Owner-reported complaints naming the body or structure system, filed with NHTSA
Data refreshed
Reports naming the vehicle structure, frame, body panels, doors, hood and trim. Every record below is an owner-reported complaint about the 1998 Ford F-250 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
ON APRIL 9TH 2011 MY FUEL TANK STRAPS BROKE WHILE DRIVING AT 45 MPH. THE TRUCK WAS PULLED TO THE SIDE OF THE ROAD AND THE TANK WAS HANGING BY THE FUEL LINES AND TANK NECK. THE TRUCK IS A FORD F-250 LIGHT WITH A 24 1/2 GALLON FUEL TANK, THAT HAS 102000 MILES. I REPLACED BOTH STRAPS AT A COST OF $34.00. I PAINTED THE NEW STRAPS TO PREVENT FUTURE PROBLEMS. *TR
HAVE FOUND A CRACK LOCATED ON THE DRIVER'S SIDE DOOR AT WINDOW CUTOUT.*AK
BOTH DOORS OF VEHICLE EXHIBIT A FATIGUE CRACK ON THE OUTSIDE OF THE VEHICLE NEAR THE WINDOW AREA, REAR EDGE, ABOUT 3 INCHES UP FROM THE BOTTOM OF WINDOW FRAME, CRACK BEGINS AT THE RUBBER WEATHER SEAL, THEN PROGRESSES REARWARD HORIZONTALLY FOR ABOUT ,5 INCHES. WE THEN CHECKED MY BUDDIES 1997 F150 AND HIS HAD IT TOO. HE THEN CHECK 3 OF HIS FRIENDS, AND THEY ALSO HAD THE CRACKS. SEEMS THAT AUTO BODY SHOPS KNOW OF THIS PROBLEM, CHECK IT OUT SEEMS TO BE A HIGH PERCENTAGE FROM A VERY SMALL SAMPLE. *AK
WATER LEAKING TO INTERIOR OF VEHICLE CAUSED MAL-FUNCTIONS CAUSING TRUCK TO SHORT AND STOP IN INTERSECTION.*AK
DRIVER'S SIDE DOOR IS CRACKING ABOVE DOOR HANDLE. DEALERSHIP IS REPLACING DOOR. *AK
THE 6 MONTH OLD FRAME IS WARPED, THERE WAS A BREAK ON THE FRAME THAT WAS VISIBLE WHEN THE REPAIRS WERE MADE, THE DEALER STATED THAT THE SUSPENSION BROKE, CONSUMER STATES THAT THE PROBLEM IS STILL PERSISTING. *SLC
VEHICLE EXPERIENCES A PROBLEM WITH THE FRAME CONTINUALLY BECOMING WARPED EVEN AFTER BEING REPLACED, THE CONSUMER IS CONCERNED THAT IT COULD BREAK WHILE DRIVING. *SLC
ONE SIDE OF TRUCK SAT LOW, SHORTLY AFTER THE OTHER SIDE SAT LOW. REAR END AIRBAG SUSPENSION GAVE WAY AS WELL AS THE SPRINGS. AIR BAGS WERE REPLACED TWICE WITH IN 3 MONTH PERIOD. AFTER RECIEVING TRUCK FROM REPAIR SHOP IT WAS NOTICED BY BODY SHOP THAT FRAME ON LEFT SIDE WAS CRACKED. THIS CRACK WAS IN FRONT VIEW OF SERVICE PEOPLE AND NOT DETECTED. I DO NOT RECALL THE CRACK FROM THE PREVIOUS TIME THE AIR BAGS WERE REPLACED. I DO NOT RECALL THE CRACK WHEN I DROPPED THE TRUCK FOR SECOND REPLACEMENT OF AIRBAGS AND SPRINGS. THE TRUCK FRAME ON LEFT SIDE IS HELD TOGETHER BY TWO INCHES OF CONNECTING STEEL AND I HAVE BEEN ADVISED NOT TO DRIVE THE VEHICLE. THIS TRUCK IS MY LIVELYHOOD AND ONLY MEANS OF TRANSPORTATION. FORD BODY SHOP WILL NOT WELD OR REPAIR FRAME DO TO LIABILITY. THEY RECOMMEND NEW FRAME. AFTER DISCUSSION WITH SERVICE PEOPLE AND BODY SHOP MANAGER IT WAS REVEALED THAT FORD MADE CHANGES TO THE FRAME IN THE 1999 YEAR. THIS IS WHY IN THE 1998 F-250 A DISIEL ENGINE WAS NOT AVAILABLE. OTHER WORDS THE 1998 F-250 WAS FOUND TO BE A WEAKER FRAME THAN ANY OTHER YEAR. ALSO, THE DESIGN OF THE AIRBAG SUSPENSION SYSTEM OF THIS TRUCK IS WEAKER THAN EVEN THE F-150 MODELS. THE SPRINGS ARE OF LESSOR MATERIALS AND LESSOR STRENGTH. THIS WAS EXPLAINED TO ME THAT THIS WAS DONE DO TO THE AIRBAGS CAPABILITY TO MAKE UP THE DIFFERENCE IS SUPPORT. MY VIEW IS THAT ALL THESE COMPONENTS WORK IN UNISONAND WHEN ONE SYSTEM FAILED THE OTHERS FOLLOWED. THE REPAIRS I HAVE DONE ARE NOT REMEDYING THE PROBLEM AND I HAVE PAID $ 2000.00 AND MUCH LOST TIME. THERE IS A DEFECT IN THE FRAME AND FORD NEEDS TO CORRECT THIS PROBLEM. .*AK
DRIVE SHAFT MAKING NOISE. YH
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .