2001 Ford F-250 Driver assistance Problems

LOCATION MASTER CYLINDER CRUISE CONTROL DEACTIVATION SENSOR LEAKING BRAKE FLUID NON FUNCTIONAL BRAKES AND CRUISE CONTROL.

NHTSA ID

11311334

Incident

Feb 12, 2020

Mileage

240,000 mi

TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE THE VEHICLE WAS STATIONARY IN A PARKING LOT, THE CONTACT NOTICED SMOKE UNDERNEATH THE HOOD. THE CONTACT EXITED THE VEHICLE, OPENED THE HOOD, AND NOTICED FLAMES. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH WATER AND NOTICED THAT AN UNKNOWN PLUG RELATED TO THE CRUISE CONTROL WAS MELTED. NO POLICE OR FIRE REPORTS WERE FILED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS ABLE TO BE DRIVEN. THE CONTACT'S VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS TAKEN TO EL CAJON FORD (LOCATED AT 1595 E MAIN ST, EL CAJON, CA 92021, (619) 312-4107) WHERE IT WAS DIAGNOSED THAT THE UNKNOWN PLUG RELATED TO THE CRUISE CONTROL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

11265985

Incident

Sep 12, 2019

TL* THE CONTACT OWNS A 2001 FORD F-250. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, A FIRE WAS DETECTED COMING FROM UNDERNEATH THE DRIVER'S SIDE WHEEL. THE CONTACT ALSO MENTIONED THAT THE DRIVER SIDE OF THE VEHICLE EXPLODED. A POLICE REPORT WAS FILED. THE FIRE WAS EXTINGUISHED BY THE LOCAL FIRE DEPARTMENT. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS NOT TAKEN OR TOWED TO A DEALER OR INDEPENDENT MECHANIC FOR A DIAGNOSTIC TEST OR REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN THE NHTSA CAMPAIGN NUMBER: 05V170000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

11120091

Incident

Aug 11, 2018

TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE CRASHED INTO A PEDESTRIAN BRIDGE. THE DRIVER WAS FATALLY INJURED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE PEDAL WAS BENT AND OVERLAPPED THE ACCELERATOR PEDAL. THIS ISSUE MAY HAVE CAUSED THE CRASH. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 109,000. UPDATED 04/04/17 LJ *CN

NHTSA ID

10954586

Incident

Jan 11, 2017

Mileage

109,000 mi

VEHICLE WAS PARKED IN MY GARAGE AND AT 2:30 AM SMOKE ALARMS WENT OFF AND SMOKE WAS COMING OUT OF GARAGE AND MY HOUSE BURNED DOWN. FIRE INVESTIGATOR TOLD ME WAS FROM FAULTY CRUISE CONTROL SWITCH ON FORD F250. *TR

NHTSA ID

10439800

Incident

Nov 16, 2011

Mileage

126,000 mi

JULY 7, 2011, MY 2001 FORD F250 DIESEL, CAUGHT ON FIRE WHILE MY TRUCK WAS IN DRIVEWAY. I WAS ABLE TO PUT FIRE OUT BUT MY TRUCK WAS RENDERED INOPERABLE. FORD HAS CLAIMED SEVERAL THINGS THAT CAUSED THE FIRE INCLUDING A BACKFIRE (WHICH DIESELS DO NOT DO) AND THE MECHANICS I HAVE HAD TO LOOK AT IT, INCLUDING THE LOCAL FORD DEALER'S MECHANIC, CAME TO THE SAME CONCLUSION, IT WAS THE CRUISE CONTROL. FORD REFUSES TO FIX MY VEHICLE, AND I HAVE BEEN WITHOUT TRANSPORTATION SINCE THEN. I DO NOT HAVE THE ALMOST $3,000.00 THAT IT WILL COST TO FIX MY TRUCK. *TR

NHTSA ID

10424079

Incident

Jul 7, 2011

THE TRUCK WAS PARKED INSIDE A METAL BUILDING WHEN THE FIRE OCCURRED AROUND 1:41 A.M. WHILE BUSINESS WAS CLOSED. FIRE ORIGINATED FROM A FAILURE IN THE BRAKE SWITCH MOUNTED ON THE MASTER CYLINDER RESULTING IN THE VEHICLE BEING DESTROYED AND DAMAGE TO THE BUILDING AND CONTENTS.

NHTSA ID

10423729

Incident

Aug 1, 2011

TL*THE CONTACT OWNS A 2001 FORD F250. WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY WITH THE ENGINE TURNED OFF, THE OWNER HEARD A LOUD POPPING NOISE. HE WENT OUTSIDE AND NOTICED FLAMES UNDERNEATH THE HOOD OF HIS VEHICLE. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE SIDING MELTED OFF OF THE HOUSE AND SOME OF HIS WORK MATERIALS AND TREES NEXT TO THE HOUSE WERE BURNED. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED TO A SALVAGE YARD. NHTSA CAMPAIGN ID NUMBER 06V286000 (VEHICLE SPEED CONTROL) WAS DISCOVERED; HOWEVER, THE MANUFACTURER WOULD NOT DISCLOSE WHETHER OR NOT THE VEHICLE WAS INCLUDED. THE OWNER WAS INFORMED THAT AN INVESTIGATOR MAY INSPECT THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 90,000.

NHTSA ID

10266816

Incident

Apr 25, 2009

Mileage

90,000 mi

TL*THE CONTACT OWNS A 2001 FORD F250. APPROXIMATELY FIFTEEN MINUTES AFTER PARKING THE VEHICLE, THE CONTACT NOTICED FLAMES UNDERNEATH THE HOOD. THE VEHICLE WAS TOWED TO THE DEALER. RECALL # 06V286000 (VEHICLE SPEED CONTROL) WAS FOUND. AS OF JUNE 6, 2007, THE DEALER HAS BEEN UNABLE TO DETERMINE THE CAUSE OF THE FIRE. THE CURRENT AND FAILURE MILEAGES WERE 185,000. UPDATED 08/29/07 *TR

NHTSA ID

10192576

Incident

May 31, 2007

Mileage

185,000 mi

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS IDLE, A FIRE ERUPTED WHICH WAS CAUSED BY A FAULTY ELECTRICAL SYSTEM. THE FIRE ORIGINATED FROM THE ENGINE COMPARTMENT FRONT UNDERHOOD. THERE WERE NO WARNING SIGNALS PRIOR TO THE INCIDENT. UPON INSPECTION, THE CRUISE CONTROL DEACTIVATION SWITCH AND WIRING FOR THE ELECTRICAL SYSTEM WAS OBSERVED TO BE COMPLETELY BURNT TO THE GROUND. A FIRE REPORT WAS TAKEN# 06-017205. ALSO, THE MANUFACTURER WAS NOTIFIED, BUT WOULD NOT OFFER ANY RESOLUTION WHILE THIS CASE WAS UNDER INVESTIGATION.

NHTSA ID

10169341

Incident

Aug 17, 2006

Mileage

63,000 mi

WHILE TRAVELING ON THE HIGHWAY AT 60 MPH ON FLAT GROUND, WITH THE CRUISE CONTROL ENGAGED, MY TRUCK FLOORED THE GAS PEDAL. I HAD TO JAM ON THE BRAKES TO AVOID HITTING THE CAR IN FRONT OF ME. THE TRUCK JUST TOOK OFF, LIKE IT HAD A MIND OF ITS OWN. SINCE THEN I HAVE NOT, AND WILL NOT USE THE CRUISE CONTROL. I WILL NOT USE THE CRUISE CONTROL AGAIN. IT WAS VERY SHOCKING, AND TOOK THE WIND OUT OF ME. IT COULD HAVE EASILY CAUSED AN ACCIDENT. I MISSED THE CAR IN FRONT ME BY INCHES. I WILL NEVER USE THE CRUISE CONTROL ON MY TRUCK AGAIN. *JB

NHTSA ID

10165578

Incident

May 28, 2006

Mileage

45,000 mi

DT*: THE CONTACT STATED WHILE UNLOADING THE VEHICLE PARKED IN THE DRIVEWAY, SMOKE WAS OBSERVED COMING FROM UNDER THE HOOD. WHEN THE HOOD WAS OPENED, THE SPEED CONTROL SYSTEM WAS OBSERVED TO BE ON FIRE. THE FIRE WAS EXTINGUISHED BY THE CONTACT. THE DEALERSHIP DETERMINED THE VIN IS NOT INCLUDED IN THE RECALL # 05V388000.*AK

NHTSA ID

10163802

Incident

Jul 24, 2006

Mileage

96,000 mi

FORD 2001 BLEW UP INTO FLAMES WHILE PARKED IN DRIVE WAY WHILE VEHICLE WAS OFF. TOTAL LOSS. *NM

NHTSA ID

10151702

Incident

Jan 28, 2006

ELECTRICAL FIRE RESULTED IN TOTAL LOSS. *NM

NHTSA ID

10132934

Incident

Aug 8, 2005

Mileage

200,220 mi

DT THE CRUISE CONTROL STUCK TWICE, THE LAST CAME UP OUT OF THE SEAT AND HAD TO BOTH FEET ON THE BRAKE TO GET IT STOP. CONTACTED THE DEALER, WHO SAID THAT ITS NOT INCLUDED THE RECALL, AND THERE WAS NOTHING THEY COULD DO. CRUISE SET ON 59 MPH AND IT IDLED REALLY HIGH. HAD TO KEEP HITTING THE OFF BUTTON, AND PUT VEHICLE IN NEUTRA,L AND IT STILL IT WOULD NOT DISINGAGE. HAD THEM DISCONNECT CRUISE CONTROL. *AK

NHTSA ID

10129105

Incident

May 10, 2005

Mileage

46,703 mi

WE WERE NOTIFIED BY POLICE AND FIRE DEPARTMENT OFFICIALS THAT THERE WAS A FIRE IN OUR YARD. OUR FORD 250 WAS ON FIRE AND HAD NOT BEEN DRIVEN FOR AROUND 4 HOURS. UPON INVESTIGATION THE FIRE MARSHALL INDICATED THE LOCATION OF WHERE THE FIRE BEGAN AND PRESUMED IT WAS THE BRAKE PRESSURE SWITCH BASED ON ITS LOCATION. THE CAR HAS BEEN TOTALED AND CAUGHT ANOTHER VEHICLE ON FIRE NEXT TO IT.

NHTSA ID

10127808

Incident

Jul 4, 2005

Mileage

124,000 mi

THE ACCELERATOR PEDAL FAILED. THE CAUSE HAS YET TO BE DETERMINED.*AK ACCELERATOR PEDAL STOP WORKING SPORADICALLY. MAINLY HAPPENED WHEN GOING THROUGH INTERSECTIONS. *BF *NM

NHTSA ID

10115094

Incident

Mar 12, 2005

Mileage

67,000 mi

ON NOVEMBER 22, 2004 AT APPROXIMATELY 3AM, CONSUMER'S VEHICLE CAUGHT ON FIRE. THE CAUSE OF THE FIRE WAS UNDETERMINED. CONSUMER WAS AWARE OF SIMILAR INCIDENTS INVOLVING FORD TRUCKS DUE TO CRUISE CONTROL.*AK

NHTSA ID

10104991

Incident

Nov 22, 2004

Mileage

84,000 mi

THE BRAKE PEDAL AND THE GAS PEDAL ARE TOO CLOSE, AND GAS PEDAL IS 1/2 INCH LOWER. WHEN STEPPING ON THE BRAKE PEDAL CONSUMER CAN HIT THE GAS PEDAL AT THE SAME TIME. DEALER STATES NO MODIFICATION BECAUSE OF DESIGN SPECIFICATIONS. *AK THIS PROBLEM WOULD BECOME WORSE IN THE WINTER WHEN THE CONSUMER WEARS BOOTS. *SC

NHTSA ID

10062965

Incident

Mar 11, 2004

CONSUMER WAS BEHIND ANOTHER VEHICLE WITH THE CLUTCH ENGAGED. THE VEHICLE SUDDENLY TOOK OFF AND ALMOST HIT ANOTHER CAR. THE CONSUMER HAD TO SHUT OFF THE ENGINE TO STOP THE VEHICLE. THE BRAKES WERE INOPERATIVE AND THE CLUTCH WAS STUCK TO THE FLOOR.*AK *TS *JB

NHTSA ID

10038530

Incident

May 24, 2002

Mileage

27,668 mi

CONSUMER WAS PULLING OUT OF AN INTERSECTION ONTO A FOUR LANE HIGHWAY. THE CONSUMER FLOOR THE ACCELERATOR PEDAL IN ORDER TO GET UP TO SPEED WITH ONCOMING TRAFFIC WHEN THE VEHICLE SUDDENLY IDLED DOWN. THE VEHICLE WAS TAKEN TO THE DEALER WHO DETERMINED THAT THE THROTTLE STOPPING DEVICE ON THE PEDAL ASSEMBLY BENT WHEN THE PEDAL WAS FLOOR AND CAUSED THE TRUCK TO IDLE DOWN INSTEAD OF UP. THE STEERING WHEEL DID NOT RESPOND WHEN THE CONSUMER SLAMMED ON THE BRAKE. *JG *NLM

NHTSA ID

568019

WHILE TRYING TO APPLY BRAKES TO SLOW DOWN VEHICLE UNEXPECTEDLY STARTED TO ACCELERATE. CAUSE UNKNOWN CONTACTED DEALER, AND DEALER COULD NOT DETERMINE THE CAUSE. *AK

NHTSA ID

8008849

WHILE APPLYING BRAKES AND SLOWING DOWN ENGINE WILL CONTINUE TO SURGE AND ACCELERATE. THIS PROBLEM IS CAUSING AN INCREASE IN STOPPING DISTANCE AND TROUBLE MAINTAINING CONTROL OF TRUCK. COULD NOT DETERMINE A CAUSE FOR THIS PROBLEM. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / ATTACHMENTS.*AK

NHTSA ID

898279

Incident

Apr 1, 2001