1999 Ford Explorer Sport Visibility Problems

FRONT WINDSHIELD WIPER FAILURE:FRONT WINDSHIELD WIPERS FAIL TO WORK CONSISTENTLY. WIPERS COME ON EVEN THOUGH IT IS SET TO THE OFF POSITION. SOMETIMES WIPERS DO NOT COME ON WHEN THEY ARE TURNED TO THE ON POSITION. IN ORDER FOR WIPERS TO WORK CONSISTENTLY THEY WOULD HAVE TO BE MANUALLY ENGAGE WITH HAND AND HAND HAS TO BE KEPT ON THE WIPER CONTROL SWITCH SWITCHING IT ON AND OFF TO MOVE THE WIPER BLADES. WIPERS WOULD COME ON INTERMITTENTLY WHILE DRIVING. WIPERS WOULD ACT ERRATICALLY AND FAIL TO OPERATE PROPERLY 90% OF THE TIME. WIPERS SOMETIMES WOULD COME ON AFTER VEHICLE HAS WARMED UP. WIPERS CAN COME ON ANYTIME WHILE DRIVING. FAULTY HOOD/WEAK HYDRAULIC ARMS: THE HOOD CANNOT SAFELY STAY UP BECAUSE THE HYDRAULIC ARM SUPPORTS ARE TOO WEAK TO HOLD THE WEIGHT OF THE HOOD. THE HOOD SUPPORT DOES NOT LOCK INTO PLACE SO THAT THE HOOD WOULD STAY UP SAFELY. NO SAFETY BAR WAS INSTALLED ON THIS VEHICLE TO SAFELY HOLD UP/PROP UP THE HOOD IN CASE OF HYDRAULIC ARM/SUPPORT FAILURE. IF THE VEHICLE GETS BUMPED WHILE THE HOOD IS UP THE HOOD WOULD FALL AND CLOSE SHUT. BECAUSE THE HOOD WILL NOT STAY UP IT REQUIRES TWO PEOPLE WHEN CHECKING UNDER THE HOOD. ONE PERSON TO HOLD THE HOOD WHILE OTHER IS UNDER IT. EXTREME RUST & RUST THROUGH INTERIOR RUNNING BOARDS/STEP UP: BOTH DRIVER AND PASSENGER SIDE INTERIOR RUNNING BOARDS/STEP UP HAVE EXTREME RUST AND RUSTED HOLES THROUGH THE FRAME IN MANY SPOTS.WHEN THE DRIVER OR PASSENGER SIDE DOORS ARE OPEN ALL RUST CAN BE SEEN.SOME RUST AND RUSTED HOLES THROUGH THE FRAME IN MANY SPOTS IS VISIBLE FROM THE EXTERIOR EVEN WHEN DRIVER OR PASSENGER SIDE DOORS ARE CLOSED. *TR

NHTSA ID

10442752

Incident

Dec 23, 2011

Mileage

75,000 mi

TL* THE CONTACT OWNS A 1999 FORD EXPLORER SPORT. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH IN RAINY WEATHER CONDITIONS AND THE WINDSHIELD WIPERS FAILED TO OPERATE DURING ACTIVATION. THE WINDSHIELD WIPERS WOULD OPERATE WHENEVER THE WINDSHIELD WASHER CONTROL DEVICE WAS ENGAGED. ALSO, THE WINDSHIELD WIPERS OPERATED WHEN MANUALLY TURNING THE CONTROL LEVER. ON NUMEROUS OCCASIONS, THE WINDSHIELD WIPERS ACTIVATED WHILE IN THE OFF MODE. IN ADDITION, THE HOOD SUPPORT ARM WOULD NOT REMAIN IN AN UPWARD POSITION. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,500. UPDATED 02/22/12*LJ THE CONSUMER STATED THE WIPERS WOULD ACTIVATE, WHEN THE DEFROSTER WAS ON. UPDATED 03/01/12

NHTSA ID

10442551

Incident

Dec 20, 2011

Mileage

76,500 mi

WINDSHIELD CRACKING AND STATIONARY WINDOW BACK PASSENGER WINDOW BREAKING FOR NO APPARENT REASON. *TR

NHTSA ID

10228884

Incident

May 25, 2008

Mileage

135,000 mi

RECALL 00V072000 CONCERNING ELECTRONIC FUNCTIONS. WINDSHIELD WIPERS WERE INOPERATIVE. ALSO, INTERIOR LIGHTS, AND THE 4X4 CONTROL WORKED INTERMITTENTLY. DEALER WAS NOTIFIED. DEALER INFORMED THE CONSUMER THAT THIS VEHICLE WAS NOT COVERED UNDER THE RECALL. *AK

NHTSA ID

10097775

Incident

Mar 4, 2004

Mileage

30,000 mi

THE VEHICLE EXPERIENCED PROBLEMS WITH THE WINDSHIELD WIPERS WHICH WORKED INTERMITTENTLY. PROVIDE FURTHER DETAILS. *JB

NHTSA ID

10055791

Mileage

60,000 mi

PROBLEMS WITH WINDSHIELD WIPERS, BRAKE LIGHTS, SEAT HANDLES, INTERIOR LIGHTS AND DOOR LOCKS.*MR REAR WINDSHIELD WIPERS DO NOT WORK. BOTH SEAT HANDLES BROKE OFF. INTERIOR LIGHTS REMAIN ON, BRAKE LIGHTS ARE REPLACED TWICE A WEEK. DOOR DOES NOT UNLOCK PROPERLY.*TS

NHTSA ID

10040114

AFTER TALKING TO SEVERAL PEOPLE, AND DOING SOME RESEARCH ON THE INTERNET, IT SEEMS AS THOUGH A COMMON PROBLEM IS WITH THE REAR WINDSHIELD WIPER MOTOR. ON MORE THAN ONE OCASSION, THE MOTORS STOPPED WORKING, WORK INCORRECTLY, OR WORK ONE MINUTE AND FAIL TO FUNCTION THE NEXT. THIS LEADS TO THE LACK OF VISIBILITY TOWARDS THE REAR OF THE VEHICLE, WHICH COULD CAUSE SOME SAFETY CONCERNS.*AK

NHTSA ID

10030949

Incident

Aug 6, 2003

WINDSHIELD WIPER MOTOR REPLACED 3 TIMES. MR

NHTSA ID

767967

Incident

Sep 30, 2002

REAR WINDSHIELD WIPER IS NOT MAKING CONTACT WITH WINDSHIELD. DEALER NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

NHTSA ID

8004041

Incident

Feb 3, 2002