2025 Ford F-150 Lightning BEV Problems

Our 2025 Ford Lightning has experienced multiple instances of low-speed unintended acceleration. On May 26, 2026, while coasting into a parking spot on a slight incline, the vehicle suddenly accelerated and caused a collision. The defect has occurred approximately six times over 7,300 miles of operation (approximately once every 1,200 miles). Professional collision repair was completed July 7, 2026. Defect recurred after repair. Ford Factory Service Engineer inspection on August 10, 2026 conducted a seven-mile test drive and reported "concern not duplicated". The vehicle's EDR (Event Data Recorder) failed to reliably document the collision event, recording a timestamp 1 hour 19 minutes after the actual collision occurred (NHTSA requires ±3 millisecond timing accuracy). The vehicle is unsafe and cannot be reliably driven. The defect occurs in a pattern that cannot be detected by brief test drives and poses an ongoing risk to occupants and the public.

On August 19, 2026, I was involved in a collision in my 2025 Ford F-150 Lightning after a suspected malfunction involving the automatic emergency braking, adaptive cruise control, and/or acceleration controls. Cruise control was on; BlueCruise was not. While on an exit ramp, I heard a loud warning beep, experienced automatic braking, and then felt the truck suddenly accelerate into the vehicle ahead. The unexpected braking and acceleration compromised my ability to control the truck and avoid a collision, putting me and occupants of the other vehicle at risk. I am concerned about driving this vehicle again, including with my daughter. Before the collision, I experienced three incidents in which the automatic brakes activated when no vehicles were around. I also reported a warning/error during a December 2025 service visit. The service record documents that visit; I do not know whether that issue is related to the collision. The loud warning beep occurred immediately before the collision. The truck has been at a Ford dealership for evaluation and is available for inspection upon request. The dealership has not confirmed or reproduced the suspected malfunction. The service manager told me its diagnostic testing would not necessarily show what happened during the incident and indicated limitations in obtaining crash-related data. I am requesting further investigation into the braking, cruise control, and acceleration systems. Ford Corporate and State Farm have been notified. I cannot confirm whether Ford Corporate, police, or insurance representatives have performed a technical inspection of these systems or retrieved event data. The cause remains unconfirmed.

Our 2025 Ford Lightning has experienced multiple instances of low-speed unintended acceleration. On May 26, 2026, while coasting into a parking spot on a slight incline, the vehicle suddenly accelerated and caused a collision. The defect has occurred approximately six times over 7,300 miles of operation (approximately once every 1,200 miles). Professional collision repair was completed July 7, 2026. Defect recurred after repair. Ford Factory Service Engineer inspection on August 10, 2026 conducted a seven-mile test drive and reported "concern not duplicated". The vehicle's EDR (Event Data Recorder) failed to reliably document the collision event, recording a timestamp 1 hour 19 minutes after the actual collision occurred (NHTSA requires ±3 millisecond timing accuracy). The vehicle is unsafe and cannot be reliably driven. The defect occurs in a pattern that cannot be detected by brief test drives and poses an ongoing risk to occupants and the public.

On August 19, 2026, I was involved in a collision in my 2025 Ford F-150 Lightning after a suspected malfunction involving the automatic emergency braking, adaptive cruise control, and/or acceleration controls. Cruise control was on; BlueCruise was not. While on an exit ramp, I heard a loud warning beep, experienced automatic braking, and then felt the truck suddenly accelerate into the vehicle ahead. The unexpected braking and acceleration compromised my ability to control the truck and avoid a collision, putting me and occupants of the other vehicle at risk. I am concerned about driving this vehicle again, including with my daughter. Before the collision, I experienced three incidents in which the automatic brakes activated when no vehicles were around. I also reported a warning/error during a December 2025 service visit. The service record documents that visit; I do not know whether that issue is related to the collision. The loud warning beep occurred immediately before the collision. The truck has been at a Ford dealership for evaluation and is available for inspection upon request. The dealership has not confirmed or reproduced the suspected malfunction. The service manager told me its diagnostic testing would not necessarily show what happened during the incident and indicated limitations in obtaining crash-related data. I am requesting further investigation into the braking, cruise control, and acceleration systems. Ford Corporate and State Farm have been notified. I cannot confirm whether Ford Corporate, police, or insurance representatives have performed a technical inspection of these systems or retrieved event data. The cause remains unconfirmed.

Our 2025 Ford Lightning has experienced multiple instances of low-speed unintended acceleration. On May 26, 2026, while coasting into a parking spot on a slight incline, the vehicle suddenly accelerated and caused a collision. The defect has occurred approximately six times over 7,300 miles of operation (approximately once every 1,200 miles). Professional collision repair was completed July 7, 2026. Defect recurred after repair. Ford Factory Service Engineer inspection on August 10, 2026 conducted a seven-mile test drive and reported "concern not duplicated". The vehicle's EDR (Event Data Recorder) failed to reliably document the collision event, recording a timestamp 1 hour 19 minutes after the actual collision occurred (NHTSA requires ±3 millisecond timing accuracy). The vehicle is unsafe and cannot be reliably driven. The defect occurs in a pattern that cannot be detected by brief test drives and poses an ongoing risk to occupants and the public.

On August 19, 2026, I was involved in a collision in my 2025 Ford F-150 Lightning after a suspected malfunction involving the automatic emergency braking, adaptive cruise control, and/or acceleration controls. Cruise control was on; BlueCruise was not. While on an exit ramp, I heard a loud warning beep, experienced automatic braking, and then felt the truck suddenly accelerate into the vehicle ahead. The unexpected braking and acceleration compromised my ability to control the truck and avoid a collision, putting me and occupants of the other vehicle at risk. I am concerned about driving this vehicle again, including with my daughter. Before the collision, I experienced three incidents in which the automatic brakes activated when no vehicles were around. I also reported a warning/error during a December 2025 service visit. The service record documents that visit; I do not know whether that issue is related to the collision. The loud warning beep occurred immediately before the collision. The truck has been at a Ford dealership for evaluation and is available for inspection upon request. The dealership has not confirmed or reproduced the suspected malfunction. The service manager told me its diagnostic testing would not necessarily show what happened during the incident and indicated limitations in obtaining crash-related data. I am requesting further investigation into the braking, cruise control, and acceleration systems. Ford Corporate and State Farm have been notified. I cannot confirm whether Ford Corporate, police, or insurance representatives have performed a technical inspection of these systems or retrieved event data. The cause remains unconfirmed.

Description On your vehicle, the integrated park module ipm may not properly engage the park pawl, preventing the vehicle from locking into park when park p is selected. If this condition occurs, a wrench light and shift system fault message will be displayed in the instrument panel cluster. Additionally, the vehicles electronic parking brake epb will automatically apply. Safety Risk If the park pawl is not properly engaged and the electronic parking brake epb is not applied, your vehicle may experience a roll-in-park, increasing the risk of a crash. Remedy Software is available to repair your vehicle. Ford Motor Company has authorized your dealer to update your vehicles secondary on board diagnostic module c sobdmc software free of charge. Next Steps Contact your dealer for more information to schedule the free service.

On September 19, 2025, my wife was at the wheel of our 2025 Ford F-150 Lightning (VIN: [XXX] ), a vehicle we had leased just months earlier on June 22, 2025, from Sam Galloway Ford at [XXX] . Traveling at a mere 15-20 mph when she was involved in a routine multi-vehicle collision (no citations were issued). No collision warning was sounded. The front-end impact triggered an instantaneous and ferocious eruption of flames from the truck's forward section. The vehicle was swiftly consumed in a raging inferno, leading to its complete and irreparable destruction. My wife narrowly escaped with her life, scrambling from the cab amid the explosive intensification of the fire while relying on the urgent assistance of bystanders to reach safety—mere seconds from what could have been a fatal entrapment. She endured profound terror, acute anxiety, and an overwhelming fear for her very survival in the face of this abrupt and merciless blaze. Responding emergency crews, including the fire department, pinpointed the origin at the vehicle's front end, aligning with hallmarks of a catastrophic battery or electrical malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Description On your vehicle, the integrated park module ipm may not properly engage the park pawl, preventing the vehicle from locking into park when park p is selected. If this condition occurs, a wrench light and shift system fault message will be displayed in the instrument panel cluster. Additionally, the vehicles electronic parking brake epb will automatically apply. Safety Risk If the park pawl is not properly engaged and the electronic parking brake epb is not applied, your vehicle may experience a roll-in-park, increasing the risk of a crash. Remedy Software is available to repair your vehicle. Ford Motor Company has authorized your dealer to update your vehicles secondary on board diagnostic module c sobdmc software free of charge. Next Steps Contact your dealer for more information to schedule the free service.

Description On your vehicle, the integrated park module ipm may not properly engage the park pawl, preventing the vehicle from locking into park when park p is selected. If this condition occurs, a wrench light and shift system fault message will be displayed in the instrument panel cluster. Additionally, the vehicles electronic parking brake epb will automatically apply. Safety Risk If the park pawl is not properly engaged and the electronic parking brake epb is not applied, your vehicle may experience a roll-in-park, increasing the risk of a crash. Remedy Software is available to repair your vehicle. Ford Motor Company has authorized your dealer to update your vehicles secondary on board diagnostic module c sobdmc software free of charge. Next Steps Contact your dealer for more information to schedule the free service.