2021 Ford Explorer Hybrid Problems

On July 8, 2026, I was traveling westbound on Highway 7 when another vehicle pulled right out in front of me from southbound Orchard Road, attempting to cross the highway. We collided and I struck the other vehicle at a 45° angle. My seatbelt was buckled. The impact caused me to be thrown forward into the windshield which I broke with my skull. I suffered a broken neck. The seatbelt did not operate properly to keep me secure in the seat. There's no way I should've struck the windshield if the seatbelt would've worked. Not only did the shoulder belt not work, but the lap belt did not work either because I came up and out of the seat. Also, the airbag did not prevent me from striking the windshield. There is something wrong with the seatbelt operation as well as the airbag. I have contacted Ford to inspect the vehicle. The vehicle was inspected by the Harrisonville Missouri Police Department.

The contact owns a 2021 Ford Explorer Hybrid. The contact stated that while driving at various speeds, the electronic "lift gate ajar" warning was activated; however, the liftgate was not open. The vehicle was taken to the local dealer who adjusted the liftgate striker, and the failure was remedied; however, the failure reoccurred. Additionally, while driving at speeds between 5 - 20 MPH, the vehicle started jerking and vibrating with the RPM’s extremely elevated. The vehicle was taken to the local dealer, but the cause of the failure was not identified. The dealer indicated that the jerking and vibration were normal for a hybrid vehicle. The manufacturer was notified of the failure. The failure mileage was 22,000.

The contact owns a 2021 Ford Explorer Hybrid. The contact stated that after restarting the vehicle, there was a burning odor present. The message "Pull Over Possible Powertrain Damage" was displayed. The vehicle was towed to the local dealer who determined that the high voltage junction box had overheated and was burned. The high voltage junction box and high voltage junction box wiring harness were replaced, and the vehicle was repaired. The manufacturer was notified of the failure and indicated that the VIN was not included in the NHTSA Campaign Number: 23V626000 (Electrical System). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 96,147.

A Police Officer's Ford Explorer Interceptor Hybrid SUV while driving had a vehicle malfunction where the rear wheels began to wobble/vibrate and while driving in a straight line with front wheels facing straight caused the vehicle to fishtail out of the control (loss of control to the rear wheels) and slam into a tree at approximately 50mph injuring the officer. Officer's injuries were broken left leg and two knee fractures. Upon further research, this incident may have been caused by the "rear bolt" fracture issue Ford is having with these specific Ford Explorers. This specific vehicle is under recall per the VIN. The Officer's safety was put at risk because the vehicle was most likely not recalled and fixed per the recall. The vehicle has not been inspected by manufacturer or any qualified/certified individual. No other issues or symptoms were present prior to this incident. The vehicle is available for inspection upon request with the BART Police Department in Oakland, CA.

A Police Officer's Ford Explorer Interceptor Hybrid SUV while driving had a vehicle malfunction where the rear wheels began to wobble/vibrate and while driving in a straight line with front wheels facing straight caused the vehicle to fishtail out of the control (loss of control to the rear wheels) and slam into a tree at approximately 50mph injuring the officer. Officer's injuries were broken left leg and two knee fractures. Upon further research, this incident may have been caused by the "rear bolt" fracture issue Ford is having with these specific Ford Explorers. This specific vehicle is under recall per the VIN. The Officer's safety was put at risk because the vehicle was most likely not recalled and fixed per the recall. The vehicle has not been inspected by manufacturer or any qualified/certified individual. No other issues or symptoms were present prior to this incident. The vehicle is available for inspection upon request with the BART Police Department in Oakland, CA.

On July 8, 2026, I was traveling westbound on Highway 7 when another vehicle pulled right out in front of me from southbound Orchard Road, attempting to cross the highway. We collided and I struck the other vehicle at a 45° angle. My seatbelt was buckled. The impact caused me to be thrown forward into the windshield which I broke with my skull. I suffered a broken neck. The seatbelt did not operate properly to keep me secure in the seat. There's no way I should've struck the windshield if the seatbelt would've worked. Not only did the shoulder belt not work, but the lap belt did not work either because I came up and out of the seat. Also, the airbag did not prevent me from striking the windshield. There is something wrong with the seatbelt operation as well as the airbag. I have contacted Ford to inspect the vehicle. The vehicle was inspected by the Harrisonville Missouri Police Department.

I was making a slow speed u-turn to stop a speeding motorist. As I came out of the u-turn, the wheel did not come back to center and I continued the turn going up a curb and striking a chain link fence. When I realized what was occurring, I manually began to turn the steering wheel to the right to get back on the roadway. There is patrol car dash cam footage of this collision. Police report# 23-688.

The contact owns a 2021 Ford Explorer Hybrid. The contact stated that while driving at various speeds, the electronic "lift gate ajar" warning was activated; however, the liftgate was not open. The vehicle was taken to the local dealer who adjusted the liftgate striker, and the failure was remedied; however, the failure reoccurred. Additionally, while driving at speeds between 5 - 20 MPH, the vehicle started jerking and vibrating with the RPM’s extremely elevated. The vehicle was taken to the local dealer, but the cause of the failure was not identified. The dealer indicated that the jerking and vibration were normal for a hybrid vehicle. The manufacturer was notified of the failure. The failure mileage was 22,000.