2013 Ford F-250 Fuel system Problems

TRUCK HAS JUST TURNED 20,000 MILES. AFTER HAVING THE DEF SYSTEM SERVICED AT THE FORD DEALERSHIP TRUCK HAS TO GO THU THE PARTICULATE FILTER REGEN SOONER AND SOONER. NOW EVERY 75 MILES. WHICH CAUSES TRUCK TOO LOSE POWER AND PRODUCE EXCESIVE EXHAUST TEMPERATURES WHICH CAN POTENTULLY CAUSE A FIRE. FORD IS TELLING ME THE EXHAUST EMISSSION SYSTEM IS OUT OF WARANTY YET TRUCK JUST HAS 20,000 MILES. THIS IS UNACCEPTABLE AND A DANGER TO MYSELF, MY FAMILY, AND ANYONE NEARBY

NHTSA ID

11714095

Incident

Oct 18, 2025

The contact's son owns a 2013 Ford F-250. The contact stated that the vehicle was parked while working and after returning to the vehicle and attempting to restart the vehicle, the message "Reduced Power" was displayed, and the vehicle was not able to be started. The contact's son had the vehicle towed to an independent mechanic who diagnosed the vehicle and determined that the high-pressure fuel pump had failed, and the fuel system and fuel pump needed to be replaced. The vehicle was repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the VIN was not included. The failure mileage was 206,181.

NHTSA ID

11633952

Incident

Oct 18, 2024

Mileage

206,181 mi

The contact owns a 2013 Ford F-250. The contact stated that while driving at 70 MPH, the vehicle stalled with the check engine warning light illuminated. The contact was able to pull the vehicle off to the side of the road; however, the vehicle failed to restart after multiple attempts. He initially had the vehicle towed to a dealer where he was informed that his vehicle could not be inspected for two weeks. The contact then towed the vehicle to an independent mechanic who informed him that the fuel pump was defective and needed to be replaced. The manufacturer had been notified of the failure and provided him with a case number. The vehicle had yet to be repaired and remained in the possession of the dealer. The failure mileage was approximately 77,000.

NHTSA ID

11445218

Incident

Dec 18, 2021

Mileage

77,000 mi

HIGH PRESSURE PUMP WENT OUT CAUSING THE FUEL SYSTEM TO FELL.. RECEIVED AN ESTIMATE TO REPLACE THE PUMP AND FUEL SYSTEM. OVER 9,000 TO FIX.. MY HUSBAND WAS DRIVING AT THE TIME WHEN THE PUMP WENT OUT.. CAUSING IT TO SHUT DOWN, WE HAD IT TOWED TO THE CLOSEST FORD DEALERSHIP.

NHTSA ID

11210662

Incident

May 13, 2019

Mileage

140,000 mi

ENGINE LIGHT IS ILLUMINATED WHILE DRIVING AND STOPPED ON DASH AND CODE P208 COMES UP FOR THE REDUCTANT HEATER FAILED, THIS CAUSES THE EXHAUST SYSTEM TO NOT FULLY CLEAN OUT AND COULD PLACE THE TRUCK INTO A LIMP MODE CAUSING DECREASED POWER AND POTENTIALLY STOP THE VEHICLE ALL TOGETHER

NHTSA ID

11181268

Incident

Jan 24, 2019

Mileage

104,500 mi

WHILE DRIVING THE CHECK ENGINE AND REDUCED POWER MESSAGE SHOWED UP LEAVING THE VEHICLE DEAD ON THE ROAD. WITHIN 30 SECONDS THE TRUCK HAD STALLED AND WAS NOT ABLE TO RE-START. TRUCK WAS TOWED TO THE DEALERSHIP WHERE IT WAS FOUND THAT THE CP4 HP PUMP HAD FAILED CONTAMINATING THE ENTIRE FUEL SYSTEM. THE REPAIR BILL WAS ~$8,200

NHTSA ID

11143865

Incident

Oct 4, 2018

Mileage

102,000 mi

I WAS DRIVING AND MY CHECK ENGINE LIGHT CAME ON. I TOOK IT TO THE DEALER AND THE CODE WAS P205C, WHICH REDUCTANT TANK TEMPERATURE SENSOR CIRCUIT LOW. I WAS TOLD BY THE FORD DEALER THAT IT NEEDED TO BE REPLACED AND THAT THERE WAS A RECALL FOR THIS PART FROM TRUCKS MADE FROM AUG 2009 TO OCT 23 2012 AND MY TRUCK WAS MADE ON NOV 5, 2012. MY TRUCK MISSED BEING A PART OF THIS RECALL BY LESS THAN 2 WEEKS! I THINK THAT IT IS OBVIOUS THAT THE RECALL SHOULD BE EXPANDED TO INCLUDE MORE VIN NUMBERS CORRESPONDING TO TRUCKS MANUFACTURED LATER.

NHTSA ID

11118222

Incident

Aug 3, 2018

Mileage

52,000 mi

THIS VEHICLE HAS A 6.7 DIESEL ENGINE. 5 EXHAUST GAS SENSORS HAVE BEEN REPLACED IN THE FIRST 57,000 MILES. THE LAST NEW SENSOR LASTED FOR ONE WEEK AND LESS THAN 250 MILES OF DRIVING.

NHTSA ID

11015945

Incident

Aug 16, 2017

Mileage

56,500 mi

I WAS DRIVING ON A LOCAL INTERSTATE WHEN MY 2013 FORD F-250 6.7 DIESEL SHUT OFF. I WAS IN THE FAST LANE, THE TRUCK LOST ALL POWER AND RAPIDLY SLOWED DOWN. LUCKILY I WAS ABLE TO GET THE TRUCK OVER TO THE SHOULDER USING STROBE LIGHTS AND HAZARD LIGHTS TO WARN OTHER VEHICLES THAT I HAD A SERIOUS PROBLEM. THE INTERIOR OF THE TRUCK BEGAN TO SMELL OF DIESEL FUEL AND IT BECAME DIFFICULT TO BREATHE. I CALLED MY DEALER, AND THE LOCAL TOWING COMPANY CAME TO GET IT. AFTER APPROX. 1 WEEK AT THE DEALER AND EXPECTING THIS TO BE AN INSTANT WARRANTY REPAIR, FORD MOTOR CO. HAS DENIED ANY WARRANTY COVERAGE CLAIMING "FUEL CONTAMINATION." THE ESTIMATED REPAIR IS $11,500 AND THE TRUCK THAT I PURCHASED ON AUGUST 3, 2013 FOR $50K+ IS NOW ESTIMATED TO BE WORTH $12,000 UNLESS REPAIRED. I AM NOT COMFORTABLE IN THE TRUCK ANYMORE AND I READ ALL OVER THE INTERNET ABOUT THIS PROBLEM AND HOW FORD IS NOT TAKING RESPONSIBILITY FOR A FLAW ON THEIR END. THERE ARE PEOPLE ALL OVER THE COUNTRY WITH THE SAME ISSUE AND EVEN STILL FORD WILL NOT OWN UP TO IT AND REPAIR THEM UNDER WARRANTY. THE NEW 2015 TRUCK HAS A COMPLETELY REDESIGNED FUEL SYSTEM WHICH IS A CLEAR INDICATION THAT THEY KNEW IT WAS A PROBLEM WITH THEIR OIL/WATER SEPARATORS AND THEIR FUEL SYSTEM. AS OF NOW, I LOST $40,000 IN 1 YEAR (OWNED TRUCK FOR 13 MONTHS PRIOR TO CATASTROPHIC FAILURE) AND COULD HAVE BEEN SERIOUSLY INJURED HAD I NOT BEEN ABLE TO GET OFF THE ROAD. *TR

NHTSA ID

10629574

Incident

Aug 13, 2014

Mileage

21,000 mi