2025 Ford F-350 Sd Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2025 Ford F-350 Sd, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine421.1%
- Powertrain (other)421.1%
- Electrical421.1%
- Driver assistance315.8%
- Visibility15.3%
- Brakes15.3%
- Fuel system15.3%
- Airbags15.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
The contact owns a 2025 Ford F-350 SD. The contact stated that while driving at an undisclosed speed, the DEF (Diesel Exhaust Fluid) level reading became inoperable with the message “500 Miles to Empty - Refill Soon” displayed. The vehicle was taken to the dealer but was not diagnosed. The contact was informed that the DEF gauge had been replaced by the dealer. The vehicle was repaired; however, the failure recurred. The manufacturer was made aware of the failure. The failure mileage was approximately 15,512.
After using manual mode and brakes to slow down I went back to automatic mode without coming to a stop. I was turning left and it felt like I had let off the gas completely but I was pressing harder and harder but my truck wouldn't do anything and the gas pedal did nothing. Then a second later it aggressively accelerated and went back to normal. It did it once 2 weeks ago also when I was turning right and I thought it was just the proximity sensor or something thinking I was too close to a car or something and cut power but there was no beeping. I have it on the dash camera if that helps.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
After a few hundred mile trip we stopped at a gas station, put it in park but left the vehicle running. After about 5 minutes of idling put it in reverse and everything acted as normal. Shifted into drive and there was no power to the engine. Was able to get the truck moving before seeing that the transmission was stuck in 7th gear. Shortly after the check engine light came on. Pulled over and stopped and turned the truck off for about 10 minutes and then started it to see the check engine light went off and the truck was acting normal. Got back on the freeway and proceeded the last several hundred miles home and when I pulled off the freeway the transmission was stuck in 7th again. Was able to limp it to the dealership and ended up needing a new transmission with only 2,200 miles.
After using manual mode and brakes to slow down I went back to automatic mode without coming to a stop. I was turning left and it felt like I had let off the gas completely but I was pressing harder and harder but my truck wouldn't do anything and the gas pedal did nothing. Then a second later it aggressively accelerated and went back to normal. It did it once 2 weeks ago also when I was turning right and I thought it was just the proximity sensor or something thinking I was too close to a car or something and cut power but there was no beeping. I have it on the dash camera if that helps.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
When putting truck in reverse the rear cameras pop on the 12 inch screen, as I was backing up the screen flashed couple times and froze. Not knowing with no beeping, no real time video or even the collision control braking did not work causing me to back into a concrete light post causing damage to the rear bumper and side panel. This has flickered couple times before but not like this. The truck only has 2502 miles on it.
My vehicles turn signal audio indicator is extremely quiet and cannot be heard at speeds above 45MPH creating a safety issue. I have checked the vehicle audio settings in addition to the vehicle owner manual and there is no user setting to adjust audio. I asked the dealer where i purchased my vehicle (Northtown Ford, Menomonie, WI) about the issue and they did not have a solution.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
When putting truck in reverse the rear cameras pop on the 12 inch screen, as I was backing up the screen flashed couple times and froze. Not knowing with no beeping, no real time video or even the collision control braking did not work causing me to back into a concrete light post causing damage to the rear bumper and side panel. This has flickered couple times before but not like this. The truck only has 2502 miles on it.
The contact owns a 2025 Ford F-350. The contact stated that while driving at an undisclosed speed, the vehicle independently accelerated. The contact stated that the transmission independently shifted from first gear. In addition, the contact stated that the vehicle was uncontrollable. The contact turned the vehicle off, shifted into neutral, and parked the vehicle in the nearest driveway. There were no warning lights illuminated. The vehicle was restarted, and the vehicle was driven to the intended destination. The contact stated that the failure had not reoccurred. The contact stated that the vehicle drove normally after the initial failure. The vehicle was not diagnosed or repaired by an independent mechanic. The manufacturer was not made aware of the failure. The contact stated that several attempts were made to contact the manufacturer. The failure mileage was approximately 1,400.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
The contact owns a 2025 Ford F-350 SD. The contact stated that while driving at an undisclosed speed, the front passenger's side wiper arm failed to function as intended. The vehicle was taken to the dealer, where it was diagnosed with a front passenger's side wiper assembly failure. The contact was informed that the front passenger's side wiper assembly needed to be replaced. The vehicle was not repaired. The contact was informed that the part was on back order. The contact stated that after forty days, the parts were still not available. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that the delivery date for parts was unavailable. The failure mileage was approximately 2,700.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
Trailer Braking System on Vehicle when hooked to trailer will intermittenly fail to recognize connection and not apply brakes to trailer while stopping. Dealership has acknowledged problem exist and cannot isolate cause nor resolve safety issue and returned vehicle unrepaird. First appeared after purchase of new vehicle, dealership continued to claim it was my new trailer. Problem has been ongoing and there was a recall by Ford Motors acknowleding issues with trailer brake system and still unable to repair and returned unfixed.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
The contact owns a 2025 Ford F-350SD. The contact stated that while operating the vehicle, the message "499 Miles remaining of DEF" was displayed. The contact indicated that the message was displayed even though the DEF was 75% FULL. The failure had occurred on several occasions. The vehicle was taken back to the local dealer who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 100.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
Front end collision at 57 mph impact with another vehicle and air bags did not deploy
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .