2023 Ford Explorer Owner Complaints

As I was driving out of my garage with the car engine forward. Suddenly, as the vehicle was in drive and moving forward, the rear lift gate opened. I did not observe this open, nor was there any warning lights or alarms. bAs my vehicle moved forward the lift gate caught the top of the inside of the open garage door. Causing the rear windshield wiper to break and for the garage door to apparently swing in such a manner as to shatter the rear window. Is my understanding that you cannot open the lift gate, if the vehicle's is in drive mode and your vehicle is moving forward. Normally, if you ever attempted this, an alarm would sound, there was no alarm, I touched nothing other than driving forward pulling out of my garage at a slow speed. I feel this maybe a software glitch that needs investigation. Although I was alone and not severly injured. A similar occurrence could have more troubling ramifications.

NHTSA ID

11774080

Incident

Oct 26, 2026

Panaramic roof shade sagging causing no visbilty issue and common problem with 2020-2026 explorers

NHTSA ID

11773714

Incident

Oct 2, 2026

I am filing this complaint because the federal recall remedy performed on my 2023 Ford Explorer failed, and the Ford dealership that performed it refused to correct the failure. About a year after I purchased my 2023 Ford Explorer (used, from an independent dealer), I received Ford's federal recall notice for the rearview camera software defect (recall 23S02, NHTSA campaign 23V-022). My vehicle had no problems at that time, but I took it to the authorized Ford dealership in [XXX], and had the recall software update installed as instructed. About seven months later, my vehicle developed the exact defect the recall was supposed to prevent: the backup camera stopped functioning and the infotainment screens went completely black, disabling multiple vehicle functions. This created a safety hazard because the vehicle no longer provided any rearview image while backing up. I returned the vehicle to the same dealership and asked them to correct the failed recall repair. Instead, the dealership claimed the problem was not recall-related, diagnosed a failed APIM module, and quoted about $1,600 for replacement plus a $300 diagnostic fee. The dealership then refused to release my vehicle until the $300 fee was paid, holding it for approximately two months. I took the vehicle to an independent repair shop, which confirmed the APIM was fine - the software had simply become corrupted - and repaired it by reinstalling the software. I paid $530.29 for that repair plus $313.79 for a replacement battery (the original died while the car sat at the dealership for two months). Ford was sent a formal demand letter on XXX, with a 10-day deadline, and never responded. NOTE: The incident date entered in this form is my best estimate only; the exact date is approximate. I am asking NHTSA to investigate this dealership's failure to honor a federal recall remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11771139

Incident

Jun 1, 2026

I am submitting this complaint involving suspension on 2023 Ford Explorer. Dealership has replaced the right front stunt mount two times. The problem is still not corrected.

NHTSA ID

11767501

Incident

Dec 30, 2025

I was driving on the highway at approximately 70mph in my 2023 Ford Explorer Platinum which has 30,000 miles on it. We heard a loud noise which sounded like a gun went off inside the car. My sunroof exploded outward with no warning or messages and no impact. Edges of the remaining glass were angled upward indicating that the glass burst outward. There were no signs of glass impacting the thin fabric retractable shade. We had been driving for about 3 hours when the incident occurred. I took the vehicle to a Ford dealer, they took pictures and submitted a request for it to be covered under warranty but have not confirmed. We could have been at risk if I had not maintained my composure and moved safely to the shoulder. Vehicles behind us may have been impacted by the flying glass but I did not see any other vehicles pull over. I did get an estimate for repair from a local body shop in case Ford does not agree that it is a manufacturing problem. This should be covered by Ford!!!

NHTSA ID

11765256

Incident

Sep 14, 2026

While driving, vehicle made a grinding sound, and all systems related to cruise, 4wd, decent control all illuminated on dash. Vehicle was taken to dealer, metro ford. Metro ford stated the transfer case has failed internally, and being replaced under powertrain. A week later, I received a callback, and the service writer stated after replacing and a test drive- it is still an issue, and the vehicle has an issue- which they feel is the AWD module, AWD module failed causing clutch in transfer case to lock up when it shouldn’t be resulting in limited power and grinding and depletion of safety systems on vehicle. Dealer states ford is aware of the issue but offered me a discounted repair of 270 dollars vs the 7-800 that it costs to complete the repair. Vehicle is still in shop weeks later with warning lights on.

NHTSA ID

11764616

Incident

Aug 30, 2026

Purchased new June 2023, took delivery October 2023 due to camera recall. Drive to work 5 miles a day, less than 10000 miles on it yet my driver side dash is now Ingles and rolling up. I see this is a common issue. I paid extra for the King Ranch edition. Seems this should be a dealer covered repair. I would like this looked into.

NHTSA ID

11762481

Incident

Aug 26, 2026

The exhaust pipe that connects a catalytic converter to the muffler broke and was dragging on the highway. It was during rish hour and was no safe place for me to pull over and within just a few miles, the other side of it broke off and the whole pipe between the catalytic converter and muffler fell into traffic behind me. Apparently this has been an issue with 2020-2022 model years but It needs to be extended further into atleast the 2023 model year since that is what I have.

NHTSA ID

11760401

Incident

Aug 28, 2026

The panoramic sunshade on our 2023 Ford Explorer bunches up and dips down into the rear passenger compartment when being retracted, obstructing rear visibility when using the rear view mirror or looking over your shoulder.

NHTSA ID

11759896

Incident

Aug 25, 2026

The paint is starting to bubble and flake off from inside the vehichle doors by the seam where corrosion under the paint has started. I have looked at multiple complaints from other explorer owners and this is a common issue that ford does not want to fix. There sheet metal is contaminated with “white oxidized rust underneath the paint causing the bubbling and paint letting go resulting in further rust.

NHTSA ID

11758266

Incident

Aug 20, 2026

I am submitting this complaint regarding my 2023 Ford Explorer ST and my inability to obtain the remedy for NHTSA Campaign 26V123 / Ford Recall 26C11, involving a rearview-camera/SYNC display condition that may reduce rear visibility and increase crash risk. RCAK-26V123-1258 2.pdf Kendall Ford of Anchorage has notified me in writing that it will no longer perform any work on my vehicle, including recalls. Kendall states recalls require a Ford-authorized facility and identifies Seekins Ford in Fairbanks as the closest non-Kendall Ford dealer. I contacted Ford for assistance. A Ford representative acknowledged Kendall’s refusal in a voicemail and stated, “The only thing that we can do in this instance is have you go to another dealership,” directing me elsewhere for the recall. However, Ford’s current 26C11 instructions identify Mobile Repair and Pickup & Delivery as available and specifically state, “Arrange for a mobile repair at the owner’s location.” I am not refusing the recall or requesting that Kendall perform it. I am requesting that Ford arrange a qualified Ford-authorized mobile repair rather than requiring me to travel hundreds of miles to Fairbanks. I respectfully request that NHTSA review Ford’s handling of my recall access and assist in ensuring I have a safe, practical means of obtaining the remedy. Supporting documentation: Kendall’s written correspondence, Ford’s voicemail acknowledging the refusal, and Ford’s current 26C11 instructions.

NHTSA ID

11755840

Incident

Jun 25, 2026

The light for the right hand mirror blind spot warning came loose within the mirror housing. The light still works and activates when a vehicle is in the blind spot, but the light has fallen to the bottom of the mirror housing and is barely visible (a yellow glow at night).

NHTSA ID

11749749

Incident

Jun 1, 2026

Faint popping and knocking sound coming from front suspension, LOUD clunk coming from rear suspension when going over bumps. Both seem to cause vehicle to be floaty while driving. Also headlights sometime flicker while driving with switch in auto position and sometimes will not shut off after exiting vehicle ( have to turn switch to off position and then back to auto to resolve ) Vehicle has approximately 21k miles on it but off warranty due to time. Will be bringing into local repair shop soon.

NHTSA ID

11749497

Incident

Apr 2, 2026

The contact owns a 2023 Ford Explorer. The contact stated that while driving from Pennsylvania to Ohio through the Pennsylvania Turnpike, the adaptive cruise control system was not functioning. The "Adaptive Cruise Control Is Not Available" warning message was displayed on the instrument panel. No warning lights illuminated. A dealer was made aware of the failure but informed the contact that adaptive cruise control was inoperable on certain highways. The manufacturer was not made aware of the failure. The vehicle was not repaired. The failure mileage was approximately 22,000.

NHTSA ID

11749331

Incident

Jul 3, 2026

Mileage

22,000 mi

Vehicle: 2023 Ford Explorer ST VIN: [XXX] I am reporting ongoing safety-related powertrain and drivability defects that continue despite numerous repair attempts, including complete engine and transmission replacement. Since approximately June 2025, my vehicle has experienced delayed acceleration, hesitation, erratic RPM behavior, harsh shifting, loss of power, and intermittent warning lights. The vehicle has also stalled, jerked during acceleration, and exhibited transmission shuddering and lurching. The problems have been repeatedly reproduced, documented, inspected, and repaired by Kendall Ford of Anchorage, Alaska, the sole servicing Ford dealership involved. Repairs have included replacement of fuel injectors, cylinder heads, a complete engine assembly, and a complete transmission assembly. Despite these repairs, the safety concerns remain. Current symptoms include: • 1-4 second delay in throttle response. • Vehicle may fail to accelerate below approximately 30 mph. • Engine RPM rises significantly without proportional vehicle acceleration. • Erratic shifting, surging, and harsh jolts. • Intermittent check engine lights, FordPass alerts, and electrical warnings. These conditions create a significant safety risk because the vehicle may fail to accelerate when entering the highway, merging into traffic, crossing traffic, making left turns, or avoiding hazards. The delayed throttle response and sudden acceleration after the delay increase the risk of a crash. Attached service records document stalling, misfires, loss of propulsion concerns, and repeated powertrain failures requiring replacement of both the engine and transmission, yet the drivability concerns continue. I believe this may involve a defect in the powertrain, transmission controls, engine management system, electronic throttle control system, or related vehicle control modules. I respectfully request that NHTSA investigate these recurring safety-related defects. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C

NHTSA ID

11746273

Incident

Jun 16, 2025

The contact owned a 2023 Ford Explorer. When the contact’s husband activated the air conditioning system after the vehicle had been parked for several hours, a fire started underneath the console inside the vehicle. The driver pulled over to the side of the road, where onlookers assisted with extinguishing the fire with a fire extinguisher. The contact’s husband received burns on his fingers. Medical attention was not needed. The Fire Department was not contacted. The vehicle was towed to the dealer to be inspected; however, the cause of the failure was not determined. The vehicle was deemed a total loss. The contact was provided with photos of the vehicle and became aware that the wiring was burned. The manufacturer was not made aware of the issue. The failure mileage was approximately 61,000.

NHTSA ID

11745964

Incident

May 28, 2026

Mileage

61,000 mi

Premature leaking and failure on rear shocks absorbers. Premature failure could lead to handling issues and interference with driver assist handling, action control etc. Some say this is a know issue but not one that has prompted a recall

NHTSA ID

11744038

Incident

Jun 12, 2026

The rear subframe bushing is torn, resulting in the rear of the vehicle to sway side to side when traveling down the road at highway speeds, making it difficult to maintain lanes. Bushings are not covered by the 60k power train warranty, and resulting in a 2-3,000 dollar repair due to subframe in rear of vehicle needing dropped and bushing pressed out or entire subframe to be replaced.

NHTSA ID

11743490

Incident

Jun 6, 2026

The chrome/ brushed finish peeling along the top of the center console, resulting in sharp edges. The vehicle is just outside of bumper to bumper warranty and the fix is out of pocket. Vehicle current has 55k miles on it, and bubbling down both sides of the laminated trim.

NHTSA ID

11743487

Incident

Jun 1, 2025

Precollision assist warnings on in the car saying system unavailable. Took to the dealer and showed me the sensor for this was broken and my cost would be $1800 to repair. My vehicle only has 16000 miles on it and is covered by an extended warranty and 3 year BTB warranty. Dealer claims the sensor was hit by an external force so it wasn't covered. I said we have hit nothing and my vehicle shows no damage. Internet says these can fail by bumper collision or hitting a pot hole. I think it is a vehicle safety issue that you don't design something that can withstand hitting a bump or pot hole or why wouldn't you give clearance for the bumper to flex. Ford can't tell me what happened to the sensor and to me that is a safety issue. I spoke with the service advisor and went up to service manager and called Ford customer care and they refuse to do anything about it.

NHTSA ID

11741254

Incident

May 22, 2026

Vehicle: 2023 Ford Explorer Recall Number 25S49 (NHTSA:25V315) I am filing this complaint regarding a failed recall remedy & my Ford dealership's refusal to re-repair my vehicle. The recall remedy was previously performed at an authorized Ford dealership. The defect has since recurred, my infotainment screen is completely black & non-functional at all times, leaving me with no rear-view camera visibility when reversing, which is an ongoing safety hazard. When I returned to the dealership they refused to perform a second repair under the recall. Dealer records confirm the original repair was completed. I am requesting the NHTSA document this complaint, investigate the failed remedy & require Ford to provide a durable fix for vehicles where the recall repair did not hold.

NHTSA ID

11740112

Incident

Apr 22, 2026

The contact owns a 2023 Ford Explorer. The contact stated that while her boyfriend was driving at 40 MPH, another vehicle did not stop at a stop sign and crashed into the front passenger side of the vehicle. All of the air bags deployed. The contact's boyfriend suffered bruising to the wrist and left upper arm and redness on the right hand. The front passenger-side curtain air bag caused the contact second-degree chemical burn on the right side of the stomach when it burned through two layers of clothing. The contact also suffered from a sprained left foot and left hand and lacerations from the shoulders and elbows from the air bag deployment. The contact and her boyfriend were transported to the hospital via ambulance and received medical attention. A police report was filed. The vehicle was towed to the tow yard but was not yet deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 43,000.

NHTSA ID

11739351

Incident

May 16, 2026

Mileage

43,000 mi

I purchased the Ford Explorer in June of 2023. The struts were replaced at 10,400 miles because of this problem. I have tried to work with Ford Customer service and have a case number associated with it XXX . I brought the Explorer in to get it fixed again for the same strut problem. It has 44,600 miles on it. So it’s out of the warranty it 36K miles . Still after working with Ford Customer Relations service they denied any coverage for the repair. They said they don’t cover regular worn parts . Now, I am paying out of pocket $2,097.47. This is a known problem and I feel Ford needs to pay for the repair of the strut . It’s clearly a manufacturer defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11736843

Incident

May 1, 2026

Sunroof retractable headliner

NHTSA ID

11735827

Incident

Apr 29, 2026

Ecoboost. Coolant intrusion into cylinder head causing white smoke to come out of the exhaust. This is the second ford vehicle I have owned with the same issue.

NHTSA ID

11734156

Incident

Apr 27, 2026