2004 Ford F-250 Electrical Problems

The contact owns a 2004 Ford F-250. The contact stated while driving at an undisclosed speed and attempting to accelerate, the vehicle jerked and briefly lost motive power before the vehicle stalled. No warning lights were illuminated. After several attempts, the vehicle restarted. The vehicle returned to normal functionality, but the failure became a regular occurrence. The vehicle was taken to an independent mechanic; however, no cause for the failure was found. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact related the failure to NHTSA Campaign Number 05V270000 (ELECTRICAL SYSTEM); however, the VIN was not included. The failure mileage was approximately 100,000.

NHTSA ID

11664449

Incident

Feb 2, 2023

Mileage

100,000 mi

I purchased this truck in January 2023. Drove just fine for 2 months and started having this issue. While driving my 2004 f250 sd 6.0l turbodiesel 4x4, (egr deleted, bulletproofed and studded engine, cold air intake, oil cooler, sct x4 tuner) a "fizzle" noise was heard more on passenger side; acting like fuel wasn't reaching engine; and truck stalled right after noise was heard. Wouldn't restart on a hot engine. Crank-no start. Drained both batteries attempting to restart. Restarted after cold engine but would stalled out and not be able to restart while hot engine. Replaced both fuel filters, fuel pump, some module in front bumper relating to fuel system. A friend that knows diesel engines has been trying to find out why its operating the way it is. I treated the gas tank to (2) SEAFOAM for trucks and had valvoline in Ferndale, WA do an oil change after purchasing it. Recalls say that they've been done, but could this issue be caused by the FICM recall?

NHTSA ID

11536759

Incident

Mar 1, 2023

I was driving in nampa around 5pm when my truck lost power my fuel peddle had 0 response tried to pull off the road almost had an accident because truck died losing steering power and brakes was hard to push truck had lost the voltage board in the ficm. Upon going over forums this is a major common issue amongst many ford owners. I also have a ground short from unknown location not sure as to what has caused this but assuming it has to do with the wiring harnesses to the ficm. I feel Ford should be in repair of this due to the large amount of issues across the nation of 6.0 owners but this is a very dangerous situation for owners. Not having steering control in such a large truck is extremely dangers. Previous owner had same issue and replaced the ficm and said it shouldn’t ever be an issue I feel there is a wiring issue that needs to be addressed.

NHTSA ID

11457900

Incident

Mar 2, 2022

VEHICLE LOSES ALL POWER-STALLS AND LOSES FUNCTION WHEN IDLING. HAS OCCURRED WHEN EXITING FREEWAY WAY AND IN A REGULAR NEIGHBORHOOD STREETS. NEED TO RESTART AFTER STALL.

NHTSA ID

11387696

Incident

Jan 2, 2021

Mileage

200,000 mi

REDUCED POWERED UNDER A GRADE/LOAD. REDUCED ACCELERATION. BOGS DOWN, CANNOT REACH SPEEDS HIGHER THAN 40-45 MPH, UP HILL.

NHTSA ID

11271433

Incident

Aug 15, 2019

Mileage

136,000 mi

TL* THE CONTACT OWNS A 2004 FORD F-250. WHILE DRIVING 40 MPH, THE VEHICLE STALLED AND IT TOOK NUMEROUS ATTEMPTS TO RESTART. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT NOTIFIED. AN INDEPENDENT MECHANIC DIAGNOSED THE VEHICLE, BUT WAS NOT ABLE TO LOCATE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE WAS SIMILAR TO WHAT WAS LISTED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 150,000. *BF* 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

NHTSA ID

11217074

Incident

Apr 1, 2019

Mileage

150,000 mi

EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART. IT WILL ALSO STALL AFTER LETTING OFF THE THROTTLE WHEN APPROACHING A STOP AND OCCASIONALLY WHILE WHILE STOPPED AT A LIGHT. RPM'S WILL ALSO DROP TO 500 AND I HAVE NO THROTTLE RESPONSE, IF IT DOESN'T STALL COMPLETELY. THIS MAY OCCUR 4 OR MORE TIMES A DAY, THEN MAY NOT OCCUR AGAIN FOR A FEW DAYS OR WEEKS. THERE IS ABSOLUTELY NO TELLING WHEN IT WILL OCCUR, IT IS TO RANDOM TO IDENTIFY THE PROBLEM. NOW MY HORN AND CRUISE CONTROL HAVE STOPPED WORKING AS WELL, WHEN I REPLACE THE FUSE IT BLOWS IMMEDIATELY. I HAVE REPLACED THE FICM, EBP SENSOR AND WIRING, FUEL PUMP AND STILL HAVE NOT RESOLVED THE PROBLEM. MY TRUCK IS NOT SAFE TO DRIVE. THIS HAS BEEN HAPPENING SINCE SHORTLY AFTER BUYING THE TRUCK IN 2018, BUT SEEMS TO BE GETTING WORSE AS THE TEMPERATURE WARMS UP. THE FOLLOWING RECALL NUMBER 05V270000 SOUNDS EXACTLY LIKE WHAT I AM EXPERIENCING, BUT DOES NOT SHOW A RECALL FOR MY TRUCK.

NHTSA ID

11208303

Incident

May 16, 2019

Mileage

156,000 mi

TL* THE CONTACT OWNS A 2004 FORD F-250. THE CONTACT STATED THAT THE GAUGES ON THE DASHBOARD BECAME INOPERATIVE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 151,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10862465

Incident

Jan 7, 2013

Mileage

151,000 mi

TL* THE CONTACT OWNS A 2004 FORD F-250. WHILE DRIVING 50 MPH WITHOUT WARNING, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNDER RECALL. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM) HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 225,000. UPDATED 1/21/2016 *SS *TR

NHTSA ID

10789981

Incident

Nov 7, 2015

Mileage

225,000 mi

TL* THE CONTACT OWNS A 2004 FORD F-250. THE CONTACT STATED THAT THE FUEL LINES WERE SEVERELY CORRODED AND WERE LEAKING. AS A RESULT, THE TRANSMISSION FAILED WHILE DRIVING AT 40 MPH, CAUSING THE CONTACT TO USE EXCESSIVE FORCE IN ORDER TO DRIVE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REPLACED THE POWER STEERING FUEL LINE, ONE BRAKE LINE, AND ONE TRANSMISSION FUEL LINE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000. UPDATE 01/13/16 MA

NHTSA ID

10779797

Incident

Sep 5, 2015

Mileage

180,000 mi

TL* THE CONTACT OWNS A 2004 FORD F-250. WHILE DRIVING AT ANY SPEED, THE VEHICLE WOULD STALL WITHOUT WARNING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 184,000.

NHTSA ID

10733944

Incident

Jun 20, 2015

Mileage

184,000 mi

DRIVING THE VEHICLE 20MPH LOST ALL POWER TO ENGINE, LEFT WITHOUT POWER STEERING, BRAKES OR CONTROL OF VEHICLE. PULLED OVER AND TRIED TO START VEHICLE, IT DID NOT START, BUT AFTER A FEW MINUTES IT RESTARTED. THIS HAS HAPPENED THREE TIMES IN FEBRUARY 2015. I CONTACTED FORD MOTOR COMPANY, WAS ASSIGNED A CASE NUMBER. SHE CHECKED ON NHTSA RECALL 05V270000. SHE STATED THAT THE REPAIRS TO THIS VEHICLE HAVE ALREADY BEEN COMPLETED AND THAT I WAS NOW ON MY OWN IN REGARDS TO REPAIRS. WHILE DOING RESEARCH, I HAVE FOUND OUT THAT PEOPLE ARE STILL HAVING SOME PROBLEMS REGARDING THIS ISSUE. FORD SEEMS TO HAVE WASHED THEIR HANDS OF THIS ISSUE OF RESPONSIBILITY REGARDING THEIR VEHICLES. THIS IS WHY I AM FILING A CASE. *TR

NHTSA ID

10689658

Incident

Feb 10, 2015

Mileage

155,256 mi

TL* THE CONTACT OWNS A 2004 FORD F-250. THE CONTACT STATED THAT THE VEHICLE STALLED SEVERAL TIMES. THE VEHICLE WAS ABLE TO RESTART, BUT THE FAILURE PROGRESSED. THE VEHICLE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

10669681

Incident

Oct 6, 2014

TL* THE CONTACT OWNS A 2004 FORD F-250. THE CONTACT STATED THAT WHILE EXITING A DRIVEWAY, THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED AFTER STALLING ON MORE THAN OCCASION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC, WHO ALSO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 15000.

NHTSA ID

10574666

Incident

Feb 1, 2005

Mileage

15,000 mi

MY VEHICLE HAS BEING STALLING WHILE DRIVING AT 1ST START UP IN THE MORNING FOR OVER 3 WEEKS. THE PROBLEM IS NOW GETTING DAILY. I UNDERSTAND THERE IS A RECALL 05S34 THAT HAS THIS PROBLEM WITH THE FORD DIESELS. MY VEHICLE IN CURRENTLY BROKEN DOWN ABOUT 60 MILES FROM MY HOME. THE AUTO REPAIR SHOP THINKS ITS A HIRING HARNESS TO THE FICM. *TR

NHTSA ID

10490409

Incident

Dec 24, 2012

Mileage

124,000 mi

HAD MISS FIRES IN ENGINE THIS TRUCK HAS NEVER SHOWN CHECK ENGINE LIGHT WHILE DRIVING DOWN ROAD AT 70 MPH THE ENGINE STARTED MISSING CHECK ENGINE LIGHT NEVER CAME ON??? TOOK TRUCK TO SHOP .THE ENGINE MELTED THE TIP OFF A SPARK PLUG IN SIDE THE CYLINDER ,IT DESTROYED THE CYLINDER WALL HAVE TO REPLACE ENGINE.ASKED THE TECH WHAT CAUSED THIS HE SAID ENGINE WAS RUNNING TO LEAN THIS TRUCK HAS NEVER SHOWED CHECK ENGINE LIGHT AND THERE WAS NO TROUBLE CODES FOR TECH TO READ??? SOMETHING IS NOT RIGHT WITH THE COMPUTER SYSTEM IN THIS TRUCK. *JS

NHTSA ID

10455899

Incident

Apr 10, 2012

Mileage

159,000 mi

ABOUT 9/15/2010 THE VEHICLE, WHILE STOPPED AT A RED LIGHT FAILED TO ACCELERATE WHEN LIGHT CHANGED AND THE GAS PEDAL WAS DEPRESSED. THE TRUCK THEN STALLED AND TOOK UP TO 5 MINUTES TO RESTART. THE INCIDENT DID NOT REPEAT FOR SEVERAL MONTHS. THE NEXT INCIDENT THE TRUCK FAILED TO ACCELERATE AFTER SLOWING TO NEAR STOP AT A YIELD AT A HIGHWAY CROSSING NEARLY CAUSING AN ACCIDENT. REPLACED FUEL FILTER AND HAD A TUNE UP ALTHOUGH IT HAD RECENTLY BEEN DONE AND IT DIDN'T HAPPEN AGAIN FOR A FEW WEEKS. AFTER A FEW WEEKS OF HARD DRIVING WITH NO INCIDENCE THE TRUCK AGAIN FAILED TO ACCELERATE ON HIGHWAY ENTRANCE RAMP NEARLY CAUSING ANOTHER ACCIDENT. AFTER PULLING OVER AND TURNING OFF THE ENGINE AND RESTARTING IT DROVE ON THE HIGHWAY FINE, BUT STALLED WHEN EXITING THE HIGHWAY. THE LATEST INCIDENT, DRIVING ON THE HIGHWAY THE TRUCK DROVE FINE, UNTIL EXITING. IT FAILED TO RESPOND TO PRESSURE ON THE GAS PEDAL AND STALLED LEAVING A WOMAN AND CHILD ON THE SIDE OF THE ROAD FOR 2 HOURS WAITING FOR A TOW. DURING THAT TIME IT WOULD NOT START. TOWED TO DEALERSHIP AND AFTER HAVING THE VEHICLE FOR A WEEK, THEY STATED THEY PULLED CODES SHOWING FUEL INJECTOR WAS BAD, EGR VALVE STICKING, NEEDS SOME SORT OF WIRING HARNESS, TURBO NEEDS CLEANING AND SOME SORT OF CHIP TOTAL COST OVER $2000.

NHTSA ID

10444317

Incident

Sep 15, 2010

Mileage

95,000 mi

2004 FORD F250. CONSUMER STATES FAULTY ICP SENSOR OR FAULTY EGR VALVE *TGW THE REVERSE PLANET GEAR IN THE TRANSMISSION WAS REPLACED. THE EGR VALVE REPLACED THREE TIMES, THE EGR COOLER, OIL COOLER WERE ALL REPLACED. THE R&R TURBO INTAKE WAS REPLACED TWICE, THE TURBO INNER COOLER, WIRING HARNESS ON THE ENGINE, TRANSFER CASE, FICM MODULE WERE REPLACED. THE ALTERNATOR AND BATTERY WERE REPLACED THREE TIMES, THE VALVE ASSEMBLY, HIGH PRESSURE AND REGULAR OIL PUMPS WERE REPLACED AND A NEW EGR SHIELD WAS INSTALLED. THE VEHICLE ALSO STALLED WHILE DRIVING DOWN THE INTERSTATE. *JB

NHTSA ID

10411072

Incident

Jul 1, 2011

TL*THE CONTACT OWNS A 2004 FORD F-250. THE CONTACT STATED WHILE STOPPED THE VEHICLE WOULD INTERMITTENTLY SURGE FORWARD MOMENTARILY. THE CONTACT ALSO STATED THE ACCELERATOR PEDAL WOULD NOT ALWAYS RESPOND WHEN PRESSURE WAS APPLIED TO IT AND THE VEHICLE WOULD INTERMITTENTLY STALL WHILE DRIVING AT ANY SPEED. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER STATED THAT THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 05V270000 (ELECTRICAL SYSTEM:WIRING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 76,000.

NHTSA ID

10398468

Incident

Apr 7, 2011

Mileage

76,000 mi

TL* THE CONTACT OWNS A 2004 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT SPEEDS OF 65 MPH AND HIGHER, THE VEHICLE WOULD CONTINUOUSLY STALL. THE CONTACT STATED THAT THE FAILURE WAS CAUSED BY THE MAIN WIRING HARNESS RUBBING AGAINST THE INJECTOR CONTROL MODULE CAUSING A SHORTAGE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE A NEW WIRING HARNESS AND INJECTOR MODULE WERE INSTALLED. THE FAILURE MILEAGE WAS 158,000 AND THE CURRENT MILEAGE WAS 170,000.

NHTSA ID

10322775

Incident

Sep 15, 2009

Mileage

158,000 mi

TL* THE CONTACT OWNS A 2004 FORD F-250 EQUIPPED WITH A DIESEL ENGINE. THE CONTACT WAS DRIVING AT APPROXIMATELY 65 MPH, WHEN THE VEHICLE SUDDENLY SHUT OFF COMPLETELY WITH NO POWER STEERING. HE WAS ABLE TO GET THE VEHICLE SAFELY TO THE SIDE OF THE ROAD AND HAD IT TOWED TO A REPAIR SHOP. THE MECHANIC AT THE REPAIR SHOP REPLACED THE WIRING HARNESS AND ONE OF THE FUEL INJECTORS. HOWEVER, THE WIRING HARNESS SHORTED OUT AGAIN AND A FUEL INJECTOR IN ANOTHER AREA BLEW. THE CONTACT THEN TOOK THE VEHICLE TO THE DEALERSHIP WHERE HE WAS INFORMED THAT THE WIRING HARNESS AND THE FUEL INJECTION MODULE HAD FAILED. HE WAS ALSO ADVISED TO REPLACE THE WIRING HARNESS AND THE MODULE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 170,000.

NHTSA ID

10322680

Incident

Feb 28, 2010

Mileage

170,000 mi

TL*THE CONTACT OWNS A 2004 FORD F250. THE ENGINE FAILED TO START AFTER SEVERAL ATTEMPTS. THERE WERE NO PRIOR WARNINGS. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR A DIAGNOSTIC TEST. THE TECHNICIAN STATED THE FAILURE WAS DUE TO VIBRATION OF THE WIRING HARNESS SHORTAGE. THE CONTACT IS AWARE OF THE SAFETY RISK INVOLVED. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 151,000 AND THE CURRENT MILEAGE WAS 151,300. THE VIN WAS UNAVAILABLE.

NHTSA ID

10266529

Incident

Apr 19, 2009

Mileage

151,000 mi

TL*THE CONTACT OWNS A 2004 FORD F250. WHILE DRIVING ON TWO SEPARATE OCCASIONS, THE VEHICLE SHUT OFF WITHOUT WARNING. THE VEHICLE RESTARTED APPROXIMATELY TEN MINUTES LATER AND HAD TO BE TOWED. NHTSA CAMPAIGN ID NUMBER 05V270000 (ELECTRICAL SYSTEM:WIRING) WAS REFERENCED. THE VEHICLE WAS DIAGNOSED BY A MECHANIC. THE SPEED AND FUEL SYSTEM WERE UNKNOWN. THE CURRENT MILEAGE WAS 27,150 AND FAILURE MILEAGE WAS 27,140. UPDATED 5/19/08 *CN UPDATED 05/19/08

NHTSA ID

10224936

Incident

Apr 5, 2008

Mileage

27,140 mi

DT*: THE CONTACT STATED THE VEHICLE HAD THE SAME PROBLEMS AS DEFINED IN NHTSA RECALL #05V270000, BUT THE MANUFACTURER STATED THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE VEHICLE LOST POWER AND DID NOT ACCELERATE ON TWO DIFFERENT OCCASIONS. THE SECOND OCCASION THE VEHICLE STALLED AND WAS NOT ABLE TO BE RESTARTED. THE SERVICE DEALER COULD NOT LOCATE THE PROBLEM.

NHTSA ID

10166156

Incident

Aug 10, 2006

Mileage

42,000 mi

DT: THE VEHICLE WAS TAKEN TO REPAIR SHOP 8 TIMES FOR STALLING. EACH TIME THE DEALER DID SOMETHING AND IT CONTINUED TO STALL. THEY REPLACED THE PROCESSOR, WIRING HARNESS, AND A NUMBER OF OTHER THINGS. THIS STARTED OCT 12,2004. *AK

NHTSA ID

10132922

Incident

Oct 12, 2004

Mileage

4,200 mi