1991 Ford F-250 Electrical Problems

TL* THE CONTACT OWNS A 1991 FORD F-250. AFTER THE VEHICLE WAS PARKED, THE CONTACT NOTICED A STRONG FUEL ODOR FROM THE SIDE OF THE VEHICLE. THE CONTACT NOTICED FUEL POURING OUT OF THE OPENING OF THE TANK THAT SPILLED ONTO THE STREET AND UNDERNEATH ANOTHER VEHICLE. THE DEALER STATED THAT THE FUEL CHECK VALVE IN THE PUMP UNIT WAS DAMAGED, WHICH CAUSED THE FUEL TO TRAVEL FROM ONE TANK TO THE OTHER AND OVERFLOW. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 137,000.

NHTSA ID

10717803

Incident

May 18, 2015

Mileage

137,000 mi

THERE WAS AN ACRID ODOR IN THE CABIN ON SEVERAL OCCASIONS. THE RADIO LIGHT BEGAN FUNCTIONING INTERMITTENTLY. THE DASH LIGHTS FAILED TO WORK TWICE. THE HEAD LIGHTS FAILED TO WORK TWICE, ON SEPARATE OCCASIONS FROM THE DASH LIGHTS. I WENT TO REPLACE THE HEADLAMP SWITCH, AND FOUND THE CONNECTOR CHARRED AND MELTED, AND THE B2 TERMINAL ON THE SWITCH WAS LOOSE AND DISCOLORED. THE SWITCH WAS CHARRED AROUND THE B2 TERMINAL.. I AM GOING TO REPLACE THE CONNECTOR ALSO. *JB

NHTSA ID

10109905

Incident

Feb 5, 2005

Mileage

115,646 mi

RECALL 96 V 071 00/ELECTRICAL SYSTEM IGNITION: VEHICLE EXPERIENCING PROBLEM WITH IGNITION SWITCH FAILING TO OPERATE/ WILL NOT TURN ON. HAD TO DISCONNECT SWITCH AND HOT WIRE TO GET VEHICLE TO START. MANUFACTURER NOTIFIED, AND INFORMED CONSUMER THAT THEY COULD NOT LOCATE VIN SYSTEM. ASKING NHTSA TO HELP IN THIS MATTER. FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS PROBLEM. *AK

NHTSA ID

889980

Incident

Jun 15, 2000

WOULD TURN ON VEHICLE GLOW PLUG WOULD NOT HEAT UP TO MOVE OR START ENGINE. WOULD NEED TO JIGGLE IT OFF/ON A LOT OF TIMES BEFORE STARTING VEHICLE. WOULD HAVE A GAUGE TO INDICATE THAT VEHICLE WAS ON. HAD NOT BEEN TO DEALER. *AK JIGGLING IT OFF AND ON TO START THE VEHICLE COULD POSSIBLY CAUSE EXPLOSION OR PERMANENT DAMAGE TO THE ENGINE. *YH

NHTSA ID

877355

FRONT TIRE WEARING UNEVENLY EVEM WITH RECENT ALINEMENT-TOOK TO AMERICAS TIRE CO. FOR ROTATION AND WAS TOLD TIRE HAD FLAT SPOTS AND ROTATION WOULD NOT HELP-TIRE DEFECTIVE. IS THIS TIRE ON THE RECALL?

NHTSA ID

734313

Incident

Oct 14, 2000

WHILE DRIVING AT NIGHT THROUGH MOUNTAINS ALL LIGHTS WENT OUT, AND CAR WAS FILLED WITH FUMES THAT MADE CONSUMER'S EYES WATER. IT SMELLED LIKE PLASTIC WIRES BURNING. VEHICLE WAS STILL DRIVEABLE AS CONSUMER PLAYED WITH SWITCH, AND THEN THEY CAME BACK ON. THE SMELL GOT SO BAD THAT CONSUMER TOOK SWITCH OUT AND FOUND THAT THE CONNECTOR WAS MELTED, BUT NO FUSES HAD BLOWN, BOUGHT A NEW CONNECTOR. DEALER/FORD CONTACTED. *AK *ML

NHTSA ID

861040

Incident

Jul 27, 1998

RECALL # 96V07100, AFTER IGNITION SWITCH WAS REPLACED OWNER STARTED EXPERIENCING ELECTRICAL PROBLEMS. DEALER DOES NOT WANT TO CORRECT. MANUFACTURER STATES THAT DEALER IS RESPONSIBLE. OWNER IS EXPERIENCING THE SAME PROBLEM WITH A F150, [XXX]. *AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

821414

Incident

Feb 9, 1998

IGNITION SWITCH FIRE. (INSURANCE COMPANY FOR CLIENT)

NHTSA ID

514717

Incident

Oct 2, 1995

IGNITION SWITCH FAILED, CAUSING LOSS OF POWER, WINDSHIELD WIPER, HEADLIGHT, BATTERY, AND TURN SIGNAL FAILURE.

NHTSA ID

514862

Incident

Sep 1, 1996

IGNITION SWITCH FAILED PRIOR TO RECALL NOTICE.

NHTSA ID

525505

IGNITION RECALL SERVICE DENIED WITH NO REASON GIVEN, WAS TOLD BY MCGARITY, CARTER FORD LINCOLN MERCURY TO GO TO ANOTHER DEALERSHIP. THIS IS THE CLOSEST LOCATION. 96V071000. *AK CONSUMER STATES WHEN HE APPLIED THE BRAKES VEHICLE PULLED TO THE RIGHT.*JB

NHTSA ID

805818

IGNITION SWITCH FIRE.

NHTSA ID

508865

Incident

Oct 2, 1995

IGNITION SWITCH FIRE. *SD

NHTSA ID

506934

Incident

Oct 2, 1995

IGNITION SWITCH FIRE. *SD

NHTSA ID

504000

Incident

Apr 26, 1996

VEHICLE WAS PARKED INTERIOR COMPARTMENT FIRE, UNDER THE DASH. *AK

NHTSA ID

983047

Incident

Mar 1, 1991