2007 Ford Explorer Sport Trac Engine Problems

ISSUE FEB 2018 - PRESENT I BOUGHT MY 2ND- HAND 2007 FORD SPORT TRAC IN FEBRUARY 2018, FROM THE ORIGINAL OWNER. WE HAD EXPERIENCED 2 CAT-FIVE HURRICANES; POWER AND INTERNET WAS ALMOST NONEXISTENT, SO I COULD NOT RESEARCH THE TRUCK. ON THE SECOND DAY AFTER MY PURCHASE, WHILE DRIVING DOWN A STREET AT ABOUT 30 MPH, IT STALLED. I HAD VERY LITTLE BREAKS AND NO STEERING. WHEN I TRIED TO CRANK IT, IT WOULD TURN OVER BUT NOT FIRE. FOR THE LAST TWO YEARS, I HAVE HAD NO LUCK FIXING THE ISSUE. UPON RESEARCH, THERE ARE HUNDREDS OF BLOGS/ QUESTIONS / ATTEMPTS TO REPAIR FROM OWNERS TRYING TO FIX THE SAME ISSUE. ONE BLOG SAID THAT IT HAD BEEN REQUESTED FOR FORD TO DO A RECALL, BUT FORD DENIED THAT THERE WAS AN ISSUE. IT MAY DRIVE GREAT FOR 3 WEEKS AND THEN WHEN YOU ARE DRIVING STRAIGHT DOWN A STEEP, CURVY MOUNTAIN IN TRAFFIC, IT TURNS OFF WITH NO WAY TO STOP QUICKLY OR CONTROL THE STEERING. IF YOU DRIVE TOO SLOWLY OR SOMEONE PULLS IN FRONT OF YOU AND DRIVES 5 MILES AN HOUR, IT WILL STOP. IF YOU PUNCH THE GAS PEDAL TO GET OUT OF THE WAY OF A DANGEROUS SITUATION, IT WILL OFTEN STALL. SOMETIMES IT WON'T DRIVE, AND THEN IT SURGES FORWARD. IT OFTEN SOUNDS LIKE THE FUEL IS RUNNING RICH. YOU NEVER KNOW WHEN IT WILL HAPPEN SO YOU ARE ALWAYS IN DANGER. I HAVE CHANGED OUT THE STARTER SWITCH, SHIFT LINKAGE, JUST ABOUT EVERY SENSOR, PUMP, FILTER, WIRING, EGR VALVE, THROTTLEBODY' ANOTHER ORIGINAL OWNER ON ISLAND SAID HE'S READY TO DRIVE HIS OFF OF A CLIFF AFTER DEALING WITH THIS PROBLEM FOR THREE YEARS. HIS TRUCK IS A 2010 I BELIEVE. I CHECKED BACK WITH HIM RECENTLY. HE CHANGED OUT HIS COMPUTER SYSTEM AND IT IS NOW RUNNING PROPERLY FOR THE MOMENT. I CAN'T SELL MY TRUCK BC MY ETHICS WON'T ALLOW IT. I CAN'T TRASH IT BC I NEED TO SELL IT TO BUY ANOTHER. I BOUGHT THE TRUCK TO BE SAFE. IT HAS DONE NOTHING BUT PLACED ME IN DANGER AND DEPLETED MY WALLET.

NHTSA ID

11309675

Incident

Feb 13, 2020

Mileage

40,000 mi

MY CAR STALL INTERMITTENTLY OVER THE LAST FEW YEARS. SEEMS TO BE WHEN I BREAK. I UNDERSTAND THIS HAS BEEN HAPPENING WITH A LOT OF FORD VEHICLES AND SHOULD BE LOOKED INTO.

NHTSA ID

10920006

Incident

Oct 27, 2016

Mileage

100,000 mi

OK WHERE CAN I START BESIDES THAT I'VE COME TO HATE MY TRUCK I HAVE SPENT THOUSANDS OF DOLLARS FIXING IT CONSTANTLY FIRST OFF LIGHT IN THE CAR GO ON AND OFF WHILE DRIVING WHENEVER YOU HIT A BUMP THAN I GET RANDOM LITTLE LEAKS ALL THE TIME AND HAD MY TRANSMISSION WORKED ON A YEAR AGO BECAUSE IT WAS MESSED UP AND HERE IT GOES AGAIN I DON'T KNOW WHAT THE [XXX] IS WRONG WITH IT BUT SOMETIMES I SWEAR I JUST WANNA THROW THE [XXX] CAR OFF A BRIDGE EVERY OTHER DAY THERE'S ANOTHER PROBLEM NOT MY AC HAS STOPPED WORKING I WAS DRINKING HOME FROM THE GYM YESTERDAY MORNING AT A RED LIGHT HE CAR SHUT OFF LOCKED MY STEERING WHEEL LOCKED MY DOORS LOCKED MY BRAKE STARTED BEEPING ON MY DASH WOULDN'T LET ME DO ANYTHING THAT'S DANGEROUS IT WAS A MAJOR ROAD WITH THE LIGHT JUST TURNING GREEN I'M STUCK CAN'T EVEN PUT IT IN NEUTRAL AND ROLL IT OUT OF THE INTERSECTION I TURNED IT OFF AND TURNED IT OFF DROVE IT HOME WOKE UP NEXT MORNING FOUND SOMETHING LEAKING DROVE TO WORK NOT ITS HAVING PROBLEMS SHIFTING I'M SO DONE WITH THIS TRUCK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10883795

Incident

Jul 9, 2016

Mileage

114,000 mi

MY FORD EXPLORER 2007 HAS VERY LOW MILEAGE (56,000 MILES). ITS ENGINE STARTED TO SHUT OFF INTERMITTENTLY UNDER ALL TYPES OF CONDITIONS, STREETS AND HIGHWAYS. IT WAS INDEED VERY DANGEROUS. INDEED MY DAUGHTER, DRIVING THIS CAR, HAD AN ACCIDENT ON SEPT. 4, PRECISELY BECAUSE OF THE ENGINE SHUT OFF. FORTUNATELY IT HAPPENED IN A STOP-AND-GO TRAFFIC WHICH DID NOT RESULT IN ANY INJURY. I HATE TO THINK OF CONSEQUENCES OF THIS HAPPENING IN FAST MOVING TRAFFIC. MY RESEARCH SHOWED THAT THIS PROBLEM IS VERY COMMON FOR THESE AUTOS, AND IT SEEMS THAT IT IS NOT TAKEN CARE OF. AFTER HAVING MY MECHANICS CHECK EVERY CONCEIVABLE PROBLEM, I WAS REFERRED TO THE FORD DEALERSHIP. THEIR DIAGNOSIS DETERMINED THE INTERNAL PCM FAILURE TO BE THE CAUSE. IT TURNED OUT THAT THIS PART IS BELIEVED TO BE DEFECTIVE BECAUSE OF ITS DESIGN, AND A NEW ONE IS DEVELOPED WHICH IS ON BACK ORDER. I WAS LUCKY TO FIND A NEW PART AND HAD IT SHIPPED TO SOUTHERN CALIFORNIA AND INSTALLED. I HOPE THE PROBLEM IS RESOLVED. IT COST ME $1,546.41, WHICH I DO NOT THINK I SHOULD HAVE PAID ESPECIALLY WITH SUCH LOW MILEAGE. I THINK THIS IS A CASE OF BAD/DEFECTIVE DESIGN OF THE PCM, WHICH IS ALSO A SAFETY PROBLEM AND I THINK THE FORD COMPANY SHOULD HAVE RECALLED AND REPLACE THIS PART FREE OF CHARGE.

NHTSA ID

10780915

Incident

Sep 4, 2015

Mileage

56,000 mi

PASSENGER SIDE EXHAUST MANIFOLD BOLTS HAVE BROKEN AT 65K MILES. AFTER RESEARCHING THIS SEEMS TO BE A KNOWN PROBLEM FORD HAS AVOIDED RECALLING. I EASILY FOUND 25 PLUS CASES OF EXPLORER SPORTTRAC OWNERS WITH THE 4.6 V8 REPORTING THIS EXACT PROBLEM. FORD CHARGES OVER 3K TO FIX WHAT SEEMS TO BE A FAULTY DESIGN THAT HAPPENS ON THE MAJORITY OF THESE VEHICLES.

NHTSA ID

10780566

Incident

Oct 1, 2015

Mileage

65,000 mi

THE TRUCK HAS BEEN LEAKING COOLANT. THE MECHANIC FINALLY FOUND THE PROBLEM. THE INTAKE ON THE MANIFOLD IS PLASTIC. IT GETS OVERHEATED ON THE METAL MANIFOLD AND CRACKS WHICH CAUSES COOLANT TO LEAK. WE'VE SPENT OVER $1000 GETTING REPAIRS. STILL LEAKS DUE TO THAT ONE FAULTY PART. EVERYTHING I'VE READ INDICATES THAT FORD IS AWARE OF THE PROBLEM BUT HAS TAKEN NO STEPS TO CORRECT IT. THEY DID CLAIM THAT REPROGRAMMING THE THERMOSTAT SETTINGS WAS ALL IT NEEDED BUT THAT IS NOT TRUE. *TR

NHTSA ID

10706505

Incident

Dec 15, 2014

STOPPED TO GET FUEL AND TRUCK WOULD NOT START. ENGINE WOULD TURN OVER, BUT WOULD NOT START. I HAD VEHICLE TOWED TO THE FORD DEALERSHIP. TOLD BY THE FORD SERVICE MANAGER THAT IT WAS THE FUEL CONTROL MODULE LOCATED BY THE REAR SPARE TIRE AND THEY HAVE REPLACED MANY OF THEM. THE FORD DEALERSHIP CONFIRMED IT AND REPLACED THE FUEL CONTROL MODULE. MY COST $386.93. WE HAD PURCHASED A EXTENDED MOTOR VEHICLE SERVICE AGREEMENT (NATIONAL PROTECTION PLAN, INC.) FROM CAPITAL FORD IN MADISON, WI. WE WERE TOLD WHEN WE PURCHASED THE POLICY IT WAS A BUMPER TO BUMPER AND THE COMPANY WILL NOT STAND BEHIND POLICY. *TR

NHTSA ID

10511295

Incident

May 6, 2013

Mileage

72,481 mi

(YEAR 2011 TO 2013 ALL THIS HAPPENED LEMON) THE WHEEL BEARINGS WENT ON THE VEHICLE...HAD TO HAVE ALL THREE REPLACED...BOTH FRONT ...ONE DRIVERS SIDE BACK. IT WASN'T THE TIRES BECAUSE THEY WERE BRAND NEW.( $2.100 INCLUDING LABOR) THE MECHANIC STATED THAT NEVER SHOULD HAVE HAPPENED. THIS SEEMS TO BE AN ON GOING PROBLEM WITH SPORT TRACS ...I AM TO HAVE THE RIGHT REAR PASSENGER SIDE DONE SOON ...NO ONE HAS OVER $700...TO PUT TOWARDS A VEHICLE IN THIS DAY AND AGE WITH THE ECONOMY THE WAY IT IS. THIS SPORT TRAC HAS BEEN WITH SO MANY ISSUES TO DO WITH WHEELS, TRANSMISSION (ONE MONTH IN THE REPAIR SHOP, REVERSE AND DRIVE GONE ON THE TRANNY( $6897.65), RADIATOR (REPLACED 3X DUE TO RUPTURE OF THE, COOLING AND HEATING SYSTEM $1017.), HOSES BREAKING ($200)...NO WONDER THEY QUIT MAKING THEM TOTAL PAIN IN THE KEESTER AND VERY HARD ON THE POCKET BOOK. IT IS PAID FOR AND IS MINE THAT IS THE ONLY REASON I KEEP IT. I CANNOT AFFORD TO GET ANOTHER VEHICLE...BUT I WILL NEVER BUY ANOTHER FORD AGAIN. THEIR SERVICE SAYS IT ALL...IT IS HORRIBLE. SINCE PURCHASING THIS VEHICLE I HAVE SPENT $10,903.65 IN REPAIRS. THE TRUCK IS VERY HARD ON TIRES...I DON'T SQUEAL MY TIRES BUT I TRAVEL 70 TO AND FROM DAILY FOR WORK..EVERY YEAR BABY NEEDS NEW RUBBER BOOTS. $689. NOT FAIR IN ALL ESSENCE THE VEHICLE IS ONLY 6 YRS OLD. I HAVE HAD BETTER AND IT CERTAINLY WASN'T A FORD. YOU CAN SHARE THIS WITH THEM IF YOU LIKE BECAUSE THEY NEED TO SEE THAT THEIR SERVICE DEPARTMENT DID NOTHING FOR ME AND I TOOK IT TO ACUTE AUTO CARE FOR MY TRANSMISSION ETC. *TR

NHTSA ID

10510511

Incident

Mar 18, 2011

Mileage

77,000 mi

AS CITED BY OTHER READERS, FORD HAS PLACED HT-1 CERAMIC PLUGS IN THE EXPLORER SERIES WHICH ARE VERY EXPENSIVE. THESE PLUGS CONSTANTLY DEVELOP STRESS CRACKS AND BREAK DURING REPLACEMENT, REQUIRING A SPECIAL TOOL TO REMOVE THEM. WHEN THEY BREAK (2~3 ON AVERAGE), BE READY TO PAY ADDITIONAL CHARGES TO COVER THE EXTRA TIME NEEDED FOR REMOVAL/CLEAN-OUT BY THE MECHANIC. SOMETHING NEEDS TO BE DONE BY FORD TO REPLACE THESE PLUGS. *TR

NHTSA ID

10462092

Incident

May 16, 2012

Mileage

100,000 mi

WITHOUT ANY INDICATION WHY, THE TEMPERATURE INDICATOR BEGAN TO RISE AND THE ENGINE BECAME RATHER LOUD. NO INDICATOR (IDIOT LIGHTS) LIGHTS CAME ON AT ALL. PULLED OVER TO CHECK THE ENGINE, LEFT THE ENGINE RUNNING AND THE HEAT INDICATOR RETURNED TO NORMAL IMMEDIATELY. STARTED TO DRIVE AND THE SAME ISSUE STARTED AGAIN. THIS TIME I PULLED OVER AND SHUT THE ENGINE DOWN COMPLETELY. RESTARTED THE ENGINE 2~3 MINS LATER, WHICH APPEARS TO HAVE RE-SET THE SYSTEM, AS I HAVE NOT HAVE A SIMILAR PROBLEM SINCE. *TR

NHTSA ID

10462081

Incident

Jun 9, 2012

Mileage

105,000 mi

I NOTICED WHILE DRIVING MY 2007 FORD EXPLORER SPORT TRAC THAT SOMETHING WAS WRONG WITH THE ENGINE. I THOUGHT IT MIGHT BE THE TRANSMISSION, BECAUSE WHEN ACCELERATED IT WOULD BECOME SLUGGISH AND MAKE A LOUD ROARING NOISE. THE TEMPERATURE LIGHT CAME ON FOR ABOUT 8 SECONDS AND THE TEMPERATURE GAUGE WENT TO THE TOP FOR ABOUT THE SAME AMOUNT OF TIME. THEN THE LIGHT WENT OFF AND THE GAUGE WENT BACK TO NORMAL. THEN ENGINE SOUND AND SPEED APPEARED TO BE NORMAL. *JS

NHTSA ID

10458525

Incident

May 15, 2012

Mileage

45,000 mi

SPARK PLUGS MAY BE CONTRIBUTING TO A SKIP UNDER LOAD. HOWEVER, FORD HAS USED SOME UNUSUAL SPARK PLUG THAT IS A SERIOUS PROBLEM FOR END USERS TO EITHER CHANGE THEMSELVES OR EXTRAORDINARILY EXPENSIVE FOR THE CONSUMER TO HAVE CHANGED BY FORD. FORD SERVICE QUOTE IS $300.00 TO HAVE CHANGED. THIS IS A TERRIBLE DESIGN AND ENGINEERING SCREW UP THAT IS RIDICULOUS. FORD NEEDS TO STEP UP AND ADMIT THEY HAVE A POOR DESIGN AND NOT KEEP CHARGING CUSTOMERS FOR THEIR MISTAKE. *TR

NHTSA ID

10452125

Incident

Feb 1, 2012

Mileage

77,250 mi

I HAD MISFIRES ON CYLINDER 7, TRIED TO REPLACE PLUGS HAD FOUR BREAK IN MANIFOLD, FOUND THAT SPECIALITY TOOL HAD TO BE BOUGHT TO REPLACE PLUGS THAT BREAK, ALSO FOUND THAT FORD SERVICE WAS WELL AWARE OF PROBLEMS WITH PLUGS AND THEY CHARGE EXTRA TO REMOVE AND REPLACE BROKEN PLUGS. FORD ENGINEERED A FAULTY PRODUCT AND BECAUSE THE NTSB HAS NOT SLAPPED THEIR HANDS THEY WILL NOT MAKE ANY AMENDS TO THEIR CUSTOMERS FOR REPLACEMENT OF PLUGS. SOMETHING SHOULD BE DONE TO MAKE THEM REPLACE THE PLUGS FOR A NON DEFECTIVE PART. *TR

NHTSA ID

10449226

Incident

Feb 3, 2012

Mileage

89,000 mi

PURCHASED 2007 EXPL SP TRAC IN APRIL 2008 FROM ACADEMY FORD LAUREL, MD (19K MI). RADIATOR LEAK AND REPLACEMENT IN MAY 2011 (38.5K MI). RADIATOR LEAKING AGAIN AT 59K MI. *TR

NHTSA ID

10442106

Incident

May 9, 2011

Mileage

38,550 mi

TL* THE CONTACT OWNS 2007 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THE THERMOSTAT THAT CONTROLS THE TEMPERATURE IN THE VEHICLE MALFUNCTIONED. THE CONTACT CALLED THE MANUFACTURER REGARDING THE THERMOSTAT AND WAS ADVISED THERE WAS NO RELATED RECALL. THE CONTACT STATED THE AIR CONDITIONER ALSO FUNCTIONED SPORADICALLY AT TIMES DURING HOT WEATHER. THE CONTACT STATED THE VEHICLE WAS UNSAFE TO DRIVE DUE TO THE EXTREME HEAT. THE FAILURE MILEAGE WAS 85,000.

NHTSA ID

10415032

Incident

Nov 15, 2010

Mileage

85,000 mi

RADIATOR IS LEAKING COOLANT. COOLANT LEAKS THE FROM ALUMINUM CORE, POOLS UP AT THE BOTTOM IN THE PLASTIC AND DRIPS OUT FROM THE BOTTOM OF THE PLASTIC ON BOTH THE DRIVER AND PASSENGER SIDE. TALKED TO FORD ABOUT THE ISSUE AND THEY SAID THERE WAS A TSB ISSUED FOR THIS (WHICH I REALIZE DOES NOT EXTEND THE WARRANTY) AND THAT WHEN THE TRUCK WAS MADE, THE FAN THAT COOLS THE RADIATOR WAS NOT PROGRAMMED CORRECTLY. IT WOULDN'T RUN WHEN IT NECESSARILY NEEDED TO OR FOR AS LONG AS IT NEEDED TO WHICH IS CAUSING THE RADIATOR TO OVERHEAT AND THE ALUMINUM TO SEPARATE AT THE SEAM...THUS CAUSING A COOLANT LEAK AND LEADING TO THE VEHICLE OVERHEATING. UNFORTUNATELY, THE ONLY FIX WAS JUST TO REPLACE THE RADIATOR WITH AN "UPDATED" RADIATOR AND HAVE THE PROGRAMMING UPDATED FOR THE FAN TO FUNCTION LIKE IT SHOULD HAVE IN THE FIRST PLACE. (NOT SURE I AGREE WITH PAYING A LOT OF MONEY TO FIX SOMETHING THAT SHOULD HAVE WORKED PROPERLY IN THE FIRST PLACE.)

NHTSA ID

10388649

Incident

Aug 1, 2010

Mileage

76,800 mi

ON 8/10/10 I NOTICED WHILE DRIVING MY 2007 FORD EXPLORER SPORT TRAC THAT SOMETHING WAS WRONG WITH THE ENGINE. I THOUGHT IT MIGHT BE THE TRANSMISSION, BECAUSE WHEN ACCELERATED IT WOULD BECOME SLUGGISH AND MAKE A LOUD ROARING NOISE. I CALLED THE FORD DEALERSHIP AND ASKED FOR AN APPOINTMENT TO BRING MY TRUCK IN. THEY SUGGESTED I BRING IT ON THE MORNING OF 8/11/10 FOR THEM TO CHECK IT OUT. AROUND NOON ON 8/11/10 THE SERVICE MANAGER CALLED ME TO INFORM ME THAT THE PROBLEM WAS NOT MY TRANSMISSION, BUT THAT I HAD A LEAK IN THE RADIATOR. HE ALSO SAID THAT HE HAS HAD SEVERAL OF THE SAME TYPE VEHICLES COME IN TO HIS SHOP WITH THE SAME ISSUE WITH THEIR RADIATORS. HE SUGGESTED THAT THEY REMOVE THE RADIATOR AND TAKE IT TO A REPAIR SHOP TO SEE IF IT COULD BE REPAIRED. ON 8/12/10 THE SERVICE MANAGER PHONED ME TO TELL ME THAT THE RADIATOR COULD NOT BE REPAIRED DUE TO MORE THAN ONE LEAK IN THE RADIATOR. HE ADVISED ME NOT TO PURCHASE A NON FACTORY MADE RADIATOR AND SUGGESTED THAT I ALLOW HIM TO ORDER ONE FROM THE DEALERSHIP AND REPLACE MY DEFECTED ONE. ON 8/13/10 I WAS ABLE TO PICK UP MY TRUCK AFTER PAYING $583.05 FOR A NEW RADIATOR $15.52 FOR A NEW CAP AND $14 FOR ANTI FREEZE, NOT TO MENTION THE $75 FOR THE COST OF LABOR. ON 8/17/10, I PHONED NHTSA TO SEE IF THERE HAD BEEN A RECALL ON THE RADIATOR THAT I NEVER RECEIVED. NO RECALLS HAVE BEEN ISSUED AT THIS TIME, BUT THERE HAVE BEEN OTHER COMPLAINTS FROM THIS SAME MODEL VEHICLE WITH RADIATOR ISSUES. I WAS TOLD TO CALL FORD AND ISSUE A FORMAL COMPLAINT BY PHONE. I DID THIS AND WAS GIVEN A REF # [XXX]. I WOULD LIKE FOR THERE TO BE AN INVESTIGATION AND IF POSSIBLE A RECALL ISSUED FOR OWNERS OF THIS SAME TYPE VEHICLE. I WOULD ALSO LIKE SOME REIMBURSEMENT FOR THE EXPENSE I WAS OUT GETTING A NEW RADIATOR FOR MY VEHICLE. FROM WHAT I UNDERSTAND, THESE RADIATORS COULD HAVE BEEN DEFECTIVE AT THE TIME OF ASSEMBLY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

NHTSA ID

10349949

Incident

Aug 10, 2010

Mileage

59,250 mi

AT APPROXIMATELY 40000 MILES I NOTICE A LEAK IN THE RADIATOR ON THE LOWER LEFT SIDE. THE DEALER SERVICE DEPARTMENT INFORMED ME THAT THEY HAD SEEN A NUMBER OF THESE AND THAT IT WAS LEAKING ON A SEAM AND THAT IT NEEDED TO BE REPLACED AT A COST OF OVER $500. I HAD THEM ORDER A REPLACEMENT AND IT IS DUE TO BE REPLACED 03/29/2010. IF THIS IS KNOWN TO HAPPEN WHY IS THERE NO PARTLY TO FULL COVERAGE FOR A DEFECTIVE ITEM?

NHTSA ID

10322503

Incident

Mar 22, 2010

Mileage

40,000 mi

THE VEHICLE LEAKING FLUID FROM THE RADIATOR. CAUSING ENGINE TO RUN HOT. ALSO THE LUMBAR IN THE DRIVERS SEAT EXPLODES PUSHING YOU IN TO THE STEERING WHEEL WHILE DRIVING. *TR

NHTSA ID

10301976

Incident

Dec 12, 2009

Mileage

3,000 mi

TL*THE CONTACT OWNS A 2007 FORD EXPLORER SPORT TRAC. SHE STATED THAT SHE NOTICED RUST INSIDE THE ENGINE COMPARTMENT, AND THE DRIVE SHAFT MECHANISM. SHE ALSO NOTICED RUST UNDER ALL THE SEATS OF THE VEHICLE. THE DEALER STATED THAT THIS WAS SURFACE RUST DUE TO THE CORROSIVE ENVIRONMENT. THEY ALSO STATED THIS IS A NORMAL OCCURRENCE FOR NEW VEHICLES MANUFACTURED BY FORD. THE DEALER INSTRUCTED THE CONTACT SHE COULD WIPE THE RUST OFF USING A TOWEL. THE FAILURE MILEAGE WAS 360 AND THE CURRENT MILEAGE WAS 700.

NHTSA ID

10193042

Incident

May 25, 2007

Mileage

360 mi

ENGINE SHUTS OFF DURING SLOWING FOR TURN OR STOP CAUSING LOSS OF POWER STEERING AND POWER BRAKES. THIS HAS ALMOST CAUSED AN ACCIDENT SEVERAL TIMES. DEALER SAYS THEY CAN NOT REPAIR AND CAN NOT DUPLICATE PROBLEM. DEALER DOES NOT TAKE THE PROBLEM SERIOUSLY. I BELONG TO A SPORT TRAC CLUB AND OTHER 2007 SPORT TRACS HAVE THIS PROBLEM. *NM

NHTSA ID

10170336

Incident

Sep 10, 2006

Mileage

3,000 mi