2006 Ford F-350 Suspension Problems

The contact owns a 2006 Ford F-350. The contact stated that while driving approximately 45 MPH, the front passenger wheel drove over a small dip in the roadway and the vehicle started to shimmy. The contact stated that the vehicle was difficult to steer. The contact continued driving at a slower speed to allow the shimmy to self-correct. There was no warning illuminated. The contact had taken the vehicle to an independent mechanic to be diagnosed; however, no cause for the failure was found and the failure was not duplicated. The vehicle was not repaired. The mechanic checked for recalls related to the failure and advised the contact that the manufacturer had issued a recall for the failure (09L02) for severe steering wheel and front wheel vibrations. The manufacturer was not informed of the failure. The failure mileage was approximately 265,000.

NHTSA ID

11675113

Incident

Jul 2, 2025

Mileage

265,000 mi

The contact owns a 2006 Ford F-350. The contact stated that while driving 35 MPH, the front of the vehicle started to wobble. While driving over a pothole, the vehicle wobbled violently. The contact was unable to control the vehicle while driving over 35 MPH. While driving at an undisclosed speed, the contact detected smoke coming from the vehicle. The engine warning light was illuminated. The contact called the local dealer, who informed him there were no recalls. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 99,856.

NHTSA ID

11562586

Incident

Dec 15, 2023

Mileage

99,856 mi

Vehicle has experienced "death wobble," a common and well documented occurrence in Ford F250 and F350 model trucks. This has occurred on multiple occasions since 2006, and most recently on 4/26/2022. The incident occurred while traveling approximately 45 MPH, and hitting a small bump in the road. When the "death wobble" occurs, the vehicle shakes violently and is difficult to control. This creates a hazardous situation for the occupants of the vehicle and other vehicles/pedestrians in the vicinity of the vehicle. Prior and current attempts to contact Ford service departments, typically involves Ford stating there is not a recall and any repair outside of warranty are the responsibility of owner. The vehicle is available for inspection upon request. There is no warning prior to the "death wobble," and occurs when the vehicle is travelling at speed more than 45 MPH.

NHTSA ID

11462633

Incident

Apr 26, 2022

8 years ago was crossing RR tracks and vehicle started violently shaking had to slow to 10mph for it to stop. Checked found nothing wrong finished drive home. Took to Ford dealership and they said some tricks shake when tire pressure is wrong and didn't find anything wrong with vehicle. Truck did this once more and after that when I approach RR tracks I slow to 5- 10 mph to keep it from happening. Took it back to Ford 1 time and again they spoke about tire pressure but tire pressure was fine. In the last 2 weeks anytime I hit a bump the truck violently shakes I took to a mechanic shop and they said something was wrong with front end but not sure what. I called Ford and they said to bring it in. We will see what happens because this truck has done this off and on for the last 8 years, but now it does it all the time. It has been shaking so violently I wouldn't be surprised if other damages have happened from it.

NHTSA ID

11452299

Incident

Feb 1, 2022

My truck experiences what I have learned is called the death wobble. The condition occurs intermittently but usually at speeds above 50mph and seems to be initiated by hitting any small bump. The whole front end shakes violently like the tires have been half filled with lead causing them to rotate wildly out of round. The truck actually bounces up and down rapidly and the steering wheel shakes violently creating a very unsafe driving circumstance. My research into this issue uncovered that this is a well-known condition that has been reported multiple times by many different Ford truck owners and that it occurs on Ford trucks of various year make and model. I also am aware of Fords service letter 09L02 advising owners to maintain proper air pressure to combat the issue. It is my opinion that Fords efforts to address this issue are woefully inadequate and the NHTSA has allowed this manufacturer to produce and provide an unsafe vehicle to the public for way to long. This is a hazardous condition that needs to be properly addressed.

NHTSA ID

11419405

Incident

Mar 9, 2021

DRIVING EAST ON INTERSTATE I10 EAST OF BENSON, AZ AT AROUND 75MPH, HIT A ROUGH PATCH OF ROAD AND THE VEHICLE WENT WILD, SHAKING, VIBRATING, LOSS OF CONTROL. I HIT THE BRAKES AND WENT ACROSS 3 LANES OF TRAFFIC INTO THE MEDIUM, WHERE I SKIDDED TO A STOP. I SEE FROM THE INTERNET THIS IS CALLED THE F350 DEATH WOBBLE! THE FORD F350 AND ALL RELATED VEHICLES NEED TO BE TAKEN OFF THE ROADS, THEY ARE A POTENTIAL DEATH TRAP. I COULD HAVE BEEN KILLED OR SERIOUSLY INJURED IN THIS ACCIDENT OR EVEN WORSE SOME INNOCENT FAMILY COULD HAVE BEEN KILLED IN A HEAD ON ACCIDENT! MY FORD F350 VEHICLE HAS AROUND 60,000 MILES, SUPERDUTY, 4X4. IT IS IN EXCELLENT CONDITION WITH A CAB OVER CAMPER.

NHTSA ID

11404937

Incident

Oct 1, 2020

Mileage

60,000 mi

TRUCK VIBRATES UNCONTROLLABLY AFTER HITTING BUMPS OR UNEVEN PAVEMENT AT HIGHWAY SPEEDS I REPLACE THE BRAKES THREE TIMES AND THAT DIDN'T FIX IT THIS HAS BEEN GOING ON SINCE IT HIT ABOUT 60K MILES. IT NOW HAS 108K I CAN NOT TRUST THIS TRUCK ANYMORE.

NHTSA ID

11402525

Incident

Feb 27, 2021

Mileage

60,000 mi

ON 2/28/21 AND 3/6/21 WHILE DRIVING AT HIGHWAY SPEED, I EXPERIENCED TWO SEPARATE VIOLENT SHAKING EVENTS OF THE FRONT SUSPENSION AND STEERING. BOTH EVENTS OCCURED AT APPROXIMATELY 70MPH UPON CROSSING PAVEMENT JOINTS. THE SHAKING IS SO VIOLENT YOU LOSE THE ABILITY TO CONTROL THE VEHICLE AND JUST HOPE IT DOESN'T CAUSE A WRECK. THE SHAKING WILL NOT STOP UNTIL SPEED IS REDUCED TO APPROXIMATELY 20MPH, WHICH IN ITSELF IS DANGEROUS ON AN INTERSTATE HIGHWAY. A PASSENGER IN MY TRUCK DURING FIRST INCIDENT SAID HE THOUGHT I HAD HIT A LOAD OF PIPES IN THE ROAD. DURING THE SECOND EVENT, NEARBY MOTORISTS LOOKED AT ME LIKE MY TRUCK WAS FALLING APART. I AM VERY UPSET THAT FORD AND NHTSA HAVE NOT ISSUED A RECALL. THIS PROBLEM STARTED WHEN VEHICLE WAS BRAND NEW. FIRST DEALER TOLD ME THERE WAS NOTHING THEY COULD DO. A SECOND DEALER TIGHTENED VARIOUS FASTENERS ON FRONT SUSPENSION AND MADE STEERING BOX VERY TIGHT. I WAS ALSO GIVEN NEW ALIGNMENT SPECS (WHICH I GAVE TO TIRE INSTALLER), AND ADVISED INFLATING TIRES TO MUCH HIGHER PRESSURE THAN TRUCK WAS DELIVERED NEW WITH. IT IS UNWORKABLE BECAUSE IT RESULTS IN BRUTAL RIDE IF TRUCK IS OPERATED WITHOUT PAYLOAD. I BELIEVE THESE EVENTS ARE CAUSED BY UNDAMPED RESONANCE IN THE FRONT SUSPENSION. IT FEELS LIKE THE WHEELS ARE ALTERNATELY POUNDING UP AND DOWN, LEFT AND RIGHT SIDE. THE STEERING WHEEL OSCILLATES SO HARD YOU CAN'T HOLD ON.

NHTSA ID

11399954

Incident

Feb 28, 2021

Mileage

135,000 mi

I WAS RIDING DOWN HWY55 AT ABOUT 65 TO 70 MPH AND TRUCK STARTS TO WOBBLE AND BOUNCE UNCONTROLLABLY. THE TRUCK BOUNCED TO THE OTHER SIDE OF THE ROAD. I THOUGHT I HAD A FLAT. AFTER GATHERING MYSELF I GOT OUT TO CHECK TRUCK AND THERE WAS NO FLATS AND ALL LUGS WAS THERE. I THOUGHT MAYBE I RAN OVER SOMETHING BUT ABOUT 12 MILES DOWN THE TRUCKS DOES IT AGAIN. BUT THERE ARE MANY CARS BEHIND AND ON THE SIDE OF ME. CARS AND TRUCKS ARE GOING DOWN THE OF ROAD TO GET OUT OF WAY. THIS IS SO A VERY FRIGHTEN AND HORRIBLE EXPERIENCE WHEN YOU ARE NOT PREPARED OR AWARE OF ABOUT THIS TRUCK. FORD TO BE ON OF THE TOP TRUCK MANUFACTURE IT GREATLY SADDEN ME TO KNOW THAT YOU ARE VISUALLY AWARE OF THE TRUCKS DEATHLY DEFECT FOR OVER 15 YEARS. YOU HAVE NOT MADE AN EFFORT TO PROVIDE A SAFE DURABLE PRODUCT TO PROTECT YOUR ROYAL CUSTOMERS OR YOURSELVES. TECHNOLOGY HAS AFFORDED MANY SEEN APPLICATION TO DO SO. YET YOU HAVE IGNORE WHAT IS YOUR COMPANY FUTURE.

NHTSA ID

11361469

Incident

Sep 27, 2020

Mileage

220,000 mi

DEATH WOBBLE, THE TRUCK SHAKES VIOLENTLY WHEN I DRIVE ON THE FREEWAY SINCE DAY ONE WHEN I BOUGHT IT . THE DEALER WON'T FIX IT THAT , THERE'S NOTHING WRONG WITH IT .AND THE DEALER SAYS TO REMOVE AIR FROM THE TIRES AND IT SHOULD STOP THE SHAKING .

NHTSA ID

11300513

Incident

Jan 20, 2020

Mileage

200,000 mi

DRIVING ON INTERSTATE AT APPROX 60 MPH, HIT PATCH IN ROAD, LOST CONTROL OF VEHICLE, DEATH WOBBLE, ALMOST CAUSED CRASH WITH 6 OTHER VEHICLES. WENT STRAIGHT TO DEALERSHIP TOLD IT WAS STEERING SHIMMY SHOCK FAILURE. ALIGNMENT. PAY FOR OUT OF POCKET, ALTHOUGH HAD SAME TRUCK IN SHOP FOR FRONT END REPAIRS IN JANUARY 2019.

NHTSA ID

11241718

Incident

Aug 5, 2019

Mileage

99,987 mi

THE FRONT SUSPENSION WOBBLES VERY BAD WHEN GOING 40-60 MILES OVER A SMALL UNEVEN PAVEMENT. JUST REPLACED THE TIRES AND GOT AN ALIGNMENT. STILL HAVING THE SAME PROBLEM, I'M NOT ABLE TO DRIVE MY TRUCK CAUSE IT WOBBLES SO BAD THAT I HAVE TO COMPLETELY STOP FOR THE WOBBLING TO STOP. I PURCHASED MY TRUCK NEW AND NOW HAS 92K AND HAD NEVER BEEN IN AN ACCIDENT OR AFTER MARKET TIRES OR PARTS. I HAVE ALWAYS KEPT IT WITH GENUINE PARTS DON'T KNOW THE PROBLEM AND NEED HELP.

NHTSA ID

11203415

Incident

Apr 19, 2019

Mileage

92,000 mi

WHILE TOWING MY LARGE CAMPER, ON THE FREEWAY, I HIT A BUMP. THE FRONT END OF THE TRUCK STARTED SHAKING VIOLENTLY. IT WAS ALL I COULD DO TO STOP THE TRUCK WITHOUT WRECKING. I HAD TO STOP IN THE TRAFFIC LANE. THIS WAS AN EXTREMELY DANGEROUS SITUATION. AFTER RESUMING TRAVEL, THE FRONT END WOULD SHIMMY AT ABOUT 45 MPH. I HAD TO DRIVE HOME AT 40 MPH...ROUGHLY ANOTHER 75 MILES. I THINK I HAVE SEEN AN ADVISORY LETTER FROM FORD, TO OWNERS, CONCERNING THIS. THERE ARE MANY, MANY INSTANCES OF THIS HAPPENING. ONE CAN FIND DOZENS OF EXAMPLES OF THIS HAPPENING IF ONE LOOKS ON LINE. NEITHER FORD NOR THE LOCAL FORD DEALER SEEMS TO BE AWARE OF THE PROBLEM. WE WERE TRAVELING AT ABOUT 60 MPH AT THE TIME OF THE INCIDENT.

NHTSA ID

10991433

Incident

May 21, 2017

Mileage

50,500 mi

TL* THE CONTACT OWNS A 2006 FORD F-350. WHILE DRIVING 65 MPH OVER BUMPS IN THE ROAD, THE VEHICLE SHOOK VIOLENTLY. THE DEALER DIAGNOSED THAT THE FRONT AXLE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED BECAUSE THE REMEDY WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10873902

Incident

Jun 5, 2012

FORD F-350 2006 OSCILLATION I HAVE FILED A PREVIOUS COMPLAINT BEFORE RE THE VIOLENT OSCILLATION THAT HAPPENS WITH OUR FORD F-350 TRUCK. WE HAVE HAD MORE EVENTS AT SLOWER SPEEDS AND THE SHAKING IS ALMOST UNMANAGEABLE NOW. WEDNESDAY MAY 11 APPROX 1PM EXITING THE BOURNE BRIDGE MA. I WAS DRIVING AT APPROX 40MPH AND EXITING THE BRIDGE. THERE WAS A ROUGH CONSTRUCTION PATCH ON THE ROAD RIGHT WHERE THE ROAD CONNECTS TO THE BRIDGE. AS I HIT THE ROUGH PATCH, THE OSCILLATION BEGAN AND THE TRUCK SHOOK UNCONTROLLABLY APPROACHING THE ROTARY. THERE WAS A LOT OF TRAFFIC AND CARS IN THE LANE BESIDE ME THAT COULD HAVE BEEN DAMAGED. MAY 20, 2016 AT APPROX 5PM. MY HUSBAND WAS DRIVING WEST ON HIGHWAY ROUTE 6, CAPE COD MA AT APPROX 55MPH. AS HE PASSED EXIT 6, HE HIT A ROUGH PATCH AND THE TRUCK BEGAN OSCILLATING VIOLENTLY. HE WAS UNABLE TO CONTROL IT AND SWERVED IN BOTH LANES OF THE WESTERLY 2-LANE HIGHWAY ALSO RUBBING AGAINST THE CURB. LUCKILY THE TRAFFIC STOPPED WHEN SEEING HIS TRUCK OUT OF CONTROL AND NO ONE WAS HURT OTHER THAN MY HUSBAND BEING TOTALLY SHAKEN. THE TIRES HAVE BEEN INFLATED AS RECOMMENDED BY FORD WHEN THE SENT A LETTER RE THIS DEFECT. THIS TRUCK IS DANGEROUS, NOT ONLY TO US BUT OTHERS WHO ARE ON THE ROAD. I HAVE CONTACTED THE PLYMOUTH FORD DEALER WHERE THE TRUCK WAS PURCHASED, FORD CUSTOMER SERVICE AND FORD HEAD OFFICE. EVEN THOUGH THEY ACKNOWLEDGE THE TRUCKS ARE DEFECTIVE, THEY SAY THEY ARE NOT RESPONSIBLE FOR REPAIRING THEM. OUR TRUCK IS OSCILLATING REALLY BADLY AND IS DANGEROUS TO DRIVE. THIS SHOULD BE A RECALL, NOT ONLY FOR THOSE OF US DRIVING THESE DEFECTIVE FORD F-350 2006 TRUCKS, BUT FOR THE OTHER INNOCENT LIVES ON THE ROAD.

NHTSA ID

10871068

Incident

May 20, 2016

Mileage

125,000 mi

TL* THE CONTACT OWNS A 2006 FORD F-350. WHILE DRIVING OVER A BUMP AT 35 MPH, THE VEHICLE VIBRATED VIOLENTLY. IN ADDITION, THE STEERING WHEEL ALSO VIBRATED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE CONTACT WAS UNSURE AS TO WHAT REPAIR WAS PERFORMED ON THE FRONT SUSPENSION OF THE VEHICLE. THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120.

NHTSA ID

10822088

Incident

Feb 28, 2005

Mileage

120 mi

FORD F-350 2006 COMPLAINT. WE HAVE EXPERIENCED VIOLENT SHAKING (SHIMMYING) WHEN THE TRUCK HITS A BUMP ON THE HIGHWAY AND AS A RESULT, EXTREME DIFFICULTY MAINTAINING THE VEHICLE ON THE ROAD. OUR FIRST EXPERIENCE WAS IN AUGUST 2015, ON THE INTERSTATE HIGHWAY WHILE TRAVELLING AT 75MP. WE HIT A BUMP AND THE TRUCK / STEERING WHEEL SHOOK VIOLENTLY FOR ABOUT 10 SECONDS CAUSING US TO SWERVE ACROSS LANES AND STRUGGLE TO KEEP THE TRUCK IN THE LANE AND OUT OF TRAFFIC'S WAY. WE HAVE SINCE EXPERIENCED THIS PROBLEM FOUR MORE TIMES HITTING BUMPY HIGHWAYS AT SPEEDS AS LOW AS 50MMP AND AS RECENT AS 2 WEEKS AGO. WE HAVE CHECKED IT OUT AND OUR MECHANIC ADVISED THAT HE COULD NOT FIND ANYTHING WRONG. IT HAS BEEN A GREAT CONCERN OF OURS AS IT PUTS OUR LIVES (AND THOSE ON THE ROAD WITH US) AT DANGER WHEN THIS ISSUE OCCURS. ADDITIONALLY, EVERY TIME THE VIOLENT SHAKING OCCURS, IT THROWS OFF THE ALIGNMENT AND BALANCING FOR THE TRUCK. WE HAVE JUST RECEIVED A LETTER FROM FORD ADVISING OF THIS PROBLEM AND I HAVE CALLED THE SERVICE CENTER FROM THE FORD DEALER WE BOUGHT THE VEHICLE FROM. FORD IS NOT ASSUMING RESPONSIBILITY FOR ANY DIAGNOSIS OR REPAIRS TO THESE DEFECTS AT THIS TIME. OUR TIRE PRESSURE IS IN KEEPING WITH FORD'S RECOMMENDATIONS AS THEY SUGGEST IN THEIR LETTER. FORD F-350 TRUCKS SHOULD NOT BE APPROVED FOR USE ON HIGHWAYS AS THIS DEFECT COULD RESULT IN FATAL ACCIDENTS IF THE SHAKING CANNOT BE CONTROLLED. ALSO, FORD SHOULD BE RESPONSIBLE FOR REPAIRING THE FAULTY TRUCKS.

NHTSA ID

10820797

Incident

Aug 8, 2015

Mileage

120,000 mi

SHIMMY IN FRONT END FORCES LOSS OF STEERING CONTROL. SHIMMY OCCURS AT SPEEDS OVER 50 MPH. HAS NOTHING TO DO WITH TIRE PRESSURE, CONTRARY TO FORD MOTOR COMPANY CLAIMS. THIS IS A PROBLEM WITH THE FRONT END STEERING DESIGN AND SHOULD BE REVIEWED IN GREATER DETAIL BY THE NHTSA AND FIXED WITH MORE THAN A LETTER FROM FORD TELLING ME TO CHECK THE AIR PRESSURE IN MY TIRES. AIR PRESSURE IS PERFECT AND THE PROBLEM STILL EXISTS.

NHTSA ID

10819574

Incident

Jan 7, 2016

Mileage

115,000 mi

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE INDEPENDENTLY SWAYED SIDE TO SIDE WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE DRIVE SHAFT, CASE SHIFTER, TRANSMISSION, LIFT PUMP, TRANSFER CASE, LEFT CALIBER, FUEL LINE AND REAR SHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 131,000. MA 08/13/15 UPDATED 09/01/2015*LJ UPDATED 10/14/2015*JS

NHTSA ID

10730174

Incident

Jun 19, 2015

Mileage

131,000 mi

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT THE SUSPENSION WAS UNSTABLE AND WOULD SHAKE WHILE THE VEHICLE WAS BEING DRIVEN AROUND A CURVE OR AT VARIOUS SPEEDS SPORADICALLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE DEALER REPLACED THE POWER STEERING HOSES AND THE STEERING STABILIZER HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT A CASTER ADJUSTMENT WOULD NEED TO BE PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DECLINED TO PROVIDE THE CONTACT A REMEDY TO REPAIR THE VEHICLE. THE FAILURE MILEAGE WAS 20,000.

NHTSA ID

10576849

Incident

Apr 2, 2008

Mileage

20,000 mi

TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT THE WHILE DRIVING APPROXIMATELY 35 MPH, THE FRONT END OF THE VEHICLE AND THE STEERING WHEEL EXPERIENCED SEVERE VIBRATION AFTER THE CONTACT DROVE OVER A ROAD DIP. THE CONTACT STATED THAT THE DEFECT WOULD RECUR WHEN DRIVING AT ANY SPEED AND ANYTIME THE VEHICLE WAS DRIVEN OVER A DIP OR ROAD WINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 60,000.

NHTSA ID

10563867

Incident

May 2, 2011

Mileage

60,000 mi

OUR TRUCK EXPERIENCED A SEVERE, VIOLENT WOBBLE THAT STARTED AFTER TRAVELING OVER A UNEVEN SPOT ON THE ROAD. WE FEARED FOR OUR LIVES AS THIS OCCURRED WHILE PASSING ANOTHER TRUCK ON A BRIDGE WITH HEAVY TRAFFIC BEHIND US. THE SHAKING AND WOBBLE CONTINUED FOR ABOUT 20 SECONDS, AND DID NOT STOP UNTIL THE TRUCK SLOWED DOWN TO ABOUT 40 MILES AN HOUR. ALL OUR TIRES HAVE BEEN RECOMMENDED AND INSTALLED AT THE FORD DEALERSHIP. I MAINTAIN TIRE PRESSURES AS INDICATED ON DOOR JAM. 75 LB ON FRONT AND 60 LB ON REAR TIRES. THERE ARE NO AFTERMARKET MODIFICATIONS ON OUR TRUCK. I CONSIDER THIS ISSUE VERY DANGEROUS, AND WONDER HOW MANY FOLKS MAY HAVE BEEN INJURED OR KILLED AS A RESULT OF THEIR TRUCK SUDDENLY BECOMING UNCONTROLLABLE, AS OURS DID. *TR

NHTSA ID

10533024

Incident

Aug 1, 2013

Mileage

81,000 mi

BOUGHT TRUCK USED WITH APPROXIMATELY 35,000 MILES. DRIVING DOWN THE ROAD FROM 45 TO 55 THE FRONT SUSPENSION GETS A TERRIBLE SHIMMY. WHEN THIS OCCURS, ITS HARD TO HANDLE THE TRUCK. THE FRONT END SHAKES VIOLANTLY. A DANGEROUS SITUATION SINCE I AM NORMALLY PULLING A RACE CAR WITH THIS TRUCK. TRUCK IS NOT A DAILY DRIVER. IT'S AVERAGE USE IS 4 TO 6 TIMES PER MONTH. IN ORDER TO GET THE SHIMMY TO STOP, SOMETIMES I CAN SLOW DOWN BELOW 40 MPH. OTHERWISE, I HAVE TO STOP. IT MAY OR MAY NOT GO AWAY. THE STRANGE THING IS THAT IT DOES NOT ALWAYS DO THIS. THE TRUCK HAS NEW SHOCKS, NEW TIRES, BALANCED, AND ALIGNED. TIRES ARE APPROVED FOR THE TRUCK. THE SHIMMY HAS BECOME MORE FREQUENT AND IS PREMATURLY WEARING THE TIRES. TIRES ARE INFLATED PROPERLY FOR USE OF THE VEHICLE. PROBLEM HAS RECENTLY STARTED WITHIN THE LAST 6 TO 7 MONTHS. MILEAGE IS CURRENTLY 78,490. THEREFORE SHIMMY STARTED AT APPROXIMATELY 75, 000 MILES. *TR

NHTSA ID

10510586

Incident

Sep 19, 2012

Mileage

75,000 mi

UPON DRIVING AT HIGHWAY POSTED SPEED, I ENCOUNTERED A BUMP IN THE ROAD WHILE IN A TURN. UPON HITTING THE BUMP, IT SENT MY FRONT-END INTO A VIOLENT SPEED-WOBBLE WHICH ALMOST PUT MY FAMILY AND I INTO THE RETAINING WALL. BEING THAT I'M A FORMER STATE POLICE OFFICER, I MAY HAVE "SAVED" US ONLY BY BEING HIGHLY TRAINED WITHIN DRIVING AND VEHICLE CONTROL. I HAVE READ FORUMS WITH MANY STATING THAT THEY HAVE EXPERIENCED THE SAME FLAW, SOME WITH NOT VERY GOD ENDINGS. *TR

NHTSA ID

10491526

Incident

Sep 19, 2012

Mileage

67,800 mi

THIS VEHICLE SINCE NEW HAS HAD NUMEROUS INCIDENTS WITH A SEVERE UNCONTROLLABLE SHIMMY IN FRONT END AND STEERING WHEEL.I HAVE HAD IT TO THE DEALER NUMEROUS TIMES AND THEY TELL ME THERE IS NOTHING WRONG WITH IT. FORD HAS SENT A FEW NOTIFICATIONS STATING THAT THEY ARE AWARE OF THE PROBLEM,BUT THAT IT IS JUST CAUSED FROM IMPROPER INFLATION.I HAVE SET THE TIRES TO MANUFACTURERS RECOMMENDED PSI WEEKLY,AND DOESN'T MAKE A BIT OF DIFFERENCE.FORD IS CLOSING THEIR EYES ON THIS ONE, AND IT IS GOING TO COST LIVES!!!.WHEN THIS OCCURS YOU HAVE ABSOLUTELY NO CONTROL OF THE VEHICLE.ANOTHER PROBLEM WITH THIS VEHICLE IS THE ENGINE IS JUNK. MY VEHICLE HAS 43000 MILES CURRENTLY,AND HAS HAD THE MOTOR TAKEN OUT OF IT TWICE ALREADY FOR REPAIRS!!!,AND HAS BEEN TO DEALER AT LEAST 6 OR 7 TIMES.I OWN A SMALL TREE CARE COMPANY AND REALLY CANT AFFORD A $45000 MISTAKE TO A MULTI BILLION DOLLAR COMPANY. *TR

NHTSA ID

10443216

Incident

Nov 15, 2006

Mileage

2,500 mi