2000 Ford F-250 Sd Electrical Problems

APPROXIMATELY 1 HOUR AFTER BEING PARKED IN PARKING STALL AT MY RESIDENCE, NEIGHBORS NOTICED FIRE COMING FROM THE HOOD AND UNDERNEATH THE VEHICLE (THE FIRE ORIGINATED ON THE DRIVER'S SIDE).THEY ATTEMPTED TO PUT OUT THE FIRE AND CALLED 911. SAN JOSE FIRE DEPARTMENT RESPONDED TO THE CALL AND FINISHED PUTTING OUT THE FIRE. THE VEHICLE HAD VISIBLE BURNT WIRING, RIGHT SIDE FENDER DAMAGE FROM HEAT (INSIDE AND OUTSIDE) AND THE RIGHT DRIVER'S SIDE TIRE SUSTAINED DAMAGE DUE TO MELTING DEBRIS FALLING ON TIRE. THE FIRE DEPARTMENT TOOK A REPORT OF THE INCIDENT. AS I HAVE RELAYED THIS EVENT TO OTHERS, THEY HAVE MENTIONED THAT THIS IS PROBABLY A "RECALL FIRE" AND THAT I SHOULD REPORT THIS INCIDENT. *TR

NHTSA ID

10433625

Incident

Oct 28, 2011

TL* THE CONTACT OWNS A 2000 FORD F-250 SD. THE CONTACT STATED THAT HE HEARD A CLICKING NOISE AND THE LIGHTS ON THE INSTRUMENT PANEL FLICKERED ON AND OFF. ONCE HE TURNED THE HEATER CONTROL OFF, THE FLICKERING STOPPED BUT RECURRED WITHIN A FEW MINUTES. THE CONTACT PARKED THE VEHICLE AND WHEN HE RETURNED, THE VEHICLE WAS ATTEMPTING TO START INDEPENDENTLY. HE REMOVED THE POSITIVES AND NEGATIVES FROM THE SOLENOID TO CORRECT THE FAILURE. HE THEN REATTACHED AND THE FAILURE RECURRED. IN ADDITION, SMOKE WAS EMITTING FROM THE VEHICLE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 218,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 217,000.

NHTSA ID

10396623

Incident

Apr 14, 2011

Mileage

217,000 mi

I HAD A SPARK PLUG BLOW OUT OF THE CYLINDER HEAD, AS MANY OTHER PEOPLE HAVE. THIS IS A MANUFACTURING DEFECT, AND THEY KNOW IT, SINCE THEY CHANGED THE DESIGN. THERE SHOULD BE A RECALL FOR THIS, SINCE IT IS A SAFETY ISSUE, AND IF I CANNOT FIX IT, IT WILL COST ME $2400 FOR A NEW CYLINDER HEAD. *TR

NHTSA ID

10386886

Incident

Mar 8, 2011

Mileage

103,000 mi

TL*THE CONTACT OWNS A 2000 FORD F250 HD. EVERY OTHER DAY, THE BRAKE LIGHTS AND TURN SIGNAL LIGHTS STOP WORKING. THE CONTACT MUST CONSTANTLY REPLACE THE FUSES. THE VEHICLE WAS TAKEN TO A MECHANIC AND HE DIAGNOSED FAILURE IN THE WIRING. HE STATED THAT THE FIVE ROUND WIRING HARNESSES IN WHICH TO TOW A CAMPER WAS PUT IN POOLY. THE CURRENT MILEAGE WAS 109,513 AND FAILURE MILEAGE WAS 94,650.

NHTSA ID

10206684

Incident

Oct 23, 2007

Mileage

94,650 mi

WIFE RETURNED HOME WIITH COMPLAINT OF SMELL AND SMOKE FROM ENGINE COMPARTMENT. I OPENED THE HOOD AND FOUND FLAMES COMING FORM MASTER CYLINDER AREA. UPON FURTHER INSPECTION THE FIRE WAS CENTERED ON THE BRAKE PRESSURE SWITCH, AT THE ELECTRICAL CONNECTION. *AK

NHTSA ID

10189966

Incident

May 5, 2007

CAM POSITION SENSOR/SYNCHRONIZER FAILURE ON 2000 FORD F250 SUPERDUTY WITH 7.3L POWER STROKE DIESEL ENGINE @ 64477 MILES. ENGINE STOPPED RUNNING WHILE DRIVING @ 40 MILES/HOUR ON SECONDARY ROAD. LOSS OF POWER BRAKES AND STEERING. VEHICLE TOWED TO DEALER. REPLACE PART FMC F7TZ 12K073 A. TOTAL CHARGE $503.76. *JB

NHTSA ID

10188667

Incident

Apr 13, 2007

Mileage

64,477 mi

I HAVE A 2000 F 250 DIESEL PICKUP. THE ENGINE HAS STALLS AND THUS YOU LOOSE BRAKES AND POWER STEERING. IT HAS HAPPENED WHILE GOING A LOWW SPEED 2X RECENTLY.ALSO WHILE STOPPED . I HAD THE CAMSHAFT SENSOR WHEN THE TRUCK WAS ABOUT 3 YEARS OLD. IT IS NOW OCCURING MORE OFTEN.

NHTSA ID

10185263

Incident

Feb 27, 2007

Mileage

97,000 mi

OCCASIONAL ENGINE STALL WHEN WINDSHIELD WIPER IS TURNED ON OR ON INTERMITTENT SETTING. OCCASIONAL STALLS WHEN STEERING IS TURNED QUICKLY LEFT TO START TURNING FROM STANDING POSITION AT INTERSECTIONS. FORD SERVICE DEPARTMENT WAS UNABLE TO FIND CAUSE OR MAKE CORRECTIONS. *JB

NHTSA ID

10181327

Incident

Feb 28, 2001

Mileage

10,000 mi

1. TRUCK RUNNING CORRECTLY. 2.ENGINE STOPPED, PULLED OFF ROAD, TOW REQUIRED TO FORD, ROCKLAND MAINE . 3. CPS REPLACED, ENGINE RUNNING FINE. NHTSA ACTION #: PE06011 SYNCHRONIZER OR CMP SENSOR. *NM

NHTSA ID

10173110

Incident

Nov 8, 2006

Mileage

77,100 mi

VEHICLE DIED SUDDENLY AND FAILED TO RESTART. CPS WAS REPLACED, VEHICLE RAN. *JB

NHTSA ID

10173000

Incident

Oct 12, 2006

Mileage

110,000 mi

I HAVE A F250 FORD SUPER DUTY 7.3L DIESEL,YEAR 200 101,000 MILES.WHILE MY WIFE WAS TAKING THE KIDS TO SCHOOL A FIRE STARTED UNDER THE HOOD WITH THE CRUISE DEACTIVATION SWITCH.THIS IS IN A RECALL FOR F150 AND VANS BUT NOT MY F250 DIESEL.THIS FIRE WAS FLAMING UNDER THE HOOD WHEN MY WIFE PULLED INTO A GAS STATION.ACCORDING TO ZFORD THERE ARE NO RECALLS FOR THE F250 WITH THE SAME PART

NHTSA ID

10166181

Incident

Aug 18, 2005

Mileage

102,631 mi

WHILE DRIVING MY 2000 F-250 FORD PICK UP TRUCK EQUIPED WITH THE 7.3 LITER DIESEL ENGINE, THE ENGINE SUDDENLY STOPPED RUNNING, WITHOUT ANY WARNING SIGNS. THIS OCCURED WHILE I WAS ENTERING A CIRCLE INTERSECTION, FORTUNATELY VERY EARLY IN THE MORNING BEFORE ANY RUSH HOUR TRAFFIC. WHEN THE ENGINE SHUT DOWN I LOST BOTH THE POWER STEERING AND THE POWER BRAKING SYSTEMS. I WAS STARTING MY TURN TO ENTER THE CIRCLE AND AT FIRST THOUGHT THAT I HAD A FRONT FLAT TIRE AS THE VEHICLE BARELY RESPONDED TO MY EFFORTS TO GRADUALLY TURN TO THE RIGHT. THEN, WHEN I TRIED TO STOP IT TOOK AT LEAST TWO TO THREE TIMES THE DISTANCE TO COME TO A STOP, AS IT USUALLY DOES, EVEN WITH GREATLY INCREASED PRESSURE TO THE BRAKE PEDAL. IF THER HAD BEEN A VEHICLE IN FRONT OF ME OR ANOTHER SORT OF OBSTRUCTION I COULD HAVE EASILY HIT IT. I WAS ABLE TO RETURN HOME, A DISTANCE OF APPROX 2/3 MILES , DURING WHICH THE VEHICLE STALLED OUT 4 MORE TIMES, WITH THE SAME PROBLEMS OF VERY POOR STEERING AND BRAKING . THE REPAIR SHOP REPLACED AN ELECTRICAL COMPONET REFERED TO AS A CAMSHAFT POSITION SENSOR AT A COST OF APPROX $377.00 . I WAS INFORMED THAT THIS PARTICULAR VEHICLE AND ENGINE COMBINATION USUALLY HAVE THIS SAME PROBLEM OF FAILURE OF THIS SENSOR WITHOUT ANY WARNING, E.G. THER WERE NO DASH WARNING LIGHTS OR ANY WARNING OF ANY SORT AND THE ENGINES CAN STALL OUT EITHER RUNNING AT 65 MPH OR AT IDLE OR ANYWHERE IN BETWEEN. I WAS FORTUNATE, IN THAT I WAS GOING SLOW AND THAT THERE WAS NO TRAFFIC. *NM

NHTSA ID

10164722

Incident

Aug 2, 2006

Mileage

78,250 mi

MY CPS IN MY 2000 7.3L TRUCK FAILED. *JB

NHTSA ID

10159556

Incident

Jun 12, 2006

CAME OUT FROM WORK TO GO HOME, TRUCK WOULD NOT START, JUST FILLED THE PARKING LOT WITH WHITE SMOKE. CPS SENSOR HAD FAILED WITH NO WARNING. GOT A RIDE HOME AND NEXT DAY PURCHASED A REPLACEMENT SENSOR. INSTALLED IT THAT DAY AND THIS ONE LASTED ABOUT 9 MONTHS AND HAD TO BE REPLACED AGAIN WHEN IT FAILED. IF THIS SENSOR WERE TO FAIL WHILE DRIVING, LOST OF STEERING AND BRAKING WOULD OCCUR. *JB

NHTSA ID

10152347

Incident

Aug 20, 2003

Mileage

23,000 mi

MY CPS FAILED WHILE DRIVING AND THE ENGINE STALLED LEAVING ME WITH LIMITED STEERING AND BRAKING. THE TRUCK IS A FORD F-250 WITH THE 7.3 POWERSTROKE DIESEL. THE PART WAS REPLACED UNDER WARRANTY BUT I HAD TO PAY A $100 DEDUCTIBLE. *NM

NHTSA ID

10152273

Incident

May 13, 2002

Mileage

61,435 mi

MY COMPLAINT IS ABOUT THE CPS (CAMSHAFT POSITION SENSOR) ON THE FORD 7.3L POWER STROKE ENGINES. IT SEEMS THAT MOST/ALL VEHICLES EQUIPPED WITH THIS SENSOR HAVE EXPERIENCED FAILURE, WHICH RESULTS IN THE VEHICLE STALLING. I BELONG TO SEVERAL FORUMS AND NEARLY EVERYONE HAS HAD A PROBLEM WITH THAT SENSOR AND IT IS "RULE OF THUMB" TO CARRY ONE IN YOUR GLOVE BOX FOR WHEN IT GOES BAD. THIS HAS BECOME SUCH A PROBLEM THAT YOU CAN NOW BUY THE SENSORS ON EBAY, PEOPLE HAVE BOUGHT THESE BY THE TRUCKLOAD TO SELL SINCE THEY KNOW OF THE PROBLEM. WHY SHOULD WE CONSUMERS HAVE TO WORRY ABOUT SUCH AN IMPORTANT COMPONENT OF THE ENGINE FAILING? WE SPEND 20-30-40K DOLLARS ON THESE VEHICLES AND CAN BE LEFT STRANDED ON THE SIDE OF THE ROAD DUE TO THIS ONE PART FAILING OVER AND OVER AGAIN. PLEASE, SOMEONE DO SOMETHING ABOUT THIS!!!*JB

NHTSA ID

10141911

Incident

Nov 4, 2005

Mileage

118,850 mi

2000F-250 SUPER-CREW HEAVY DUTY P/U CAUGHT ON FIRE AND BURNED UP THE WIRING AND FUSE PANEL ALONG WITH THE MASTER CYLINDER COVER. FORD HAS NOT RETURNED MY PHONE CALLS. FORD REPRESENTATIVE SAID IT WOULD BE 5 BUSINESS DAYS BEFORE ANYONE CALLED, IT WAS THE SECOND WEEK AND NO CONTACT WAS MADE. *AK

NHTSA ID

10118173

Incident

Nov 24, 2004

Mileage

60,000 mi

DRIVING HOME AT ABOUT 55MPH NOTICED A VERY BAD HESITATION IN 5.4L ENGINE AND APPARENT MISFIRE. AFTER PULLING OVER AND SHUTTING ENGINE OFF, NOTICED # 3 COIL BROKEN AND SPARKPLUG LAYING BY FUEL RAIL. SPARK PLUG SHOT OUT OF CYLINDER HEAD DUE TO POOR ENGINEERING BY FORD. 1999-2002 F250 5.4L HEADS ONLY HAVE 4 THREADS THAT HOLD SPARK PLUGS.*AK

NHTSA ID

10112627

Incident

Mar 4, 2005

CONSUMER COMPLAINED ABOUT THE ELECTRICAL SYSTEM. AT FIRST, VEHICLE LOST CRUISE CONTROL. THEN IT LOST THE BRAKE LIGHTS. WHEN TAKEN TO BE SERVICED, IT WAS DETERMINED THAT THE FAILURE WAS DUE TO A BLOWN OUT WIRING HARNESS CONNECTED TO THE CRUISE CONTROL.*AK

NHTSA ID

10109202

Incident

Dec 28, 2004

VEHICLE WAS PARKED OUTSIDE THE OWNERS HOMEAND IT CAUGHT ON FIRE. OWNER CONTACTED THE MANUFACTURER. CURRENTLY THE MANUFACTURER WAS RECALLING SEVERAL SIMILAR VEHICLES FOR THIS PROBLEM. HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL. *AK...*AK

NHTSA ID

10109076

Incident

Nov 21, 2004

Mileage

80,000 mi

TEN MINUTES AFTER PARKING THE VEHICLE IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CONTACTED TO EXTINGUISH THE FIRE. THE FIRE SEEME TO HAVE STARTED UNDER THE HOOD ON THE DRIVER'S SIDE. *AK

NHTSA ID

10083910

Incident

Jul 26, 2004

ON MY WAY HOME FROM WORK I HEARD AN UNUSUAL NOISE EMINATING FROM UNDER THE HOOD OF MY 2000 FORD F-250 SUPER DUTY, 6.8 (V-10) TRUCK. I THOUGHT IT WAS AN XHAUST MANIFOLD LEAK. I PULLED ONTO A GRAVEL ROAD, LIFTED THE HOOD AND CLIMBED UP TO LOOK TO SEE WHAT I COULD FIND. IMAGINE MY SUPRISE TO SEE A LEFT BANK SPARK PLUG, #8 CYLINDER, LYING AGAINST THE FUEL RAIL AND THE COIL FIRING AGAINST THE HEAD. I LIMPED HOME, WONDERING ALL THE WHILE HOW MUCH FUEL WAS POURING INTO THE OIL PAN! I USED A STRONG FLASH LIGHT TO PEER INTO THE SPARK PLUG HOLE AND FOUND TO MY SUPRISE, VERY LITTLE IF ANY THREADS TO CONTIAN THE SPARK PLUG. I THEN USED A 90 DEG. PICK TO "FEEL" THE THREADS. NONE. I CALLED JOE MACHENS FORD IN COLUMBIA, MO. TO SEE IF THIS MIGHT BE A COMMON PROBLEM. THEY INFORMED ME THEY SEE QUITE A FEW OF THE 5.4 LITER CYLINDER HEADS IN FOR REPAIR AND HAD HAD ONE 6.8. THEY INFORMED ME THAT FORD HAD ISSUED A TSB FOR THE LIGHTNING WITH THE 5.4 ( I CAN SEE WHY, A COMPRESSOR ON TOP OF THE ENGINE CAN CREATE PROBLEMS) OTHER THAN THE AFORMENTIONED TSB, NO OTHERS EXIST AND FORD HAS YET TO ACKNOWLEDGE THE PROBLEM. I CHECKED FOR INFO VIA THE GOOGLE SEARCH ENGINE AND WASN'T ABLE TO FIND MUCH INFORMATION. I PROBABLY USED THE INCORRECT TERMINOLOGY. WHO KNOWS HOW MUCH OF THE ALUMNIUM THREADS WERE INGESTED INTO THE CYLINDER, WHICH IN TURN WILL CAUSE SCARRING AND OIL CONTROL PROBLEMS. I DO KNOW HOWEVER, DUE TO WHAT I WAS TOLD BY THE PERSON AT JOE MACHENS FORD IN COLUMBIA, MO., IT SEEMS AS THOUGH FORD HAS NOT PRACTICED DUE DILIGENCE AS TO FINDING A SUITABLE COST EFECTIVE REPAIR OR REPLACEMENT FOR THIS PROBLEM.*AK

NHTSA ID

10082970

Incident

Jul 28, 2004

Mileage

99,500 mi

APRIL 2004. FAULTY CABLE IN STEEING COLUMN. THIS CABLE CAUSES A FAILURE WHICH DISABLES THE DRIVER SIDE AIR BAG IT ALSO DISABLES THE HORN AND CRUISE CONTROL. AFTER GOING TO SEVERAL DISCUSSION FORUMS THIS IS A COMMON PROBLEM AFFECTING 100'S PERHAPS 100 OF FORD SUPER DUTY F250, F350 VEHICLE. PER THE CHAT PAGES FORD WAS ABLE TO GET AROUND THIS ISSUE BY STATING THE FAULTY CABLING EFFECTS THE CRUISE CONTROL ONLY. THIS IS A MISCONSEPTION. ALSO BASED ON THESE CHAT PAGES THIS PROBLEM EFFECTS MOST F250,350 FROM 1999 - 2003. THE AVERAGE FAILURE TIMELINE IS 45000 - 70000 MILIES. MINE OCCURED AT 68000. *AK

NHTSA ID

10074618

Incident

Apr 3, 2004

Mileage

68,000 mi