2022 Ford Explorer Engine Problems

RECALL COMPLIANCE & SAFETY DEFECT DESCRIPTION: The vehicle was transported via roadside assistance to a licensed manufacturer dealership due to severe engine overheating under an active manufacturer safety recall. Service personnel systematically modified intake paperwork to alter the true mechanical state upon arrival, removing safety recall and towing documentation. Intake files were falsified with the notation stating that the customer reported a bad battery, executed solely to evade mandatory factory safety recall tracking protocols and obscure dealer liability for subsequent failures. UNAUTHORIZED SHOP-FLOOR HAZARDS & MECHANICAL DAMAGE: Following custody transfer, shop technicians induced severe physical damage to the vehicle's twin-turbocharger assembly, resulting in a snapped turbo stud and a torn engine air filter. The vehicle was subsequently operated on public roads by shop personnel for 75 to 80 unauthorized miles under active engine overheating conditions without correcting thermal or safety recall failures, creating an immediate risk of catastrophic engine block structural cracking. The safety failures triggered 13 critical system fault codes across powertrain, electrical, and battery systems, which went entirely unaddressed while the shop attempted to compel payment under an altered repair estimate. CYBER SABOTAGE OF OUTBOUND SAFETY TELEMATICS: To actively obstruct diagnostic tracking and safety verification, shop staff executed a forced remote network reset of the vehicle's cellular modem. This reset deliberately severed user profile access and entirely deactivated the outbound telematics pipeline to systematically block the outbound transmission of the 13 powertrain and thermal fault messages to the user and manufacturer databases.

NHTSA ID

11755278

Incident

Jun 19, 2026

Exhaust manifold turbo charged cracked while driving. Exposing everyone in the vehicle to raw exhaust inside the vehicle every time it is driven. The replacement part is back ordered until September 16th from the dealership. I was told this is an extremely common issue with ford explorers. I don’t understand how this part is not recalled. It has slowly gotten worse and worse. No warning lamps came on. You can hear the engine or manifold rattling/ticking while the vehicle is running. The vehicle is available for inspection. I brought the vehicle to a repair shop called MIDAS. Where I was told exactly what was wrong with it. The problem is reproduced every single time the vehicle is on. The replacement part is also not covered under fords “emissions warranty”. Even though it is part of the emissions.

NHTSA ID

11755072

Incident

Jul 13, 2026

The contact owns a 2022 Ford Explorer. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle before the engine seized. The check engine warning light was illuminated. The vehicle restarted after several attempts and was driven to the residence. The contact's minor grandchild was an occupant in the vehicle when the failure occurred. The contact stated that the temperature was extremely hot outside when the failure occurred. The failure was a persistent failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000.

NHTSA ID

11754722

Incident

Aug 1, 2025

Mileage

60,000 mi

The contact owns a 2022 Ford Explorer. The contact stated while driving at 55 MPH, the vehicle was driving unusually rough and the vehicle stalled. In addition, the check engine warning light illuminated, and the vehicle lost motive power. The vehicle was driven to the shoulder of the road. The contact stated while attempting to start the vehicle, the vehicle failed to stall as intended. The vehicle was towed to the independent mechanic where it was diagnosed with a failed low pressure fuel pump. The contact was informed that the low pressure fuel pump needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and a case was filed. The contact referenced a recall, NHTSA Campaign Number: 25V455000 (Fuel System,Gasoline) however the contact's VIN was not associated. The failure mileage was approximately 64,598.

NHTSA ID

11740416

Incident

May 22, 2026

Mileage

64,598 mi

Unknown! sometimes the rear back up camera goes into a black screen and then once in drive the info screens stays black for about 30 seconds. the cars shifting is hard at times especially when going from slow to fast like for instance on a highway on ramp the shifting is very sluggish. the cupholder are a real hazard my cupholder bottomed out and my drink fell thru luckily there was no liquid in the cup otherwise it could have spilled into the electrical since it is right where the gear shift is. the the car not accelarating is dangerous when you trying to get on the highway. rear camera going blank sometimes and not being able to see whats behind you even when looking around you just can not see the blindspot which the camera could if it would not go black sometimes. if the car does not shift right when it is supposed to makes it really hard to go with flow of traffic on the highway. there never have been any warning lamps, message or anything else during these incidents and it does not happen all the time but when it does it is not safe

NHTSA ID

11739777

Incident

May 14, 2026

There are three active recall on my car, all of which say there are not remedy available and NHTSA Recall Number 25V455 can cause engine failure that leads to a crash, was reported in July 2025, and STILL has no remedy. The other 2 recalls are NHTSA Recall Number 26V123 and NHTSA Recall Number 26V117.

NHTSA ID

11730431

Incident

Jul 8, 2025

Ford Explorer Recall – Ongoing Safety Hazard In July 2025, Ford issued a recall notice for my vehicle. Shortly after, the check engine light came on. Starting October 15, 2025, my vehicle began failing to start after refueling—making noise and taking multiple attempts to start. The same issue occurred repeatedly on October 23 and October 30, worsening each time. On November 3, we brought the car to a Ford dealership. They confirmed there is no available fix for the recall and said there’s “nothing they can do.” I explained this was a safety issue since I drive my son with a disability to therapy daily. They told me I would have to pay out of pocket for repairs even though the problem is linked to the recall. On November 8, while driving in Arizona, my vehicle again failed to start after refueling. Later that day, it lost power on the road, the speed dropped suddenly, and it would not accelerate. The same stalling and jerking occurred again on November 10 while my husband was driving. We contacted Ford Corporate and NHTSA, but both said nothing could be done because the recall label says the car is “still drivable.” This is inaccurate and dangerous. The car stalls and loses acceleration randomly, creating a serious risk of an accident. On November 21, the car again failed to start after refueling. This has happened multiple times each week, and Ford continues to delay a fix. My vehicle is unsafe to drive, and this unresolved recall poses an ongoing safety hazard to my family and others on the road.

NHTSA ID

11698789

Incident

Oct 15, 2025

2022 ford explorer with less than 100,000 miles on it. Started getting engine shudders and a check engine light. It’s currently in the shop and I’m being told by the shop and a third party adjuster that I need a whole new engine because there is coolant leaking into the cylinders.

NHTSA ID

11694311

Incident

Oct 1, 2025

When i accelerate, the car jerks back and forth and stalls. ford has said the car was throwing codes but the TECH didnt feel the issue so they sent me on my way.... well fast forward to today, i am informed my car has thrown codes 4 times in the past few days and this morning i was scared to drive my car it was bad... and i have a [XXX] daughter. Our safety is my top priority and it doesnt seem to matter to anyone else INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11677769

Incident

Jul 1, 2025

The contact owns a 2022 Ford Explorer. The contact’s son started the vehicle and became aware that the "Cylinder Head Temperature Overheated" message was displayed on the instrument panel while the vehicle was parked in the driveway. The vehicle was towed to the dealer, who diagnosed that the engine and engine cooling system had failed due to water leaking into the turbo. The dealer stated that the sensor failed to identify and inform the driver that the engine was running hot. The contact became aware that the failure had occurred with the previous owner of the vehicle approximately 2 - 3 years ago. The contact was informed that the engine needed to be replaced, or the turbocharger could be replaced as a temporary repair. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 105,000.

NHTSA ID

11676588

Incident

Jul 7, 2025

Mileage

105,000 mi

The contact owns a 2022 Ford Explorer. The contact stated that upon starting the vehicle, the check engine warning light illuminated and remained illuminated. Additionally, there was an abnormal rattling sound coming from the front end of the vehicle, and there was an abnormal gasoline odor inside the cabin of the vehicle. The vehicle was taken to a local independent mechanic to be diagnosed, and the contact was informed that the catalytic converter was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 72,378.

NHTSA ID

11670581

Incident

Jun 18, 2025

Mileage

72,378 mi

The contact owned a 2022 Ford Explorer. The contact stated that upon taking off after yielding to a stop sign, the vehicle inadvertently lost motive power in the middle of an intersection. As a result, the vehicle was struck by another vehicle on the rear driver's side door, sending the vehicle careening back through the inspection past the stop sign before coming to a complete stop. All air bags were deployed. No warning lights were illuminated. The vehicle was towed to a tow yard and deemed a total loss by the contact's insurance provider. A police report was filed, and injuries were reported. The occupants did not immediately receive medical attention but later transported themselves or were transported to area hospitals for evaluation. The contact received a full-body MRI and was treated for whiplash, neck pain, and various bruising caused by the seat belt, while her husband received a CAT scan and was treated for whiplash, neck pain, back pain, and bruising on his arms. Meanwhile, the [XXX] occupant was transported to his primary care physician by his parents and treated for a neck burn caused by the seat belt. The contact also stated that the driver of the other vehicle was transported to an area hospital by EMT but was unaware of her condition or treatment. The manufacturer was not notified of the failure. The failure mileage was 80,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11660969

Incident

May 14, 2025

Mileage

80,000 mi

The contact owns a 2022 Ford Explorer. The contact stated that while the vehicle was turned off, the contact was notified by the Ford App that the check engine warning light was illuminated and the message “Fuel Door Open" was displayed. The contact stated that the vehicle previously had a transmission software update due to the vehicle hesitating to accelerate while driving. Additionally, the speedometer intermittently failed to function as needed. The vehicle was taken to the dealer, who determined that there was water intrusion into the body control module fuse panel. The contact was informed that the battery and body control module fuse panel needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 61,500.

NHTSA ID

11652806

Incident

Mar 28, 2025

Mileage

61,500 mi

My wife was driving the car all of a sudden the check engine light came on, and it started to flash on and off. The car started sputtering. She pulled over turned the car off and called me. I informed her to wait a little bit and restart the car. She did – and then the check engine light came on, but was no longer flashing, and a car started running as if no problem. I had the code checked out it is P0300 – which is an error code of random misfire detected in the engine. Fortunately, she was not evolved in an accident, even though she was traveling on the highway. I am taking it to the dealer as his recommended. This happened when the mileage on the odometer read 40,144.

NHTSA ID

11635503

Incident

Jan 11, 2025

The contact owns a 2022 Ford Explorer. The contact stated that while driving at an undisclosed speed, he heard an abnormal knocking sound emanating from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the camshaft and timing chain. The vehicle was repaired, but the failure reoccurred. The manufacturer was not notified of the failure. The VIN was not available. The failure mileage was 38,000.

NHTSA ID

11634850

Incident

Jan 8, 2025

Mileage

38,000 mi

On 10/28/2024 at approximately 0515 I was traveling at 51 MPH when my 2022 Ford Explorer King Ranch edition with ~25k miles experienced catastrophic engine failure. The vehicle had no prior indication of failure. No engine light, no warning lights, etc. The vehicle started shaking violently and lost all power. I was able to safely pull to the shoulder of a two-lane road. The vehicle was completely dead and would not start. I am not sure if there was oil or anything leaking as it was dark outside. I called a tow truck and had the car taken to the Ford dealership. After initial inspection, the dealership moved the car to the "heavy maintenance" part of the service department. After a few days, I called to find out what they found and was informed the engine had "thrown a rod" and the entire engine would have to be replaced. After a week and a half, I called back and was told they are still disassembling the engine and their next step will be to submit a "cost cap" to Ford for permission to replace the engine. After researching the issue online, I came across the Safety recall 24V-598 on engine failures in the 3.3L size engine, typically only on police interceptor versions of the Ford Explorer. The information in the recall sounded exactly like what happened to my explorer but was told by the dealer the 3.0L engines were not affected and they had never seen one fail like this. I truly believe the 3.0L engine sizes are affected and the recall should be expanded to include this version of the explorer. I was lucky that I was able to safely drift to the side of the road, however, others may not be that lucky.

NHTSA ID

11624212

Incident

Oct 28, 2024

Mileage

177,175 mi

The vehicle is a hybrid police interceptor utility. The unit was moving running radar and activated its emergency equipment, made a u-turn on a highway cross over, when accelerating in pursuit of a vehicle its engine stalled out and shut off. The vehicle stated to shift to neutral and restart when safe. The officer shifted to neutral and the vehicle would not restart. It was coasted off the roadway and towed. This is the third issue of this type that has occurred with our fleet of ford hybrid police interceptor utilities.

NHTSA ID

11596284

Incident

Jun 14, 2024

I was driving down the highway and my vehicle suddenly lost power and the motor blew up.

NHTSA ID

11582672

Incident

Oct 5, 2023

Transmission fails to smoothly shift, vehicle delays going in reverse after driving causing delays to park and shakes while downshifting. Drivers anticipate the vehicle to be able to backup sooner and can cause accident with delays. Safety 360 display and rear view camera goes completely out, inverts, and has delay when functions. Vehicle has full power failure while driving and can take 10 minutes to turn back on, happened twice.

NHTSA ID

11560172

Incident

Dec 1, 2023

I smell exhaust/gas fumes when driving my car. It is a very intense smell. This happens several times a week.

NHTSA ID

11557750

Incident

Oct 1, 2022

I have received six (6) notifications of a power train failure, which causes the vehicle to "shudder" at highway speeds. The first issue took place 09/01/2023, and the last was on 11/1/2023. The vehicle then continues to operate normally. If the vehicle is turned off and then on again, the light clears. I took the vehicle to Tamiami Ford for service. They reported that they can see that their is an issue, but are unable to diagnose it.

NHTSA ID

11556867

Incident

Nov 5, 2023

Vehicle was pushing blue smoke, dealership replaced the turbo. Blue smoke returned furiously and dealership replaced the top end including valve assembly. While on a 900 mile journey through northern idaho, the engine completely failed at highway speed leaving me stranded. Ford believes they have cured the valve issue when in fact a new long block motor failed on first long distance trip. Please don't let anyone else go through this I lost thousands of dollars in out of pocket expenses, missed my best friends funeral among other things. These manufacturers need to be held accountable for poor workmanship!!!

NHTSA ID

11548227

Incident

Aug 4, 2023

When engaging vehicle from park to gear (ex drive, reverse) or from gear into park there is a delay. Meaning vehicle doesn’t engage into drive or reverse when it is placed in that gear, it will take a moment for gear to engage, sometimes resulting in a jerking motion of vehicle. This jerking motion also happens when vehicle is automatically shifting as speed (rpm) increase. There is also a delay when pacing the vehicle from a moving gear into park, there is a delay of vehicle locking into park, sometimes motion is still felt.

NHTSA ID

11547960

Incident

Oct 3, 2023

As you drive and pick up speed at the range of 29 to 31 mph, exactly the car shutters and shakes. It is known by Ford that the driveshaft needs to be angled due to the hybrid battery location in the car. This particular problem is consistent with a driveshaft replacement that has been known by Ford as well as bearings in the driveshaft. I have had problems with the shuttering in this vehicle almost since day, one of owning it.

NHTSA ID

11547488

Incident

Sep 30, 2023

I was driving (at a fairly low speed) recently when my vehicle began driving erratically. I pulled over and noticed that there was smoke in the passenger compartment. I exited the vehicle and walked to the passenger side (out of traffic) and opened the passenger door to retrieve my cell phone. At that point there was a burst of flame upon opening the door, and the fire quickly spread to the passenger compartment.

NHTSA ID

11516106

Incident

Mar 20, 2023