2013 Ford Expedition Problems

The contact owns a 2013 Ford Expedition. The contact stated that while driving 55 MPH, the vehicle decelerated and unexpectedly downshifted to first gear before the vehicle veered over into the next lane. The contact was able to regain control of the vehicle and steer it back into the correct lane. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed; however, the vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 19V075000 (POWER TRAIN); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The approximate failure mileage was 147,300.

The contact owns a 2013 Ford Expedition. The contact stated that while driving 55 MPH, the transmission unexpectedly downshifted to first gear, causing the vehicle to shake and jerk abnormally. The speedometer was fluctuating, and the transmission warning light was illuminated. The contact pulled over and turned off the vehicle. The vehicle was restarted and driven to the parents' residence. The dealer was made aware of the failure but informed the contact that the vehicle was not included in Customer Satisfaction Program: 19N01 (Transmission Molded Leadframe Extended Coverage). The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 146,500.

2013 Ford Expedition Limited 5.4 engine. The vehicle was purchased new with an extended warranty with all services performed by Ford dealer. On or about [XXX], with no warning or indication of problem the vehicle experienced what was determined to be a catastrophic internal engine failure, with only 93840 miles. The engine problems were known by Ford Motor Company as replacement engines had design changes and modifications. The engine failure resulted in an immediate stop, which occurred on a 4-lane state road with a fifty-five MPH limit. Fortunately, no vehicles were in close proximity at the time. Dense traffic, at speed, could have resulted in a multivehicle accident. The vehicle required flatbed towing to a service center. Ford Motor Company has not taken action (recall) to address the engine problems, nor has Ford offered reimbursement to customers for replacement engine cost. Ford Motor Company receives the defective engine back when a replacement engine is purchased. The cost was near $8K. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2013 Ford Expedition. The contact stated that while driving at various speeds, there was an abnormal tapping sound coming from the passenger’s side of the engine compartment. The vehicle was taken to the local dealer who replaced twelve rocker arms from the passenger’s side of the engine, and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 95,833.

When driving veh wrench light came on veh jerks and drops down to first gear rpm and speed gauges go out for second had to pull over cut veh off and cut it back on to get it home this happened several times took it to the closes shop they said it the transmission speed sensor loosing connection with the computer.

The contact owned a 2013 Ford Expedition. The contact stated that while the vehicle was idling in the daughter's driveway, a mist was present coming from the vents, and moments later the horn activated and flames were seem coming from under the front passenger side dashboard. Flames quickly engulfed the vehicle and the fire department was called to the scene and extinguished the flames. During the incident, the vehicle was destroyed. No injuries were reported. A fire and police report was taken at the scene and the vehicle was towed away. The cause of the failure was not determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 60,000.

2/13/19- Ford Issued Recall on 2013 Ford Expedition for OSS failure and downshift 2/20/19- I go to the Preston Ford Mazda dealership, Maryland. I view and test drive a 2013 Ford Expedition, during the test drive the RPMs ran high on the Expedition and it felt sluggish and “off” crossing a road, and at one point it jumped, and the wrench symbol came on as we were returning. My concern was shrugged off by my salesman, as he said ‘maybe Fords are just like that’. As we returned, and had the issue with the wrench symbol, salesman advised me “ well when you came and interrupted as they were just getting this thing checked out and tested.” 2/19/19 When I returned following days to purchase, the vehicle was not ready. It turned out the battery had died and they had some other issue with a “computer code”. They put in another battery on hand, and told me I should now be “good to go”, knowing that I was in desperate need of a vehicle, and would likely be trusting if they told me it was now repaired. At this point we were within manufacturer’s warranty, and under 60k miles. -was never informed that there was a recall issued by Ford that EXACTLY applied to our vehicle, and to the issue I Reported during my test drive, under warranty, and Preston Ford Mazda never correctly repaired the issue as they stated, which was reported within all Ford and recall time and mileage requirements. [XXX]-while driving suddenly speedometer went out, the gas gauge stopped working, and then, a moment later while trying to figure that out, the vehicle jumped and shuddered/stopped and the RPMS went wild, revving. Almost hit cars, but was able to pull to the side of highway. Upon turning the vehicle off and restarting, normal operation resumed, but issue with the wrench symbol, gauges, RPMs revving and vehicle jump/stop has now happened repeatedly, leaving me with no safe transportation for my large family. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Since more than 18 months, we have the known intermittent problem described in TSB [XXX], where all of a sudden the wrench appears, speedometer drops to zero and car can't change gear anymore. Sometimes going to manual gears works, sometimes car needs to be stopped, locked and completely shut down several times for the problem to go away. Before turning off, error P0720 appears (as described in TSB [XXX]). Car taken to garage in January 2023 where it was for 3 weeks. Technicians drove it for 11 miles (!) and could not reproduce the problem so could not do the required work ie changing the molded leadframe. Now, in January 2024 the problem happened again and this time the Check Engine light came on. The same error code P0720 was now permanently stored. Took the car to the garage, where they were able to diagnose the problem and ... replaced the molded leadframe. This at an out of pocket cost of $1,300. Contacted Ford and they say there is no program or financial assistance in place for this problem, despite all the information that can be found. It is clear this a general problem of all 6R80 gearboxes beyond the time periods stated in the recall. Ford is negligent by not doing a recall on all cars having this gearbox. Nobody is looking at this issue at Ford, when creating a case number they say no program exists, and state paperwork and proof can be sent to a PO BOX in Dearborn (not even an email address to send attachments in this 21st century). All ways to discourage people to react, send in documents or claim documents did not arrive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

REPLACED SWAY BAR LINKS THREE TIMES ON BOTH SIDES

THE STRUTS WERE REPLACED AT 26,344 ON 6/30.16 AND NOW IN OCTOBER 2016 THE NEW ONES ARE ALSO LEAKING OIL AND NOT WORKING. I DRIVE ON PAVED ROADS.

SEVERAL STALLS FOLLOWED BY CRANK NO START CONDITIONS OVER SEVERAL MONTHS WITH NO ASSOCIATED CHECK ENGINE LIGHT, CODE P0627 WHILE VEHICLE IN MOTION. 4M AUTO SERVICE CENTER ABILENE TX PERFORMED FUSE 27 RELOCATION TO FUSE 73 ACCOMPLISHED. VEHICLE RETURNED TO SERVICE. SEVERAL STALLS FOLLOWED BY CRANK NO START CONDITIONS OVER SEVERAL MONTHS WITH NO ASSOCIATED CHECK ENGINE LIGHT, CODE P0627 WHILE VEHICLE IN MOTION. CODE CLEARED, VEHICLE RETURNED TO SERVICE. STALLED FOLLOWED BY CRANK NO START CONDITIONS WITH CHECK ENGINE LIGHT, CODES P025A, U0109 AND P0627 WHILE VEHICLE STATIONARY. 4M AUTO SERVICE CENTER ABILENE TX REPLACED FUEL PUMP CONTROL MODULE. VEHICLE RETURNED TO SERVICE. SEVERAL STALLS FOLLOWED BY CRANK NO START CONDITIONS OVER SEVERAL MONTHS WITH NO ASSOCIATED CHECK ENGINE LIGHT NO CODES. VEHICLE OWNER REPLACED FUEL PUMP DUE TO BURNT WIRE (SEE ATTACHED PHOTO). VEHICLE RETURNED TO SERVICE. CONTACTED 4M AUTO SERVICE CENTER, ARROW FORD ABILENETX AAND FORD MOTOR COMPANY CUSTOMER SERVICE.

PARKING BRAKE FAILED TO HOLD THE VEHICLE AT 1500 RPM WHICH IS REQUIRED IN MASSACHUSETTS TO PASS STATE INSPECTION. IT DOES NOT PERFORM TO SPECIFICATIONS. VEHICLE WAS ABOUT 2 YRS OLD WITH 9500 MILES. DEALER HAD TO REMOVE AND CLEAN PARKING BRAKES PARTS AND REASSEMBLE. I HAD THE EXACT SAME ISSUE WITH 2000 EXPEDITION EVERY YEAR THE PARKING BRAKE WOULD FAIL STATE INSPECTION AND HAD TO BE REPAIRED. I CONSIDER THIS A SAFETY ISSUE AND DESIGN FLAW IF THE PARKING BRAKES CHRONICALLY UNDER PERFORM ON THESE FORD VEHICLES

The contact owns a 2013 Ford Expedition. The contact stated that when she attempted to operate the heating system, she heard a loud whistling sound and knob became stuck on high speed. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the blower motor controller and connector had burned and needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the independent mechanic where it was diagnosed that the blower motor controller and connector needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in a recall and to call the NHTSA Hotline for assistance. The failure mileage was approximately 134,000.

INTERMITTENT PART OF WIPER CONTROL NOT WORKING

THE VEHICLE WILL SWITCH GEARS WHILE TRAVELS NG AT 70 MILES PER HOUR. I IMMEDIATELY PULL TO SIDE AND HAVE TO STOP AUTOMOBILE AND RESTART. THE DASH SHOWS MOTOR AND CHECK ENGINE. AT THIS TIME THE PASSENGER SEAT BELT WILL NOT REMAIN LATCHED. THE AIR CONDITIONER HAS STOPPED WORKING. MY SPOUSE IS A MECHANIC AND CHECKED THE PLUG BELOW THE GLOVE COMPARTMENT. THE PLUG RECEIVER (NOT SURE WHAT IT'S CALLED ) HAD A WHOLE MELTED IN BOTTOM OF FEMALE AND OF PLUG.

TL* THE CONTACT OWNS A 2013 FORD EXPEDITION. WHILE DRIVING 45 MPH, THE REAR PASSENGER DOOR OPENED WITHOUT WARNING. IN ADDITION, THE FRONT DRIVER SIDE DOOR WOULD NOT CLOSE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V643000 (LATCHES/LOCKS/LINKAGES). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.

The contact owned a 2013 Ford Expedition. The contact stated that while driving at an undisclosed speed, he started to see smoke located underneath the front passenger dashboard. The contact then stated that he then noticed that flames had started to ignite. No warning lights were illuminated. The contact stated that he immediately pulled the vehicle off the road and exit the vehicle and as the vehicle flames started to spread throughout the vehicle. No injuries were sustained. No medical attention was required. The fire department was notified and extinguished the fire. A fire report was filed. The vehicle was towed to a tow lot. The contact stated that the vehicle was then towed to an undisclosed lot by the insurance company. The contact was unsure if the vehicle was deemed a total loss. The dealer was not notified of the failure. The contact stated that the vehicle was a total loss. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 150,000.

Lug Nuts cannot be removed due to defective design. Impossible to properly maintain tires or to remove wheel in case of roadside emergency. Each wheel has 6 lug nuts that must ALL work properly together. All 24 of my lug nuts had to be forcibly removed/replaced in order to perform tire maintenance and to be proactive against the safety risk of malfunction while being operated on the road. Ford has never made me aware of this issue. Krause Ford in Woodstock Georgia inspected the lug nuts and recommended replacement at my expense due Ford Corporate not recognizing this as a problem with their product. Tire/wheel maintenance is an important safety issue.

The contact owns a 2013 Ford Expedition. The contact stated while driving 65 MPH, the vehicle independently decelerated to 0 MPH. The check engine warning light and the wrench symbol was illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the failure was due to a faulty main control valve body in the transmission. The vehicle was repaired; however, the failure reoccurred. The manufacturer was made aware of the failure and advised the contact to call NHTSA Hotline for assistance. The failure mileage was approximately 200,080

Transmission fluid cooler line ruptured causing loss of propulsion. There is a known and common problem with the cooler lines breaking at the fitting where the Transmission lines meet the cooler. There is a meeting of dis-similar metals (Aluminum and Steel) in this fitting that is thought to increase the risk of fracture. There are multiple reports of the fitting fracturing in the same place in Ford Forums and Youtube videos. This affects the Ford F150s, Expeditions and similar Lincoln models.

The contact owned a 2013 Ford Expedition. The contact stated while driving 45 MPH, the front passenger's side tire blew out, and she lost control of the vehicle. The contact stated that the front end of the vehicle crashed into an embankment, and the vehicle stopped. The contact stated that the front grill and the bumpers detached due to the impact. The contact stated that the driver's side and the passenger's side roof air bags were deployed; however, the front driver's side air bag failed to deploy, causing the contact to hit her face and her head against the steering wheel. The contact sustained black eyes, bruises on the forehead, a scratch on the scalp that extended to her nose, a swollen nose, a swollen forehead, and swollen eyes. The contact had not received medical assistance. A police report was filed. The vehicle was towed to a tow lot, where it was totaled. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 200,000.

The airbag case/seal is ruptured and splitting in the center of the steering wheel and looks like it will self-deploy on its own. Their airbag warning light is NOT illuminated.

SEVERAL STALLS FOLLOWED BY CRANK NO START CONDITIONS OVER SEVERAL MONTHS WITH NO ASSOCIATED CHECK ENGINE LIGHT, CODE P0627 WHILE VEHICLE IN MOTION. 4M AUTO SERVICE CENTER ABILENE TX PERFORMED FUSE 27 RELOCATION TO FUSE 73 ACCOMPLISHED. VEHICLE RETURNED TO SERVICE. SEVERAL STALLS FOLLOWED BY CRANK NO START CONDITIONS OVER SEVERAL MONTHS WITH NO ASSOCIATED CHECK ENGINE LIGHT, CODE P0627 WHILE VEHICLE IN MOTION. CODE CLEARED, VEHICLE RETURNED TO SERVICE. STALLED FOLLOWED BY CRANK NO START CONDITIONS WITH CHECK ENGINE LIGHT, CODES P025A, U0109 AND P0627 WHILE VEHICLE STATIONARY. 4M AUTO SERVICE CENTER ABILENE TX REPLACED FUEL PUMP CONTROL MODULE. VEHICLE RETURNED TO SERVICE. SEVERAL STALLS FOLLOWED BY CRANK NO START CONDITIONS OVER SEVERAL MONTHS WITH NO ASSOCIATED CHECK ENGINE LIGHT NO CODES. VEHICLE OWNER REPLACED FUEL PUMP DUE TO BURNT WIRE (SEE ATTACHED PHOTO). VEHICLE RETURNED TO SERVICE. CONTACTED 4M AUTO SERVICE CENTER, ARROW FORD ABILENETX AAND FORD MOTOR COMPANY CUSTOMER SERVICE.

THE THROTTLE IS ERRATIC. SOMETIMES ACCELERATION FROM A STOP IS SMOOTH AND SOMETIMES ITS AS IF THE THROTTLE IS BINDING AGAINST SOMETHING. OTHER TIMES THE THROTTLE IS DEPRESSED AND NOTHING HAPPENS UNTIL THE VEHICLE SUDDENLY LURCHES FORWARD. THE LAST EPISODE WAS PULLING INTO A PARKING PLACE AND THE ENGINE SUDDENLY WENT INTO IDLE. I MASHED THE GAS MORE AND MORE AND IT SUDDENLY ALMOST LURCHED OVER THE CURB. I HAVE HAD IT TO[XXX] IN PLANO TEXAS ON SEVERAL OCCASIONS, EVEN LEAVING IT FOR SEVERAL DAYS FOR THEM TO DRIVE. THEY CHANGED SEVERAL ITEMS ON THE TRANSMISSION, BUT IN THE LAST FEW DAYS IT HAS WORSENED(MORE FREQUENT). THERE ARE NO ERROR CODES, BUT IT IS BECOMING UNSAFE TO DRIVE. I HAVE TO LEAVE THE CAR WITH A PARKING VALET WHEN MY WIFE RECEIVES MEDICAL TREATMENT AND THIS COULD BE PROBLEMATIC. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE VEHICLE WILL SWITCH GEARS WHILE TRAVELS NG AT 70 MILES PER HOUR. I IMMEDIATELY PULL TO SIDE AND HAVE TO STOP AUTOMOBILE AND RESTART. THE DASH SHOWS MOTOR AND CHECK ENGINE. AT THIS TIME THE PASSENGER SEAT BELT WILL NOT REMAIN LATCHED. THE AIR CONDITIONER HAS STOPPED WORKING. MY SPOUSE IS A MECHANIC AND CHECKED THE PLUG BELOW THE GLOVE COMPARTMENT. THE PLUG RECEIVER (NOT SURE WHAT IT'S CALLED ) HAD A WHOLE MELTED IN BOTTOM OF FEMALE AND OF PLUG.

NO SAFETY SEAT BELT WARNING LIGHT AND INDICATOR CHIME WHEN ADULT SETTING IN THE PASSENGER SET WITHOUT SEAT BELT FASTENED. VEHICLE ENGINE ON, TRANSMISSION IN DRIVE. THE DRIVERS SIDE WARNING LIGHT AND INDICATOR CHIME WORKS CORRECTLY AS YOU WOULD EXPECT IT TO. THE VEHICLE HAS OPERATED THIS WAY FROM THE DAY WE PURCHASED THE VEHICLE APPROXIMATELY 33 DAYS AGO AND IT NOW HAS 2800 MILES. *TR

2013 FORD EXPEDITION WILL NOT SHIFT OUT OF PARK. VEHICLE WILL NOT REVERSE OR DRIVE. I WAS STUCK AT MY BANK DRIVE THRU. I COULD NOT SHIFT OUT OF PARK TO GO FORWARD OR REVERSE. *TR

TL* THE CONTACT OWNS A 2013 FORD EXPEDITION. THE VEHICLE EXPERIENCED INDEPENDENT BRAKING WHILE BEING OPERATED AT 70 MPH. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE COULD NOT BE DUPLICATED. IN ADDITION, THE FUEL GAUGE AND SPEEDOMETER FAILED TO DISPLAY CORRECT INFORMATION. THE DEALER (FRIENDLY FORD OF CROSBY, 2425 US-90 BUS, CROSBY, TX) DIAGNOSED THAT THE TRANSMISSION MODULE FAILED AND RECOMMENDED IT BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 15410976. THE FAILURE MILEAGE WAS 86,000. *JS

WHILE DRIVING AT APPROXIMATELY 35 MPH WE LOST ALL SYSTEMS INCLUDING EXTERIOR, INTERIOR AND EMERGENCY LIGHTS. WE WERE ABLE TO STOP WITHOUT GOING OFF THE ROAD, ONCE WE HAD STOPPED AND PUT VEHICLE IN PARK WE WERE UNABLE TO GET IT OUT OF PARK. WE COULD TURN THE ENGINE ON AND OFF, BUT STILL COULD NOT GET VEHICLE TO COME OUT OF PARK, NOR COULD WE GET THE LIGHTING SYSTEM TO COME BACK ON, THE ONLY LIGHTS THAT WORKED WERE THE DASH LIGHTS. THE COMPUTER SYSTEM INDICATED: 1- TOW HAUL MALFUNCTION 2- TIRE PRESSURE MANAGEMENT SYSTEM LIGHT ON. HAD VEHICLE TOWED TO FORD DEALER. THEY FOUND SEVERAL MODULES LOST COMMUNICATION WITH BCM, RESET SYSTEM, TEST DROVE BUT UNABLE TO DUPLICATE OR DETERMINE WHAT CAUSED THE PROBLEM. WE WERE IN A VERY DANGEROUS SITUATION AS IT WAS DARK, WE WERE ON A TURN IN THE ROAD AND IN THE CENTER OF THE ROAD WITH NO EMERGENCY LIGHTING. *TR