2026 Ford Explorer Problems

On XXX around 6:30pm: Car would not go into reverse. Upon pressing the gas a 2nd time, a loud pop was heard from the back of the car. The car was then able to drive forward, however, when pressing on the brakes, the rear end of the car would wobble, and the brakes were rubbing and making a loud noise. I contacted Rich Ford, explained that my car is brand new (2 months), with less than 4,000 miles, and this should not happen. I was told that “someone would call me the following morning around 7am”. I drove to work the next morning, XXX, avoiding the use of the brakes as much as possible. I called Rich Ford again, at around 07:45, and spoke to “Toby”. Explained to him what had happened, and asked that they pick up the vehicle to see what’s wrong. I was told that they couldn’t look at it until Monday XXX. I told Toby that I did not feel comfortable or safe driving my car anywhere, and asked that they pick up the car and provide a loaner. Toby then told me I could drop the car off on Friday, XXXat 08:00. Around 3:48pm, Wednesday, I called Rich Ford again and asked them to pick it up because I didn’t feel safe to drive it. They said “No, just drop it off on Friday”. At around 5:35pm, I got to my car, which was parked on the side street of [XXX]. I pressed the brakes, pressed the start engine button, and then went to step out of the car to talk to a co-worker. The car was in “park”. Once I stepped out with my left leg, the car began rolling forward, knocked me face down onto the road, and then ran over both of my legs. My coworker ran after the car and it stopped on the side of the road. I was rushed to a Level 1 trauma center, UNMH, with severe injuries to both of my legs. I was unable to take my car to the dealership on Friday, XXX, because of my injuries. Rich Ford had NOT REACHED OUT TO ASK WHY THE CAR WAS NOT TAKEN IN. I plan on contacting my insurance company on XXX.I have very serious injuries as a result. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I had my car in drive in a parking spot. I was ready to go, put the car in drive, DID NOT MOVE but needed to put it in park fast to assist to a child in the back seat. I put it in park pretty fast. Took my seatbelt off and assisted child. It must have not engaged. Car rolled into my office metal mailbox. I 100% put it in park. I took my seatbelt off after so I seen it. It was fast with the gear shift though. Should this have been an issue? I feel like if it was any other car you with a manual gear shifter , not electrical, it’s fine. I feel this was not my fault at all and was a malfunction of the car. The car did not automatically stop either. It hit the mailbox at like 3-4mph. I have never been in an accident of my fault in 10 years of driving. I’ve never made a crazy mistake like that. It should’ve never happened. I drive all types of cars/ and trucks. This is also a lease and I’m SO PISSED. Especially because my kids were in the car. Luckily no one was hurt and no property damage. Just the car.

On several occasions when trying to drive from a stopped position I press the gas and the car will move slowly but not shift into gear and then after turning off it struggles to restart. The check engine light is solid but goes away by the next day. This has happened after sitting idling in a parking lot most often but recently it happened 2 times as I was turning left onto a street where I luckily was able to slow roll to the side and not get hit. I brought it in once for service and they struggled to find the issue for hours and eventually said pins in the fuel injector were lose and replaced but it is continuing to randomly happen.

This 2026 Ford Explorer has stopped, stalled, hesitated and jerks after fuel fill-ups. It stopped twice for myself in busy intersections. The dealer has had it for weeks and when driving the vehicle back to me, stalled and hesitated for Ford Service dept. twice. They told me I could not have my car back for safety reasons.

Seal around the panoramic sunroof is failing and has caused loud wind noises and lack of proper weather seal. Vehicle has 7000 miles and this has randomly started. Loud wind whistle noise occurs now 100% of the time when speed reaches 35mph and stays present at higher speeds.

While driving my 2026 Ford Explorer on the highway, the panoramic roof glass made an abnormally loud noise and completely shattered without any impact from an object or other vehicle. No other cars were nearby. The protective shade remained in place and no glass entered the cabin. This appears to be a spontaneous failure of the tempered glass. I have already located a nearly identical NHTSA complaint on another 2026 Ford Explorer (Campaign 11734759). The vehicle is currently undrivable in normal conditions and is being repaired through insurance. I am concerned this is a known defect with the panoramic roof glass on 2026 Explorers.

Ford has issued a recall related to the driver seat recline memory feature. It is recall 26V470. The remedy (software-based) disables the driver seat recline memory feature altogether. THIS IS UNACCEPTABLE. Instead of correcting the issue with the recline memory feature, Ford has chosen to disable the feature completely. I did not purchase a new vehicle, just to have the manufacturer disable a standard feature than does not function properly. Ford must repair the standard feature and return the vehicle to it's normal operating function. The solution must not diminish the features and usability of the vehicle that was purchased.

When entering the vehicle with a key fob that is programmed for a saved seat setting for the driver, the chair back begins to recline all the way. This could crush a passenger seated behind them.

I had my car in drive in a parking spot. I was ready to go, put the car in drive, DID NOT MOVE but needed to put it in park fast to assist to a child in the back seat. I put it in park pretty fast. Took my seatbelt off and assisted child. It must have not engaged. Car rolled into my office metal mailbox. I 100% put it in park. I took my seatbelt off after so I seen it. It was fast with the gear shift though. Should this have been an issue? I feel like if it was any other car you with a manual gear shifter , not electrical, it’s fine. I feel this was not my fault at all and was a malfunction of the car. The car did not automatically stop either. It hit the mailbox at like 3-4mph. I have never been in an accident of my fault in 10 years of driving. I’ve never made a crazy mistake like that. It should’ve never happened. I drive all types of cars/ and trucks. This is also a lease and I’m SO PISSED. Especially because my kids were in the car. Luckily no one was hurt and no property damage. Just the car.

I am reporting a potential safety defect involving the upper steering column shroud and the driver-facing Driver Status Monitor Camera on my 2026 Ford Explorer equipped with BlueCruise. The upper steering column shroud became extremely loose and will not remain securely attached. The driver-facing camera is mounted in this area. Ford states that BlueCruise uses the driver-facing camera to monitor the driver’s eyes and head position during hands-free operation. I personally observed the shroud and camera assembly loose while BlueCruise remained active. I cannot determine whether monitoring accuracy was affected, but I am concerned that a driver-monitoring camera used during hands-free Level 2 driving can physically move or become unsecured without BlueCruise immediately becoming unavailable. The loose assembly could also detach or distract the driver while the vehicle is moving. Before the repair was completed, the original authorized Ford dealer advised me to temporarily tape the loose shroud assembly back together while waiting for parts. I am reporting that recommendation because the affected area contains the driver-monitoring camera used by BlueCruise. The dealer later documented “SWAP STEERING COLUMN SHROUD WITH STOCK UNIT” and returned the vehicle to me as repaired. The same loose condition remained. The next day, a second authorized Ford dealer inspected the vehicle and documented loose steering-column-shroud fitment, stated the upper and lower halves appeared mismatched in size or tolerance, and recommended replacement of both pieces. The vehicle has now been returned to the original Ford dealer for another repair attempt. Ford Motor Company also has an open customer case. I am asking NHTSA to evaluate whether this physical mounting or retention condition could affect the BlueCruise driver-monitoring function and whether similar conditions exist in other BlueCruise-equipped Explorers.

On several occasions when trying to drive from a stopped position I press the gas and the car will move slowly but not shift into gear and then after turning off it struggles to restart. The check engine light is solid but goes away by the next day. This has happened after sitting idling in a parking lot most often but recently it happened 2 times as I was turning left onto a street where I luckily was able to slow roll to the side and not get hit. I brought it in once for service and they struggled to find the issue for hours and eventually said pins in the fuel injector were lose and replaced but it is continuing to randomly happen.

This 2026 Ford Explorer has stopped, stalled, hesitated and jerks after fuel fill-ups. It stopped twice for myself in busy intersections. The dealer has had it for weeks and when driving the vehicle back to me, stalled and hesitated for Ford Service dept. twice. They told me I could not have my car back for safety reasons.

I had my car in drive in a parking spot. I was ready to go, put the car in drive, DID NOT MOVE but needed to put it in park fast to assist to a child in the back seat. I put it in park pretty fast. Took my seatbelt off and assisted child. It must have not engaged. Car rolled into my office metal mailbox. I 100% put it in park. I took my seatbelt off after so I seen it. It was fast with the gear shift though. Should this have been an issue? I feel like if it was any other car you with a manual gear shifter , not electrical, it’s fine. I feel this was not my fault at all and was a malfunction of the car. The car did not automatically stop either. It hit the mailbox at like 3-4mph. I have never been in an accident of my fault in 10 years of driving. I’ve never made a crazy mistake like that. It should’ve never happened. I drive all types of cars/ and trucks. This is also a lease and I’m SO PISSED. Especially because my kids were in the car. Luckily no one was hurt and no property damage. Just the car.

Description On your vehicle, it may be possible that one or more engine camshaft roller finger followers were not properly installed at the time of engine assembly. Safety Risk An improperly installed engine camshaft roller finger follower may result in engine failure, resulting in a no-start condition or a loss of motive power. A loss of motive power increases the risk of a crash. Your vehicle may also experience engine ticking or tapping noise, and or a low-volume oil leak due to this condition. Remedy A remedy is not yet available. Ford Motor Company is working to provide parts for this repair. When the remedy becomes available, Ford Motor Company will notify you via mail to schedule a service appointment with your dealer for repairs to be completed free of charge. The remedy is anticipated to be available 4TH quarter of 2026. Next Steps Contact your dealer for more information to schedule the free service.

On XXX around 6:30pm: Car would not go into reverse. Upon pressing the gas a 2nd time, a loud pop was heard from the back of the car. The car was then able to drive forward, however, when pressing on the brakes, the rear end of the car would wobble, and the brakes were rubbing and making a loud noise. I contacted Rich Ford, explained that my car is brand new (2 months), with less than 4,000 miles, and this should not happen. I was told that “someone would call me the following morning around 7am”. I drove to work the next morning, XXX, avoiding the use of the brakes as much as possible. I called Rich Ford again, at around 07:45, and spoke to “Toby”. Explained to him what had happened, and asked that they pick up the vehicle to see what’s wrong. I was told that they couldn’t look at it until Monday XXX. I told Toby that I did not feel comfortable or safe driving my car anywhere, and asked that they pick up the car and provide a loaner. Toby then told me I could drop the car off on Friday, XXXat 08:00. Around 3:48pm, Wednesday, I called Rich Ford again and asked them to pick it up because I didn’t feel safe to drive it. They said “No, just drop it off on Friday”. At around 5:35pm, I got to my car, which was parked on the side street of [XXX]. I pressed the brakes, pressed the start engine button, and then went to step out of the car to talk to a co-worker. The car was in “park”. Once I stepped out with my left leg, the car began rolling forward, knocked me face down onto the road, and then ran over both of my legs. My coworker ran after the car and it stopped on the side of the road. I was rushed to a Level 1 trauma center, UNMH, with severe injuries to both of my legs. I was unable to take my car to the dealership on Friday, XXX, because of my injuries. Rich Ford had NOT REACHED OUT TO ASK WHY THE CAR WAS NOT TAKEN IN. I plan on contacting my insurance company on XXX.I have very serious injuries as a result. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Description On your vehicle, some of the bolts used to attach the vehicle trailer tow hitch may have below-specification torque. Safety Risk This condition may affect vehicle handling characteristics or lead to loss of attachment of the trailer hitch while towing, increasing the risk of a crash. Remedy Parts are now available to repair your vehicle. Ford Motor Company Lincoln has authorized your dealer retailer to inspect and secure or replace the trailer tow hitch bolts as required free of charge. Next Steps Contact your dealer for more information to schedule the free service.

The glass roof exploded while traveling down the road. No cause for failure present.

Sunroof spontaneously shattered while driving down the road.

NHTSA Vehicle Safety Complaint Narrative I am submitting this complaint to report a serious safety incident involving the rear seat belt of a Ford rental vehicle obtained from Budget Rent A Car. My [XXX] grandson was properly restrained in a weight-appropriate booster seat and secured with the vehicle’s rear lap and shoulder seat belt in accordance with child passenger safety recommendations. There had been no collision, sudden stop, or other event that would normally activate the seat belt locking mechanism. While seated in the vehicle, the seat belt became tightly wrapped around my grandson’s waist and locked in a manner that prevented it from being loosened or released. Multiple adults attempted to free him by following the normal procedures for releasing and loosening the seat belt, but all attempts were unsuccessful. An off-duty Emergency Medical Technician (EMT) stopped to assist. After repeated unsuccessful attempts to release the seat belt, the EMT determined that the only safe way to free my grandson was to cut the seat belt. The child could not be removed from the vehicle until the seat belt was cut. This incident caused significant concern because a properly functioning seat belt should not trap an occupant in a manner that prevents emergency release. My grandson had been properly restrained in a weight-appropriate booster seat and was using the seat belt as intended. I respectfully request that NHTSA investigate whether this incident represents a defect in the seat belt restraint system and determine whether similar incidents have been reported involving this vehicle or seat belt design. If appropriate, I request that this information be shared with the manufacturer so that corrective action can be taken if a safety defect exists. My goal in submitting this complaint is to help prevent another child or other vehicle occupant from becoming trapped in a seat belt and requiring emergency intervention for release. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(

Purchased new 26 Ford Explorer on [XXX] from Franklin Ford in TN. During test drive noted the BlueCruise hands free was canceling but was advised by dealer that it might need to download an update or sync my profile. Next day I confirmed the BlueCruise and adaptive cruise was not working. The hands free BlueCruise and adaptive system will cancel randomly with no warning even while in turn. This almost caused me to slam into the vehicle next to me several times but was able to catch the wheel just in time. This is an extreme danger and hazard. The issue seems to revolve around the lane centering feature but Ford has not confirmed this for me. I dropped the vehicle off with Ford of Franklin on 3/24 who kept the vehicle for 4 days. At the end I was advised Ford engendering was working to push out an update to correct this issue. As of today (5/27), I have confirmed with Ford of Franklin that there is currently no fix for this. I have had to disable Ford BlueCruise and have as of today requested a buyback from Ford. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

During a traffic accident the driver side seat airbag deployed. The airbag vent faces towards the driver when it deploys. The air escaping the vent burned through the shirt of the officer driving the vehicle and also caused a mixture of 2nd and 3rd degree burns to the hip and side abdomen region of their body.