2010 Ford Expedition Electrical Problems

Interior A/c blower motor short. A/c stops and starts by itself with smell of wiring melting or burnt.

NHTSA ID

11482932

Incident

Aug 28, 2022

I ATTEMPTED TO ROLE MY WINDOW UP WHILE DRIVING AND IT STOPPED WORKING. THE WINDOW WILL NOT ROLL UP OR DOWN AND IS STUCK OPEN. THE MOTOR MAKES A CLICKING SOUND. WINDOW IS NOT OFF TRACK EITHER.

NHTSA ID

11258661

Incident

Sep 27, 2019

TRANSMISIN PROBLEM BERY NOISE WHEN DRIVING AND PRESS GAS. SOMETIMES WHEN IS PARKED IT MOVES LIKE 12" . AC ALWAYS A PROBLEM TOKE TO MECANIC AT LEASE 10 TIMES I'M SO TIRED IF THIS.

NHTSA ID

11140157

Incident

Jun 24, 2014

Mileage

100,000 mi

WHEN WE TOUCH THE BRAKES, FROM STARTING POSITION OR WHEN IN MOTION, THE ELECTRICAL COMPONENTS IN THE DASH FLASH AND FLICKER OR TURN OFF, THE HEADLIGHTS TURN OFF, THERE IS A CLICKING NOISE IN THE DOORS, THE WINDOWS WON'T ROLL UP OR DOWN, THE AC TURNS OFF, THE RADIO TURNS OFF, AND YOU CAN'T SWITCH GEARS (GEAR SHIFT WON'T MOVE). I'D NEED TO UPLOAD A VIDEO FOR YOU TO SEE IT. IT ALWAYS HAPPENS WHEN USING THE BRAKES AND HAS BEEN HAPPENING FOR OVER A YEAR.

NHTSA ID

11019268

Incident

Aug 10, 2016

Mileage

96,000 mi

TL* THE CONTACT OWNS A 2010 FORD EXPEDITION. WHILE THE VEHICLE WAS AT A STANDSTILL, THE FRONT DRIVER AND PASSENGER SIDE WINDOWS FAILED TO OPEN. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER WINDOW REGULATOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL ON THE REGULATOR. WHILE DRIVING 25 MPH, THE CONTACT ATTEMPTED TO SWITCH THE HEATER OFF, BUT THE HEATER FAILED TO TURN OFF. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DETERMINED THAT THE BLOWER HAD LIKELY FAILED. THE CONTACT TOOK THE VEHICLE HOME BEFORE THE DEALER COULD PROPERLY DIAGNOSE THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

NHTSA ID

10985088

Incident

Dec 15, 2016

Mileage

60,000 mi

ON 04/14/2015 MY FRIEND OUR 2010 FORD EXPEDITION EL LIMITED IN THE DRIVEWAY AND WENT INTO THE HOUSE. APPROXIMATELY 2 HOURS LATER SHE HEARD THE ALARM GO OFF AND WENT OUTSIDE TO INVESTIGATE. THE CAR HAD DARK TINTS ON THE WINDOWS BUT THE CAR LOOKED DARKER THAN NORMAL THEN SHE REALIZED SHE COULDN'T SEE IN THE CAR BECAUSE IT WAS FULL OF BLACK SMOKE. A FEW SECONDS LATER SHE SAW A SPARK COMING FROM THE MIDDLE SECTION OF THE DASH BOARD THEN ALL THE WINDOWS BLEW OUT AT ONCE AND THE CAR BURST INTO FLAMES. SHE CALLED 911 AND THE FIRE DEPARTMENT MANAGED TO KEEP THE FIRE FROM SPREADING TO MY HOUSE AND MY NEIGHBOR'S HOUSE. THE FIRE WAS SO HOT IT MELTED THE FRAMES OF MY WINDOWS AND SCORCHED THE SIDING ON THAT SIDE OF THE HOUSE. THE TREE, BUSHES , GRASS AND LIRIOPE ON THAT SIDE OF THE HOUSE CAUGHT ON FIRE AND THERE IS GLASS ALL OVER MY YARD. THE CAR WAS COMPLETELY DESTROYED. I UNDERSTAND THAT FORD HAS HAD SIMILAR FIRES IN THE PAST WITH EARLIER MODELS. APPARENTLY THEY HAVE NOT FIXED ALL OF THE PROBLEMS. THE CAR WAS WORKING WELL UNTIL THE DAY IT CAUGHT ON FIRE. THE ARSON INVESTIGATOR SAID THAT IT LOOKED LIKE IT MIGHT HAVE STARTED IN THE NAVIGATION SYSTEM. NOW I AM READING THAT FORD HAS HAD PROBLEMS WITH A "DEFECTIVE CRUISE CONTROL SWITCH THAT HAS CAUSED TRUCKS TO GO UP IN FLAMES? SIMILAR TO HOW MY EXPEDITION WAS DESTROYED. I ALSO READ THAT FORD EXPEDITIONS AS WELL AS OTHER FORD TRUCKS HAVE HAD A ?POSSIBLE DEFECT IN THE SPEED CONTROL DEACTIVATION SWITCH?. THE ARTICLE STATED THAT, ?SOME SWITCHES COULD LEAK. BECAUSE THE SWITCH HAS ELECTRICAL POWER AT ALL TIMES, THE LEAKING FLUID COULD IGNITE AND CAUSE A FIRE, EVEN WHEN THE VEHICLE IS UNATTENDED?. REGARDLESS OF HOW IT HAPPENED THE TRUCK OBVIOUSLY HAD A DEFECT. I HAVE PHOTOGRAPHS AND MY NEIGHBORS HAVE VIDEO OF THE FIRE. *TR

NHTSA ID

10714140

Incident

Apr 14, 2015

Mileage

100,000 mi

VEHICLE STARTED ON ITS OWN WITHOUT THE IGNITION SWITCH TURNED ON. I WAS NOT ABLE TO GET THE CAR TO STOP RUNNING UNTIL I TURNED THE IGNITION SWITCH ON AND THEN BACK TO OFF. *TR

NHTSA ID

10693469

Incident

Mar 10, 2015

Mileage

91,500 mi

AS I WAS DRIVING AWAY FROM MY HOME (THANKFULLY AT A LOW SPEED) THE POWER STEERING SUDDENLY WENT OUT. IF I HAD BEEN GOING ANY FASTER AN ACCIDENT MIGHT HAVE HAPPENED. ALSO, I CONTINUE TO HAVE PROBLEMS WITH THE POWER WINDOW IN THE CAR. WHEN IT IS COLD, YOU CAN GET THE WINDOW TO GO DOWN BUT IT IS VERY HARD TO GET IT TO GO BACK UP. TWO SHOPS TOLD ME THAT THE MOTOR IN THE WINDOW WAS BAD SO I HAD ONE OF THEM REPLACE IT BUT THAT DIDN'T SOLVE THE PROBLEM AS I LEARNED THE NEXT TIME IT WAS COLD AND THE WINDOW STILL DIDN'T WORK RIGHT. I WAS THEN TOLD THAT THERE IS AN ELECTRICAL PROBLEM THAT MAKES THE MOTOR KEEP GOING BAD BUT I DON'T KNOW WHAT IS GOING ON. *TR

NHTSA ID

10594994

Incident

May 20, 2013

Mileage

35,000 mi

THE FAILURES OCCURRED OVER A 3 DAY PERIOD. THE MOTOR QUIT WHILE IDLING FOR LESS THAN 5 MINUTES IN A RESTAURANT PARKING LOT. INITIALLY, IT WOULD NOT EVEN TURN OVER. HOWEVER, AFTER SEVERAL ATTEMPTS IT DID RE-START. THE MOTOR STALLED AGAIN ABOUT 90 MINUTES LATER WHILE GOING 30 MILES PER HOUR. WHILE COASTING, WE TURNED OFF THE MAIN STREET (WITH GREAT DIFFICULTY) - THE POWER STEERING, BRAKES ETC. NO LONGER WORKING. IT STARTED AFTER MANY FUTILE ATTEMPTS. WE HEADED TOWARDS A FORD DEALERSHIP AND THE MOTOR STALLED AGAIN, NOW ON A BUSY FREEWAY - AFTER MULTIPLE ATTEMPTS, WHILE COASTING, THE MOTOR DID RESTART. THAT DEALERSHIP HAD THE VEHICLE FOR 24 HOURS BUT FOUND NOTHING. THEIR COMMENT: "IT IS RUNNING FINE NOW - IT IS LIKELY ELECTRONIC - TAKE IT TO YOUR LOCAL DEALER". WE LEFT THE NEXT DAY FOR THE 240 MILE TRIP HOME. WE WERE ON A MAJOR FREEWAY DURING "RUSH HOUR" EXTREMELY CONGESTED TRAFFIC (DUE TO CONSTRUCTION) WHEN THE MOTOR STALLED ONCE AGAIN. WE HAD JUST MERGED FROM 2 LANES TO 1 AND MY HUSBAND WAS ABLE TO "MUSCLE THE VEHICLE" INTO THE RIGHT LANE AND ONTO THE SHOULDER. THIS TIME, AFTER MULTIPLE ATTEMPTS, NOTHING. WE WERE STRANDED ON A MAJOR FREEWAY WITH 2 DOGS AND ENDLESS 65 MPH TRAFFIC FLYING BY. AFTER UNLOADING OUR DOGS INTO THE MIDST OF THIS DANGEROUS SITUATION, OUR 2010 EXPEDITION WAS LOADED ONTO A FLATBED TRUCK TO BE HAULED THE 65 MILES REMAINING TO OUR HOME (AND THE DEALERSHIP WHERE WE PURCHASED THE VEHICLE). AFTER 3 DAYS OF DIAGNOSTICS FOUND NOTHING, SOMEONE AT FORD (DETROIT) SUGGESTED THE "WIGGLE-WIRE" TEST BEFORE, AS A LAST RESORT, REPLACING THE COMPUTER SYSTEM. WITH THE ENGINE RUNNING, THE WIRES WERE WIGGLED UNTIL ONE ACTUALLY STOPPED THE ENGINE. IT HAD BEEN "CRIMPED", AS WIRES WERE "MERGED" FROM MANY TO A FEW AT THE FACTORY, EVENTUALLY CAUSING A SHORT. THE STALLING ENGINE COULD EASILY HAVE RESULTED IN AN HORRIFIC ACCIDENT. AND, I AM NOT CONVINCED IT IS TRULY "FIXED".

NHTSA ID

10471041

Incident

Aug 3, 2012

Mileage

41,000 mi

TL* THE CONTACT OWNS A 2010 FORD EXPEDITION. THE CONTACT STATED THAT THE INSTRUMENT PANEL LIGHTS WERE NOT BRIGHT ENOUGH, AS A RESULT HE COULD NOT READ ANY OF THE INSTRUMENTS. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT IT WAS NORMAL AND THEY COULD NOT ALTER THE DESIGN OF THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE IT WAS NOT CONSIDERED A DEFECT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 500 AND THE CURRENT MILEAGE WAS 33,000.

NHTSA ID

10409207

Incident

Jan 1, 2010

Mileage

500 mi