2012 Ford Explorer Body & structure Problems

The contact owns a 2012 Ford Explorer. The contact received notification for NHTSA Campaign Number: 24V031000 (Structure); however, the part to complete the recall repair was unavailable. The contact stated that while driving at 65 MPH on a bypass, the A-pillar exterior trim detached. The owner applied duct tape to the front windshield out of concern that the front windshield would detach. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted, and confirmed that the parts were backordered. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 80,000.

NHTSA ID

11749525

Incident

Feb 1, 2024

Mileage

80,000 mi

Failure of the dealerships to fix recall in timely manner It’s been over two years and parts still unavailable

NHTSA ID

11745848

Incident

Jan 1, 2024

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part required for the recall repair was unavailable. The contact stated the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the part was unavailable. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11743199

Incident

Jan 19, 2024

I received the first recall notice for this defect from Ford Motor Co. in February 2024 and took the vehicle to Sheehy Ford in Ashland, Virginia on August 7, 2025. Sheehy Ford did the required inspection and confirmed that the vehicle had defective windshield rubber molding. The inspection required that the plastic body molding on both sides of the windshield be removed, which rendered them unusable and could not be replaced. Sheehy Ford said they had ordered the necessary replacement parts from Ford Motor Co. and would notify me when they were received. I have been following up with Sheehy Ford every couple of months since August 2025 and they say the replacement parts are still not available from Ford Motor Co. It seems to me that 9 months is an unreasonable amount of time to provide the necessary parts for this Safety Recall, especially missing the plastic windshield moldings, my car is unsellable, which I would like to do.

NHTSA ID

11738521

Incident

Aug 7, 2025

The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed on the highway, the driver's side A-pillar trim clip became partially detached on the side of the windshield. The dealer was notified of the failure, but the vehicle was not repaired. The manufacturer was notified of the failure. The contact associated the failure with NHTSA Campaign Number: 24V031000 (Structure); however, the vehicle was previously repaired under the recall. The approximate failure mileage was 155,500.

NHTSA ID

11732733

Incident

Apr 16, 2026

Mileage

155,500 mi

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted and informed the contact that the part was on backorder. The contact stated that the vehicle could not be registered in the State of California due to the incomplete recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11713995

Incident

Jan 28, 2026

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that the passenger's side and driver's side windshield exterior A-pillar trims had separated and flown off the vehicle while driving. The local dealer was contacted several times and was notified of the failure. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ID

11691834

Incident

Oct 7, 2022

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that upon purchasing the vehicle, the trim on the lower part of the windshield detached and was loosened. The local dealer was not contacted. The vehicle was not diagnosed or repaired. Additionally, the contact stated that there was an abnormal sound coming from the steering wheel, while driving, while making left and right turns, and even while the engine was turned off. The contact stated that the failure had persisted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 125,000.

NHTSA ID

11686724

Incident

Nov 11, 2021

Mileage

125,000 mi

The contact owns a 2012 Ford Explorer. The contact stated that while driving at 55 MPH, the A-pillar trim detached from the vehicle. There were no warning lights illuminated. The contact called the local dealer, where it was previously repaired under NHTSA Campaign Number: 24V031000 (Structure). The dealer informed the contact that the parts were being ordered. The manufacturer was not contacted. The failure mileage was approximately 150,000.

NHTSA ID

11684993

Incident

Jun 1, 2025

Mileage

150,000 mi

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that the A-pillar trim was loose. There were no warning lights illuminated. The contact called the local dealer, who confirmed that parts were not yet available. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the issue. The failure mileage was unknown.

NHTSA ID

11683094

Incident

Feb 1, 2024

Trunk liftgate isn't operating. Cannot open up the trunk. Interior driver sides armrest stitching is busted.

NHTSA ID

11683064

Incident

Aug 23, 2025

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11681559

Incident

Jun 15, 2025

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving 60 MPH, the driver's side A-pillar trim detached from the vehicle. The local dealer was not contacted. The vehicle was not repaired. The contact stated that on a separate occasion, while driving 60 MPH, the driver's side A-pillar trim detached from the vehicle. The local dealer was not contacted. The vehicle was not repaired after the most recent failure. The contact stated that the driver's side A-pillar trim had detached. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

NHTSA ID

11675454

Incident

Feb 22, 2025

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V0311000(Structure); however, the part to do the recall repair was not yet available. The contact stated while driving at an undisclosed speed, the vehicle made an unusual loud sound. The vehicle was driven to the shoulder of the road. The contact stated that upon inspecting the vehicle, the contact noticed that the front passenger's side windshield exterior A-pillar trim had separated from the vehicle and flown off. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 147,012. VIN tool confirms parts not available.

NHTSA ID

11674332

Incident

Jul 17, 2025

Mileage

147,012 mi

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11674231

Incident

Jan 31, 2024

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the passenger's side and driver's side windshield exterior A-pillar trims were loose, and the rubber gaskets underneath the trims were dry rotted. The vehicle was taken to the dealer, where it was inspected but was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000. VIN tool confirms parts not available.

NHTSA ID

11674224

Incident

Jul 17, 2024

Mileage

130,000 mi

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11672495

Incident

Jan 19, 2024

Jan 19,2024 Manufacturer Recall Number24S02 NHTSA Recall Number24V031 Recall StatusRecall Incomplete, remedy not yet available This recall has been unavailable due to "lack of parts" for 18 months. Mine had already come off, and I had been holding them on with black duct tape. In the heat, the glue from the tape melted and they flew off my vehicle on the freeway and I was unable to retrieve them. When is Ford supposed to have the parts? This has been going on too long.

NHTSA ID

11669153

Incident

Jun 23, 2025

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that water was leaking into the vehicle through the A-pillar trim clip. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The approximate failure mileage was 136,000. VIN tool confirms parts not available.

NHTSA ID

11663181

Incident

Nov 28, 2023

Mileage

136,000 mi

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving 55 MPH, the driver's side A-pillar trim loosened. The local dealer was contacted. The vehicle was not repaired. The contact stated that on a separate occasion, while driving 55 MPH, the front passenger’s side A-pillar trim loosened. The local dealer was contacted. The vehicle was not repaired after the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 92,000. VIN tool confirms parts not available.

NHTSA ID

11662096

Incident

May 20, 2024

Mileage

92,000 mi

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the A-pillar trim was detaching from the front windshield and allowing water to leak into the vehicle. The contact temporarily sealed the windshield with tape. The dealer was contacted and confirmed that the part for the repair was unavailable. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

NHTSA ID

11662062

Incident

Jan 19, 2024

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted, and the A-pillar trims were removed. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. VIN tool confirms parts not available.

NHTSA ID

11659883

Incident

Jun 15, 2024

Mileage

191,000 mi

The contact owns a 2012 Ford Explorer. The contact stated while driving at an undisclosed speed, the A-pillar trim on the driver’s side windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer had gone to the residence and diagnosed the vehicle and determined that the A-pillar trim retention clips had failed and needed to be replaced. The vehicle was not repaired, and the dealer stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 176,000. VIN tool confirms parts not available.

NHTSA ID

11657163

Incident

Apr 28, 2025

Mileage

176,000 mi

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the passenger's side A-pillar trim detached. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000. VIN tool confirms parts not available.

NHTSA ID

11656157

Incident

Jan 19, 2024

Mileage

130,000 mi

The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed, the contact noticed that the passenger's side windshield exterior A-Pillar trim had detached. The vehicle was taken to an unknown dealer, where it was diagnosed with the passenger's side windshield exterior A-Pillar trim adhesive failure. The vehicle was not repaired. After investigating the failure, the contact became aware that the VIN was included in NHTSA Campaign Number: 24V031000 (Structure), which the contact related to the failure; however, the part to do the recall repair was not yet available. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ID

11654076

Incident

Apr 11, 2025