AND WOULD NEED TO BE REPAIRED. THE FAILURE OCCURRED ONCE PREVIOUSLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

WHILE DRIVING ON ROAD AND RUNNING OVER SOME DERIS ON FLOOR FUEL LINE WAS PUNCTURED, AND CONSUMER HAD TO PULL OVER. THEN NOTICED THAT FUEL LINES WERE NOT MADE OUT OF METAL, BUT PLASTIC. *AK

ENGINE CHECK LIGHT COMES ON, INDICATING BRAKE FAILURE AND LEAKING FUEL LINE. LIGHT STILL ON AFTER BRAKE CYLINDER REPAIR. *AK

THEERE IS A LOUD CRACKING NOISE COMING FROM THE STEERING GEAR. ALSO, CONSUMER IS HAVING PROBLEM WITH BRAKES, AND THE VEHICLE HAS BEEN IN THE SHOP TWO TIMES. DEALER CAN'T DETERMINE THE PROBLEM. *AK

WHILE DRIVING IT WAS HARD TO TURN THE STEERING WHEEL. DEALERSHIP INFORMED THE CONSUMER THAT THE PROBLEM PERTAINED TO THE STEERING FLUID LEAKAGE. THE PROBLEM HAD NOT BE RESOLVED. *AK

TIE ROD FAILURE ON THE LEFT SIDE. THE TIE RODS ON BOTH SIDES WERE REPLACED ABOUT 3 YEARS AGO. WHEN TAKEN IN TO THE SHOP THEY FOUND THE RIGHT SIDE WAS VERY BAD ALSO. THIS CAR HAS 59,000 MILES. THE FAILURE HAPPENED WHILE DRIVING. PRETTY SCARRY STUFF...*JB

1996 FORD ESCORT, UNIT 1 WAS TRAVELING WEST BOUND ON THE OHIO TURNPIKE. UNIT 1'S HOOD OPENED AND STRUCK THE WINDSHIELD. UNIT 1 CONTINUED ON TO THE NEXT EMERGENCY PULL OFF TO FILE THE REPORT. BF (OHIO TRAFFIC CRASH REPORT # 10-0142-90)*JB UPDATED 04/22/11 *BF

I DO NOT HAVE ANY EVENTS LEADING UP TO THE FAILURE. THE FAILURE CONSISTED OF MY SEAT BACK ON THE DRIVERS SIDE SNAPPING AT THE BASE. AFTER PULLING THE SEAT COVER OFF I NOTICED THAT THE STAINLESS STEEL FRAME ON THE SEAT COMPLETELY BROKE/SNAPPED ALLOWING THE SEAT TO FALL BACK UNCONTROLLABLY. I WAS DRIVING AT THE TIME AND ALMOST WRECKED. I REPLACED THE SEAT WITH A LIKE SEAT FROM A USED VEHICLE. *NM

FRONT WHEELS SEIZED WHILE DRIVING AT APPROXIMATELY 60 MPH WHICH RESULTED IN AN ACCIDENT, POSSIBLY DUE TO FAUTLY TRANSMISSION. VEHICLE WAS TOTALED. *AK *ML

WHILE DRIVING CAR, THE VEHICLE STOPPED PULLING. WHEN CHECKED, I WAS TOLD BY THE INSPECTOR THAT THE CLUTCHES IN THE TRANSMISSION WERE BURNT OUT. HE TOLD ME IT WOULD COST $27OO TO REPAIR. I CONTACTED FORD ABOUT THE EXTENDED WARRANTY I PURCHASED ON THE CAR WAS NO GOOD BECAUSE I SURPASSED THE MILEAGE. WHAT THEY DIDN'T TELL ME WAS THAT THE CAR IS INITIALLY COVERED FOR THE FIRST 100,000 MILES AND THE EXTRA WARRANTY I PURCHASED WAS TO GIVE ME AN EXTENSION OF 60, 000 MILES OR WHICHEVER COMES FIRST. I FEEL AS THOUGH FORD SHOULD REPLACE MY TRANSMISSION AT NO COST TO ME BECAUSE THE LIFE OF THE TRANSMISSION SHOULD BE LONGER THAN IT LASTED. I HAVE EVEN FINISHED PAYING FOR THE CAR YET. *AK

CLICKING SOUND COMING FROM THE FRONT LEFT SIDE OF THE CAR. HAD IT LOOKED AT BY MECHANIC AND WAS TOLD IT HAD SOMETHING TO DO WITH THE SPEEDOMETER CABLE. THE SOUND IS GETTING LOUDER AND CAN BE VERY ANNOYING. *JB WAS SHOCKED AND SURPRISED TO LEARN THAT LEFT REAR COIL SPRING WAS BROKEN AND HAD TO BE REPLACED. CHECK ENGINE LIGHT COMES ON AND THE CODE READS 1443. MECHANIC COULD NOT FIND ANY PROBLEM AND SAID IT MIGHT HAVE A BEEN LOOSE GAS CAP. HE RESET THE LIGHT. CHECK ENGINE LIGHT CAME BACK ON AFTER DRIVING 15 MILES, TOOK IT BACK TO SERVICE STATION AND GOT SAME CODE. MECHANIC COULD NOT FIND THE PROBLEM AND HAS ASKED ME TO TAKE IT TO THE DEALER FOR A SMOKE TEST.

THE VEHICLE SUDDENLY ACCELERATED WHILE BACKING OUT AND CAUSED SERIOUS ACCIDENT. YH

MY WIFE & I HAVE A 1996 FORD ESCORT WAGON THAT WE PURCHASED USED IN 2008. AT THE TIME OF PURCHASE IT HAD A SET OF 4 BRIDGESTONE INSIGNIA SL TIRES THAT STILL HAD REASONABLE TREAD DEPTH REMAINING, SO WE DECIDED TO CONTINUE TO USE THE TIRES UNTIL THE TREAD HAD WORN DOWN MORE AND NEEDED REPLACING. ON FRIDAY, JULY 30, 2010, MY WIFE WAS DRIVING DOWN THE FREEWAY AT APPROXIMATELY 70 MPH WHEN PART OF THE REAR PASSENGER-SIDE TIRE TREAD SEPARATED FROM THE TIRE AND SHOT AGAINST THE SHEET METAL ON THE INSIDE OF THE WHEEL WELL. IT RIPPED A LARGE HOLE IN THE VEHICLE'S SHEET METAL, SHOT MANY SMALL PIECES OF TIRE THROUGH THE HOLE INTO THE INTERIOR CARGO AREA IN THE REAR OF THE VEHICLE, AND CAUSED THE VEHICLE TO STALL AT THE SAME TIME. THANKFULLY MY WIFE WAS ABLE TO HANDLE THE CAR DURING THIS CATASTROPHIC EVENT AND SUCCESSFULLY MANEUVER IT ONTO THE SHOULDER OF THE FREEWAY. WE HAD THE CAR TOWED HOME SINCE IT WOULD NO LONGER START, AND WHEN IT ARRIVED I NOTICED THE LARGE HOLE THAT HAD BEEN MADE INSIDE THE WHEEL WELL BY THE TREAD SEPARATION. THE TIRE STILL HAD PRESSURE, BUT AT THAT TIME I SAW THAT ABOUT HALF OF THE TREAD WAS COMPLETELY MISSING. SINCE THE FORD ESCORT HAS ITS FUEL CUTOUT SWITCH INSTALLED AGAINST THE PASSENGER-SIDE WHEEL WELL, I CHECKED TO SEE IF THAT HAD TRIPPED AND IT HAD. ONCE IT WAS RESET THE CAR WAS ABLE TO START AND THE ENGINE RAN NORMALLY. AS A RESULT OF THIS CATASTROPHIC TIRE FAILURE MY WIFE WAS PLACED IN AN INCREDIBLY DANGEROUS SITUATION, STRANDED ON THE ROAD, AND SIGNIFICANT DAMAGE WAS DONE TO OUR VEHICLE. IT IS MY UNDERSTANDING AS A FORMER AUTOMOTIVE ENGINEER THAT TIRE FAILURES OF THIS KIND ARE NOT ACCEPTABLE AND ANY TIRE THAT IS SUSCEPTIBLE TO THIS FAILURE MUST NOT BE USED. I HAVE REPLACED ALL 4 TIRES WITH NEW TIRES OF A DIFFERENT BRAND AND AM WORKING ON HAVING THE CAR REPAIRED. APPROXIMATELY 2 WEEKS PRIOR TO THIS EVENT I HAD CHECKED THE PRESSURE IN ALL 4 TIRES AND HAD INFLATED THEM JUST UNDER THE MAXIMUM LISTED ON THE SIDE OF THE TIRE (44 PSI). *TR

TIRE SEPARATION WITH CHUNKS OF TIRE GONE LEAVING RADIAL BELT EXPOSE. THIS IS THE SECOND TIRE, SAME COMPANY AND SAME TIRE THAT HAS SEPARATED. BOTH LEAVING LARGE AREAS OF RADIAL BELT EXPOSED. HAVE PICTURES. NO ACCIDENT NO INJURIES, DRIVING IN HEAVY TRAFFIC WHEN BOTH EVIDENTLY SEPARATED BASED ON NOISE AND SHAKING. *JB

SEAT BELT BECAME STUCK MIDWAY ON NUMEROUS OCCASIONS, FINALLY IT CAME OFF THE TRACK. I DO NOT HAVE A SEAT BELT TO WEAR NOW. ENGINE CHECK LIGHT PROBLEM BEGAN AT UNDER 10,OOO MI VEHICLE WAS BROUGHT INTO DEALER WAS REPAIRED (MAYBE? OR WAS IT ONLY RESET?) OXYGEN SENSOR' S (2 )HAD TO BE REPLACED TO PASS EMISSION TEST. NOT COVERED UNDER WARRANTY. PASSENGER DOOR HAD PROBLEM TOOK TO DEALER WHO SORT OF FIXED IT. AT LEAST ONE COULD OPEN IT FROM THE INSIDE. BUT IT WAS DIFFICULT. EVENTUALLY PROBLEM RESURFACED. I HAVE NOTICED THAT MANY OF THE PROBLEMS I HAVE HAD WITH THE SEAT BELTS AND WITH THE CHECK ENGINE LIGHT ARE NOT AN UNCOMMON OCCURENCE. I AM A CHICAGO POLICE OFFICER AND I NOTICE THAT THE CHECK ENGINE LIGHT IS ALWAYS ON IN THE FORD SQUAD CARS. THERE ARE PROBLEMS WHICH NEEDS TO BE ADDRESSED. THE SEAT BELT ISSUE NEEDS TO BE ADDRESSED IMMEDIATELY. UNTIL I SAW YOUR WEB INFO IN A MAGAZINE, I WAS NOT AWARE THERE WAS ANY RECOURSE OTHER THAN TO COMPLAIN TO THE MANUFACTURER WHICH IS FRUITLESS. PERHAPS YOUR NUMBER AND INFORMATION NEED TO BE LISTED ON THE VEHICLE INFORMATION BOOKS THAT ARE SUPPLIED TO NEW CAR BUYERS. I ONLY WONDER HOW MANY OTHER CONSUMERS HAVE HAD SIMILAR PROBLEMS THAT HAVE NOT BEEN REPORTED OTHER THAN TO FORD'S CUSTOMER SERVICE. *AK .

SEVERAL MONTHS AFTER PURCHASE THE VEHICLE STARTED MAKING THIS POPPING OR CRACKING SOUND AT LOW SPEEDS AND ON SIDE TO SIDE MOVEMENTS AND ON UNEVEN TERRAIN. DEALER HAS NOT FOUND THE CAUSE BUT YET CHANGED ALL SHOCK ABSORBERS AND FINALLY INFORMED ME IT WAS DESIGN FLAW FOR 96 MODELS - CHASSIS AND BODY - WILL SEND ME A BULLETIN BUT NEVER RECEIVED ONE. THE NOISE PERSIST AND MUCH LOUDER.

1996 FORD ESCORT'S LEFT FRONT WHEEL FELL OFF WHILE DRIVING. *TS THE LEFT FRONT QUARTER PANEL WAS DESTROYED AND THE FRONT BUMPER AND HOOD BUCKLED/DENTED. THERE WERE NO INJURIES. *NM

TWO OF THE FOUR LUGS:NUTS ON THE REAR PASSENGER'S SIDE TIRE CAME OFF AND TWO WERE LOOSE . THE LUGS:NUTS WERE TIGHTENED AND REPLACED BY THE OWNER. BUT THE LUGS:NUTS CONTINUE TO LOOSEN AND COME OFF. *AK

THE HEAD LIGHT LENSES ON THE FRONT OF MY 96 FORD ESCORT FROM THE HEAT OF THE BULBS BEING EVENTUALLY START TO MELT I BELIEVE THIS IS A PROBLEM OF POOR QUALITY ON FORDS PART. *JB