2007 Ford Expedition Problems

The contact owns a 2007 Ford Expedition. The contact stated while driving approximately 35 MPH, the vehicle stalled in the middle of the roadway. The contact was able to place the vehicle in park(P) and the contact was unable to restart the vehicle. The contact stated no warning light was illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the fuel pump needed to be replaced. The vehicle had been repaired; however, the fuel pump failed a few years later. The manufacturer had been informed of the failure. The failure mileage was approximately 204,000.

MY EXPODITION HAS A BAD GAS SMELL AND SKIPS A LITTLE PLEASE HELP ME

THE TIRE BEGAN MAKING A SQUISHING NOISE AS IT ROTATED. OVER TIME IT BECAME WORSE. THEN ONE MORNING WE FOUND IT FLAT. WE TOOK IT OFF TO PUT THE SPARE TIRE ON. AT THAT TIME WE OBSERVED 9 SEPARATIONS OF THE SIDEWALL OF THE TIRE, ONE WITH CORD SHOWING THROUGH IT. DURING ITS LIFE, THE TIRE WAS ROTATED ROUTINELY AND WAS ALWAYS KEPT AT THE VEHICLE MANUFACTURERS RECOMMENDED PRESSURE. IT WAS MANUFACTURED IN FEBRUARY OF 2011.

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION EQUIPPED WITH MICHELIN LATITUDE TOUR, SIZE: P265/60/R18 (NA). THE CONTACT STATED THAT ALL FOUR TIRES DISPLAYED PERFORATIONS IN THE SIDEWALL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE IT WAS CONFIRMED THAT THERE WERE PERFORATIONS ON THE SIDEWALL OF THE TIRES AND, AS A RESULT, THE TIRES NEEDED TO BE REPLACED. THE TIRES WERE NOT REPLACED. THE DOT NUMBER WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13T006000 (TIRES). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE DOT NUMBER AND VIN WERE UNKNOWN. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 100,000 AND THE TIRE FAILURE MILEAGE WAS 20,000.

Unknown about what causes the issue but was Told it was manufacturers fault not mine. Insurance adjuster came out as well and said that my full coverage won’t cover anything at this point and told me as well to go contact the manufacturers to see what the option are available

I HAVE TO REPLACE SPARK PLUGS EVERY WEEK. THE ENGINE EITHER KEEPS MAKING THE PLUGS FOUL OUT, OR IT BURNS THE TIP RIGHT OFF THE ENGINE. I'M STARTING TO SEE FROM THE COMPLAINTS THIS IS A COMMON ISSUE. I DON'T FEEL SAFE DRIVING THE VEHICLE WITH MY 6 KIDS BECAUSE OF HOW BAD IT KEEPS MISSING AND TRYING TO DIE. I CHANGE PLUGS THEN DRIVES WELL FOR ABOUT A WEEK.

Symptom was low brake pedal or “soft brakes” due to the brake booster pushrod not being turned out to appropriate length requiring to adjust the brake booster pushrod length. In order to correct mechanic has to remove the master brake cylinder and turn out the pushrod 1/2 or 1/4 turn.

FIRST INCIDENT OCCURRED WHEN VEHICLE WAS TRAVELING 45 MPH. BRAKES WERE APPLIED TO SLOW DOWN BEFORE A CURVE. AT THE POINT THE FRONT WHEELS LOCKED UP AND THE VEHICLE BEGAN TO ROCK BACK AND FORTH AND SWERVE ON THE ROADWAY. TO PREVENT A ROLLOVER THE VEHICLE WAS STEERED OFF THE ROAD WHEN IT JUMPED AN EMBANKMENT AND PLOWED THROUGH 25 FEET MUD AND BRUSH BEFORE COMING TO A COMPLETE STOP. THE BRAKES WERE COMPLETELY INOPERABLE. THE VEHICLE WAS SHUT OFF AND LEFT UNTIL IT COULD BE TOWED OUT. AFTER A FEW HOURS THE CALIPERS RELEASED. THE SECOND INCIDENT OCCURRED WHEN VEHICLE WAS STOPPED AT A STOP SIGN. WHEN ACCELERATED WAS PRESSED THE FRONT WHEELS WERE LOCKED UP AND THE BACK WHEELS WERE SPINNING. VEHICLE WAS PUT IN PARK, SHUT OFF, RESTARTED AFTER A FEW MINUTES AND CALIPERS WERE STILL LOCKED UP. VEHICLE WAS TOWED HOME AND CALIPERS RELEASED AFTER A FEW HOURS. CAR HAD ONLY BEEN RUNNING FOR ABOUT 30 MINUTES WHEN THIS HAPPENED. AFTER DIAGNOSIS IT WAS DETERMINED THAT THE BRACKETS THAT HOLD THE BRAKE LINES ON THE FRONT FAILED AND WHEEL ROTATION WERE THROUGH THE LINES WHICH CAUSED THE BRAKE LINES TO INTERMITTENTLY COLLAPSE. ALL BRAKE LINES, CALIPERS, TIE RODS, SHOCK/STRUTS, BRAKES, ROTORS, UPPER CONTROL ARMS AND LOWER BALL JOINTS HAVE BEEN REPLACED ON BOTH FRONT AND REAR. VEHICLE HAD APPROXIMATELY 180,000 MILES WHEN BOTH INCIDENTS OCCURRED 3 MONTHS APART.

I HAVE A 2007 FORD EXPEDITION WILL START UP IN THE MORNING AND BE FINE UNTIL IT WARMS UP THEN IT WILL STALL OUT IN THE MIDDLE OF THE ROAD OR AT STOP SIGHS OR LIGHTS THESE MOTORS ARE KNOW TO HAVE PROBLEMS FROM FACTORY IT IS MY ONLY CAR I HAVE TO GO TO COLLEGE I NEED HELP RESOLVING THIS ISSUE

AS SOON AS YOU START THE VEHICLE THE BATTERY SYMBOL DISPLAYS ON THE DASH, IT GOES ON AND OFF CHIMING REPEATEDLY, THEN SWITCHES FROM BATTERY SYMBOL TO WRENCH SYMBOL AND THEN MY ENTIRE GAUGE CLUSTER STARTS. EVERY LIGHT GOES ON AND OFF REPEATEDLY, THE RPM GAUGE AND MPH DROPS TO ZERO AND THE ENGINE CLUNKS REALLY LOUD (WHILE DRIVING), THE AC OR HEAT WILL COMPLETELY TURN OFF AND ON, THE HEADLIGHTS FLICKER AND DIM ON AND OFF AT NIGHT WHILE DRIVING, BAD VIBRATION, LOUD GROWL TYPE IDLE SOUND, THE RADIO SHUTS OFF, WHEN YOU TURN THE HEATER ON IT REPEATEDLY CLUNKS IN THE REAR OF THE VEHICLE UNTIL YOU TURN AC ON AGAIN OR SHUT IT OFF, REAR AIR SUSPENSION LIGHT GOES ON AND OFF WHILE DRIVING. THIS ALL HAPPENS WHENEVER IT WANTS. I SHUT OFF THE CAR AND RESTART AND THE PROBLEM WILL STAY GONE AND DRIVE NORMAL UNTIL IT COOLS AGAIN AND THEN RESTART THE VEHICLE. THIS VEHICLE HAS BEEN TESTED AT 3 SHOPS AND TURNED AWAY BY ALL BECAUSE THEY DON'T KNOW WHERE TO START AS THEY ARE SCANNING THE VEHICLE AND 17 CODES CAME UP. THEY STARTED TESTING EACH ITEM WITH A CODE AND ALL CAME BACK AS FUNCTIONING PROPERLY. SO I BELIEVE IT'S EITHER ELECTRICAL OR ONE OF THE BRAINS/COMPUTERS OF THE VEHICLE?. IT IS BECOMING A SAFETY CONCERN AND I NEED HELP.

Odometer Fraud. The contact purchased a 2007 Ford Expedition. The contact stated that upon taking the vehicle to an independent mechanic for servicing, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 17,000, and at the time the mechanic was servicing the vehicle, it was discovered that the mileage was 224,000.

Unknown about what causes the issue but was Told it was manufacturers fault not mine. Insurance adjuster came out as well and said that my full coverage won’t cover anything at this point and told me as well to go contact the manufacturers to see what the option are available

I WAS RIDING ALONG THE INTERSTATE WHEN MY SUNROOF SUDDENLY EXPLODED! NOTHING HIT IT; THERE WAS NO ROCK OR PEBBLE. NOTHING WAS DROPPED ON MY SUNROOF. THE SUNROOF JUST SUDDENLY EXPLODED. SHATTERED GLASS WAS ALL OVER THE INTERIOR OF MY VEHICLE.

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT THE AUTOMATED WINDOWS WERE INOPERABLE. THE VEHICLE WAS NOT REPAIRED OR DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 54,000.

VEHICLE LEFT PARKED ON FLAT SURFACE, I GOT BACK IN AFTER IT HAD BEEN PARKED FOR ABOUT 5 MINUTES.. AS SOON AS I GOT IN, THE VEHICLE STARTED ROLLING FORWARD. I IMMEDIATELY APPLIED THE BRAKE AND CHECKED THAT THE SHIFTER WAS FULLY IN "PARK", WHICH IT WAS. AS SOON AS I LET OFF THE BRAKE, THE VEHICLE ROLLED ABOUT ANOTHER FOOT BEFORE STOPPING ITSELF. *TR

TL*THE CONTACT OWNS A 2007 FORD EXPEDITION. WHEN COMING TO A COMPLETE STOP, THE VEHICLE LUNGES FORWARD. THE CONTACT TOOK THE VEHICLE TO THE DEALER ON NUMEROUS OCCASIONS AND THEY RESET THE RPM'S. AFTER THE REPAIR, THE FAILURE IMMEDIATELY RECURRED. THE TECHNICIAN ADDED THAT THE TRANSMISSION WAS DESIGNED TO DOWNSHIFT AND THAT THERE WAS NO CURRENT REMEDY TO REPAIR THE FAILURE. AS OF OCTOBER 10, 2008, THE VEHICLE HAS NOT BEEN PROPERLY REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 10,000 AND CURRENT MILEAGE WAS 23,400.

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE REVERSING OUT OF THE DRIVEWAY, THE BRAKES AND BOTH FRONT WHEELS SEIZED AND WOULD NOT TURN. AS A RESULT, THE VEHICLE REMAINED STUCK IN THE MIDDLE OF THE STREET. THE CONTACT SHUT OFF THE ENGINE AND REMOVED THE KEYS FROM THE IGNITION. THE VEHICLE WAS RESTARTED AND THE GEAR WAS PLACED IN NEUTRAL. THE CONTACT'S HUSBAND HAD TO PULL THE VEHICLE BACK INTO THE DRIVEWAY VIA A ROPE. THE CONTACT SPRAYED THE WHEELS WITH A TYPE OF SEIZURE UNLOCK SPRAY AND THE VEHICLE WAS ABLE TO BE DRIVEN A DAY LATER. IN ADDITION, THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE CALIPERS SEIZED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 151,000.

MY TIRES WONT STAY INFLATED, THE AIR KEEPS COMING OUT DAILY, THERE IS NO LEAKS OR ANYTHING , ALSO I ALMOST CAUSED A ACCIDENT , I HIT A CURB

Unknown about what causes the issue but was Told it was manufacturers fault not mine. Insurance adjuster came out as well and said that my full coverage won’t cover anything at this point and told me as well to go contact the manufacturers to see what the option are available

I HAVE A 2007 FORD EXPEDITION WILL START UP IN THE MORNING AND BE FINE UNTIL IT WARMS UP THEN IT WILL STALL OUT IN THE MIDDLE OF THE ROAD OR AT STOP SIGHS OR LIGHTS THESE MOTORS ARE KNOW TO HAVE PROBLEMS FROM FACTORY IT IS MY ONLY CAR I HAVE TO GO TO COLLEGE I NEED HELP RESOLVING THIS ISSUE

The contact owns a 2007 Ford Expedition Max. The contact was at a state inspection station and the vehicle was failed due to rust holes on the passenger’s side front subframe behind the front suspension, directly under a reinforcement plate. The contact stated that the entire reinforcement plate and the frame rail behind the plate had rusted through rendering the vehicle unsafe. The contact stated no warning light was illuminated. The contact took the vehicle to an independent mechanic, where it was diagnosed and the rusted frame section was replaced. The manufacturer had not been informed of the failure. The failure mileage was approximately 238,000.

MY INTERIOR DOOR HANDLE SPRINGS OUT AND HAS TO BE FORCE BACK IN PLACE. I'M TOLD THERE WAS A RECALL AND IT WAS FIXED. I'M NOT ARGUING THAT SOME TIME HAS PASSED BUT IF THAT'S THE CASE WHY IS THIS HAPPENING EXACTLY AS THE RECALL STATE.

SEAT ROCKS BACK AND FORTH (FRONT AND BACK) WHEN ACCELERATING AND STOPPING. ADJUSTING SEAT DOES NOT HELP, ROCKS ON THE TRACK UP AND DOWN. CAN ROCK SEAT WHEN VEHICLE IS STATIONARY ALSO.

2007 FORD EXPEDITION. CONSUMER WRITES IN REGARDS TO ENGINE LOCKING ISSUE. *LD THE CONSUMER STATED THE VEHICLE STOPPED ON A BUSY HIGHWAY WITHOUT ANY WARNING. THE VEHICLE HAD LESS THAN 125,000 MILES ON IT. THE CONSUMER STATED THAT DOOR HANDLES WERE PEELING AND CUTTING THE OWNER. THE HANDLES WERE REPAIRED UNDER WARRANTY BUT, THE FAILURE RECURRED. UPDATED 04/10/2017 *JS

THE FIRST OCCURRENCE WAS THE TRANSMISSION SLIPPING ON ACCELERATION AND STOPPING OR GOING UP HILL. ITS BEEN TO OUR FORD DEALER WHERE WE PURCHASED IT AND AT FIRST THEY FELT IT AND SAID THEY FIXED IT BUT NOW EVERYTIME I TAKE IT IN FOR THAT OR THE AC BLOWER GOING OFF AND ON THEY SAY THEY DON'T FEEL OR SEE ANYTHING IT GOTTEN RIDICULOUS. IN THE FREEWAY I-10 ME AND MY SON WERE TRYING TO ACCELERATE ON AND ALMOST GOT HIT BY A SEMI TRUCK THE VEHICLE WOULD NOT GO FAST ENOUGH. I WONT BOTHER WITH THE DEALERSHIP HERE IN TOWN THEY DON'T CARE. IT HAS HAPPENED MANY TIMES AND NOW THE AIR BAG LIGHT GOES OFF AND ON IN TEMPERATURE CHANGE IT SEEMS LIKE. OUR DEALER FIXED THE DOOR HANDLE BUT NOW ANY RAIN THE INSIDE OF OUR DOOR FILLS WITH WATER AND THEY SAY ITS NOT THERE FAULT AND WONT FIX THAT EITHER. VERY DISAPPOINTED WITH FORD. SPOKE TO THEM ABOUT THE AIR BAG AND THEY ALSO SAY THEY WONT FIX. WE HAVE HAD NOTHING BUT PROBLEMS WITH THIS 40000 SUV VERY DANGEROUS TO DRIVE AND ITS SUPPOSE TO BE A FAMILY VEHICLE....RIGHT WE GET NO UPDATE OR RECALLS INFO AND OUR DEALERSHIP IS THE WORST I'VE EVER DEALT WITH

AIR BAG LIGHT KEEPS COMING ON AND OFF WHILE DRIVING. DEALER CAN ONLY CHECK IF IT IS ON AT TIME BROUGHT IN NO LUCK YET BUT WHY IS IT FAULTY. FORD WILL NOT COVER TO LOOK AT SO FRUSTRATED LAWS NEED TO CHANGE ON AIRBAGS AND WARRANTIES. IM TOLD IT IS ONLY COVERED IN THE FIRST 36000 MILES ANYWAY. *TR

MY TIRES WONT STAY INFLATED, THE AIR KEEPS COMING OUT DAILY, THERE IS NO LEAKS OR ANYTHING , ALSO I ALMOST CAUSED A ACCIDENT , I HIT A CURB

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHEN THE VEHICLE WAS PLACED INTO REVERSE, THE BRAKES AND THE STEERING FAILED WITHOUT WARNING. THE VEHICLE WOULD NOT STOP AND CONTINUED TO ACCELERATE. THE CONTACT DEPRESSED THE BRAKE PEDAL ALL THE WAY TO THE FLOORBOARD. THE CONTACT TURNED OFF THE IGNITION. THE VEHICLE CRASHED INTO A CURB AND A TREE. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT THERE WAS A WHINING SOUND COMING FROM OF THE REAR OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE DEALER DETERMINED THAT THE BEARINGS WERE FAILING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 75,000. *TR

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THE REAR OF THE VEHICLE WOULD FEEL UNSTABLE AND BEGAN TO BOUNCE EXCESSIVELY WHILE DRIVING APPROXIMATELY 35 MPH. THE REAR OF THE VEHICLE WAS SITTING UNUSUALLY LOW AND THERE WAS A DECREASE IN VEHICLE CONTROL WHILE DRIVING. THE DEALER STATED THAT THEY WERE AWARE OF THIS PROBLEM AND THAT THE REAR MODULE WAS THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 67,000 AND THE CURRENT MILEAGE WAS 68,000.

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT THE HAZARD LIGHTS ILLUMINATED INDEPENDENTLY AND WOULD NOT TURN OFF. AFTER PARKING AND EXITING THE VEHICLE, THE CONTACT WAS ALERTED BY PEOPLE MORE THAN ONCE THAT THE HAZARD LIGHTS WERE ILLUMINATED. AS THE FAILURE PROGRESSED, BOTH TURN SIGNALS FAILED TO WORK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

INTENSITY OF THE LIGHTING SUPPLIED TO THE ELECTRONIC MESSAGE CENTER (WHICH DISPLAYS MILEAGE, ODOMETER, REMAINING FUEL MILEAGE, FUEL ECONOMY, COMPASS, ETC.) IS PROVIDED THROUGH A PHOTO CELL ON THE DASHBOARD. IT IS WIRED INCORRECTLY, SO THAT HIGH INTENSIFY LIGHT (AS IN DAYLIGHT) REDUCES THE AMOUNT OF LIGHT DISPLAYED. THIS IS BACKWARDS. IT MAKES ALL FUNCTIONS OF THE ELECTRONIC MESSAGE CENTER (ODOMETER, ETC.), IMPOSSIBLE TO READ IN NORMAL DAYLIGHT CONDITIONS. LOCAL FORD DEALERSHIP TELLS ME THAT THIS PROBLEM IS COMMON TO A SIGNIFICANT NUMBER OF FORD CARS AND TRUCKS FOR SEVERAL YEARS, INCLUDING AND MORE RECENTLY THAN 2007. A LETTER TO FORD DID NOT PROVIDE ANY SUGGESTIONS FOR REPAIR. IN ORDER TO READ ANYTHING ON THIS DISPLAY IN NORMAL LIGHT, IT IS NECESSARY TO DUCK YOUR HEAD DOWN AND STARE AT IT FOR ABOUT TEN OR MORE SECONDS. IF THIS ACTION HAS NOT YET CAUSED ANY FATALITIES, I CAN'T IMAGINE WHY. UPDATED 10/24/2014 *JS

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING 35 MPH, THE FRONT DRIVER SIDE SEAT BELT UNLATCHED WITHOUT WARNING. ALSO, THE THIRD ROW PASSENGER SEAT BELT FAILED TO LATCH CORRECTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT THE SEAT BELT IN THE REAR MIDDLE SEAT WAS WORN. THE CONTACT NOTICED THE FAILURE SHORTLY AFTER PURCHASING THE VEHICLE. THE DEALER ADVISED THE CONTACT THAT THE SEATBELTS WERE FINE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 36,000 AND THE CURRENT MILEAGE WAS 50,000.

ONE MONTH AFTER THE PURCHASE OF MY 2007 EXPEDITION EDDIE BAUER MY AIR CONDITIONER IS WORKING INTERMITTENTLY. I HAVE RECEIVED TWO SERVICE BULLETINS FROM THE DEALER FROM FORD STATING THEY KNOW THAT THERE IS A PROBLEM BUT ARE NOT SURE HOW TO FIX. I LIVE IN FLORIDA ITS HOT. *JB