2026 Ford Expedition Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2026 Ford Expedition, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Other / unspecified428.6%
- Steering428.6%
- Electrical17.1%
- Interior & seats17.1%
- Suspension17.1%
- Brakes17.1%
- Visibility17.1%
- Driver assistance17.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
The empty passenger sea, steering wheel, center console and sun visor has aggressive shake at speeds over 35MPH. Dealer did the road force balance but that didn't fix it, it's something in drivertaina nd they are refusing to fix it. Vehicle seems unsafe to derive
Description On your vehicle it is possible that the trailer module trm may lose communication at vehicle start-up. If a trm loss of communication occurs and a trailer is connected to the vehicle, trailer stop lamps and turn signal indicators will not function. Additionally, for trailers equipped with electronic trailer brakes, the trailer brakes will not function. This loss of communication can occur with-or-without a trailer connected to the vehicle and can only initiate at vehicle start-up. If this occurs, a trailer brake module fault notification will pop-up on the vehicles instrument panel cluster. The vehicle brake and turn signal lamps will continue to operate normally and are not affected by this trm fault. If you do not tow with your vehicle, you may wait for ota deployment for your vehicle remedy. Safety Risk This may result in inoperable trailer brake lights, trailer turn signals and trailer braking functions that can reduce a drivers ability to control an attached trailer and make the trailer less visible to other drivers, increasing the risk of a crash. Remedy Software is available to repair your vehicle. Ford Motor Company has authorized your dealer to reprogram your vehicles trm free of charge. Next Steps Contact your dealer for more information to schedule the free service.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
The empty passenger sea, steering wheel, center console and sun visor has aggressive shake at speeds over 35MPH. Dealer did the road force balance but that didn't fix it, it's something in drivertaina nd they are refusing to fix it. Vehicle seems unsafe to derive
The contact owns a 2026 Ford Expedition MAX. The contact stated that while driving at 70 MPH or higher speeds, the steering wheel shuddered due to a front suspension issue. The contact completed some research online and learned that it was a known failure associated with 2025 - 2026 model years. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 800.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
Description On your vehicle it is possible that the trailer module trm may lose communication at vehicle start-up. If a trm loss of communication occurs and a trailer is connected to the vehicle, trailer stop lamps and turn signal indicators will not function. Additionally, for trailers equipped with electronic trailer brakes, the trailer brakes will not function. This loss of communication can occur with-or-without a trailer connected to the vehicle and can only initiate at vehicle start-up. If this occurs, a trailer brake module fault notification will pop-up on the vehicles instrument panel cluster. The vehicle brake and turn signal lamps will continue to operate normally and are not affected by this trm fault. If you do not tow with your vehicle, you may wait for ota deployment for your vehicle remedy. Safety Risk This may result in inoperable trailer brake lights, trailer turn signals and trailer braking functions that can reduce a drivers ability to control an attached trailer and make the trailer less visible to other drivers, increasing the risk of a crash. Remedy Software is available to repair your vehicle. Ford Motor Company has authorized your dealer to reprogram your vehicles trm free of charge. Next Steps Contact your dealer for more information to schedule the free service.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
The empty passenger sea, steering wheel, center console and sun visor has aggressive shake at speeds over 35MPH. Dealer did the road force balance but that didn't fix it, it's something in drivertaina nd they are refusing to fix it. Vehicle seems unsafe to derive
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
The contact owns a 2026 Ford Expedition MAX. The contact stated that while driving at 70 MPH or higher speeds, the steering wheel shuddered due to a front suspension issue. The contact completed some research online and learned that it was a known failure associated with 2025 - 2026 model years. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 800.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
Description On your vehicle it is possible that the trailer module trm may lose communication at vehicle start-up. If a trm loss of communication occurs and a trailer is connected to the vehicle, trailer stop lamps and turn signal indicators will not function. Additionally, for trailers equipped with electronic trailer brakes, the trailer brakes will not function. This loss of communication can occur with-or-without a trailer connected to the vehicle and can only initiate at vehicle start-up. If this occurs, a trailer brake module fault notification will pop-up on the vehicles instrument panel cluster. The vehicle brake and turn signal lamps will continue to operate normally and are not affected by this trm fault. If you do not tow with your vehicle, you may wait for ota deployment for your vehicle remedy. Safety Risk This may result in inoperable trailer brake lights, trailer turn signals and trailer braking functions that can reduce a drivers ability to control an attached trailer and make the trailer less visible to other drivers, increasing the risk of a crash. Remedy Software is available to repair your vehicle. Ford Motor Company has authorized your dealer to reprogram your vehicles trm free of charge. Next Steps Contact your dealer for more information to schedule the free service.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
Instrument panel reflection is causing a windshield glare that impairs driver visibility during normal operation. The issue originates from the panoramic display screen located behind the steering wheel. The back surface of the display is built too close to the windshield glass and causes a strong reflection that projects high onto the inside of the windshield during normal driving conditions. This reflection appears to be a design or material-related defect rather than a one-time failure. The issue occurs consistently during daytime driving when sunlight is present and is easily reproducible. I have reported the issue to the dealership and am in the process of having it formally evaluated and documented. There were no warning lamps or messages. The issue occurs during normal driving conditions when sunlight interacts with back of the instrument display.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
With speeds in excess of 70 MPH, the car have a violent shake. The shake gets worse as you approach 80 MPH. This is in both the 2025 and 2026 Ford Expedition models. This put drivers at risk, as they must keep control of the car at all times on the highway if they are in excess of 70 MPH. The car has already been inspected by Ford and they did a road balance test and replaced one tire. The car still shakes at high speeds. Ford is looking to bring my car in a 2nd time to look at the issue again. No warning lights came on. This appears to be a driving issue not related to anything that would come up electronically.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .