2008 Ford F-450 Sd Problems

FUEL TANK DELAMINATION LEADING TO BLOWN ENGINE X2 AND FUEL PUMP REPLACEMENT X2. I USE NO ADDITIVES AND BUY ONLY COMMERCIAL FUEL ALMOST EXCLUSIVELY IN NORTHEAST GEORGIA.

ENTERED ON 10/04/2016 AT 2:45:07 PM EDT (GMT-0400) BY [email protected]: SENDER NAME: SENDER EMAIL: SUBJECT: FORD F-450 COOLING SYSTEM FAILURE AND ENGINE PROBLEMS COMMENTS: I PURCHASED THIS TRUCK NEW IN 2008 AND DROVE IT CROSS COUNTRY TOWING MY 5TH WHEEL. AT 4,544 MILES THE RADIATOR BLEW APART. (DRIVING HIGHWAY/TOWING) THIS WAS REPLACED UNDER WARRANTY AFTER FIGHTING WITH FORD. AT 6,065 MILES I HAD ANOTHER COOLING SYSTEM LEAK.(DRIVING LOCAL) THEY HAD TO REPLACE THE "SMALL" RADIATOR, THE "FUEL AND TURBO" COOLER. AT 21432 MILES THE POWER STEERING PUMP WENT AND HAD TO BE REPLACED.(DRIVING/TOWING/LOCAL) SHOP STATED THAT "FLUID WAS CONTAMINATED" (THIS TRUCK HAS ONLY BEEN SERVICED BY FORD) AT 22215 MILES I HAD TO HAVE THE LEFT REAR AXLE SEAL, BRAKE PADS AND LOWER CAC HOSE FOR TURBO REPLACED.( DRIVING HIGHWAY/TOWING) NOW AT 29,017 MILES THE RADIATOR TANKS HAVE SEPARATED FROM THE CORE AND NEED TO BE REPLACED AGAIN ALONG WITH THE CRANK SEAL AND ANOTHER POWER STEERING PUMP.( COMBINATION, HIGHWAY/LOCAL/TOWING? NOT TOWING) I HAVE CHECKED WITH FORD AND THEIR CUSTOMER SERVICE DEPARTMENT AND THEY REFUSE TO COVER ANY OF THIS, OR ANY PART, UNDER WARRANTY. I HAVE ALSO DONE RESEARCH ON THESE TRUCKS HAVING FOUND MANY OTHER OWNERS HAVING THE SAME COOLING SYSTEM ISSUES ALONG WITH OTHER ISSUES THAT FORD REFUSED TO COVER. PLEASE LOOK INTO THIS ISSUE, I THINK THEY NEED TO HAVE A RECALL ON THE COOLING SYSTEMS IN THEIR TRUCKS. THANK YOU FOR TAKING THE TIME TO READ THIS. I WOULD APPRECIATE A RESPONSE. CHECK EDMUNDS FORD F-450 SD TURBO DIESEL REVIEW, MULTIPLE COMPLAINTS OF COOLING SYSTEM FAILURE, ENGINE FAILURE. *TR

FUEL TANK DELAMINATION LEADING TO BLOWN ENGINE X2 AND FUEL PUMP REPLACEMENT X2. I USE NO ADDITIVES AND BUY ONLY COMMERCIAL FUEL ALMOST EXCLUSIVELY IN NORTHEAST GEORGIA.

I HAVE 2008 FORD F450 WITH 60 K MILES AND RADIATOR START LEAKING AT THE BOTTOM AND IT WAS BUILDING PREASSURE ON THE TOP OF ATIFREAZE BOX AND HEAT AIR STOPED WORKING AND FORD DEALER THAT I BOUGHT FROM DISNT COVER THE WARRANTY I PAID 1400$ TO GET PROBLEM FIXED AND IT SECOND RADIATOR THAT I CHANGED FROM MY POCKET !!!! I THINK FORD NEEDS TO DO SOMETHING WITH THAT IT SHOULD BE A RECALL FOR ALL 2008-2014 POWER STROKE DIESEL ENGINES

The contact owns a 2008 Ford F-450. The contact stated while driving at approximately 65 MPH, the transfer case exploded, and the front windshield shattered. No injuries were sustained; however, several other vehicles sustained cosmetic damage. No warning light was illuminated. A Police report was filed. The vehicle was not drivable and was towed to an independent mechanic for a diagnostic test. The contact was informed that the transfer case, drive shaft assembly, fuel injection pump, fuel lines, and transmission wiring harness needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and confirmed that there was no recall associated with the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 164,176.

I WAS MAKING A LEFT HAND TURN AFYER STOPING AT A TRAFFIC LIGHT AND LOSS POWER. THE ENGINE LIGHT CAME ON AND THE TURBO PRESSURE GAUGE DROPPED. I TOOK THE TRUCK INTO THE DEALER AND THE DEALER TOLD ME THAT A MANAFOLD BOLT HAD BROKEN WHICH CAUSED A BAD EXHUAST LEAK. REPAIR COST WAS $3500. I DROVE THE TRUCK LESS THAN 50 MILES OVER THE NEXT TWO DAYS AND THE PROBLEM HAPPENED AGAIN WITH LOSS OF POWER AND ENGINE LIGHT ON. I TOOK THE TRUCK BACK THE DEALER AND WAS INFORMED THAT THE HIGH PRESSURE FUEL PUMP HAD EXPLODED AND SENT METAL DEBRIS THROUGH OUT THE FUEL SYSTEM. I WAS THEN TOLD THE REPAIR COST WERE GOING TO $7500 ($6000 FOR PARTS AND $1500 FOR LABOR). THIS IS A BAD FORD ENGINEERING DESIGN PROBLEM AND SHOULD BE PAID FOR BY FORD AS WELL AS A RECALL ON ALL MODELS USING THE SAME HPFP ASSEMBLY.

ENTERED ON 10/04/2016 AT 2:45:07 PM EDT (GMT-0400) BY [email protected]: SENDER NAME: SENDER EMAIL: SUBJECT: FORD F-450 COOLING SYSTEM FAILURE AND ENGINE PROBLEMS COMMENTS: I PURCHASED THIS TRUCK NEW IN 2008 AND DROVE IT CROSS COUNTRY TOWING MY 5TH WHEEL. AT 4,544 MILES THE RADIATOR BLEW APART. (DRIVING HIGHWAY/TOWING) THIS WAS REPLACED UNDER WARRANTY AFTER FIGHTING WITH FORD. AT 6,065 MILES I HAD ANOTHER COOLING SYSTEM LEAK.(DRIVING LOCAL) THEY HAD TO REPLACE THE "SMALL" RADIATOR, THE "FUEL AND TURBO" COOLER. AT 21432 MILES THE POWER STEERING PUMP WENT AND HAD TO BE REPLACED.(DRIVING/TOWING/LOCAL) SHOP STATED THAT "FLUID WAS CONTAMINATED" (THIS TRUCK HAS ONLY BEEN SERVICED BY FORD) AT 22215 MILES I HAD TO HAVE THE LEFT REAR AXLE SEAL, BRAKE PADS AND LOWER CAC HOSE FOR TURBO REPLACED.( DRIVING HIGHWAY/TOWING) NOW AT 29,017 MILES THE RADIATOR TANKS HAVE SEPARATED FROM THE CORE AND NEED TO BE REPLACED AGAIN ALONG WITH THE CRANK SEAL AND ANOTHER POWER STEERING PUMP.( COMBINATION, HIGHWAY/LOCAL/TOWING? NOT TOWING) I HAVE CHECKED WITH FORD AND THEIR CUSTOMER SERVICE DEPARTMENT AND THEY REFUSE TO COVER ANY OF THIS, OR ANY PART, UNDER WARRANTY. I HAVE ALSO DONE RESEARCH ON THESE TRUCKS HAVING FOUND MANY OTHER OWNERS HAVING THE SAME COOLING SYSTEM ISSUES ALONG WITH OTHER ISSUES THAT FORD REFUSED TO COVER. PLEASE LOOK INTO THIS ISSUE, I THINK THEY NEED TO HAVE A RECALL ON THE COOLING SYSTEMS IN THEIR TRUCKS. THANK YOU FOR TAKING THE TIME TO READ THIS. I WOULD APPRECIATE A RESPONSE. CHECK EDMUNDS FORD F-450 SD TURBO DIESEL REVIEW, MULTIPLE COMPLAINTS OF COOLING SYSTEM FAILURE, ENGINE FAILURE. *TR

TL* THE CONTACT OWNS A 2008 FORD F-450. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE BOLT IN THE STEERING COLUMN BECAME DETACHED. THE STEERING WHEEL BECAME INOPERABLE AND AFTER ENGAGING THE BRAKES, THE VEHICLE COASTED TO A STOP. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND DIAGNOSED THAT THE STEERING COLUMN BOLT WAS FRACTURED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

I TRAVEL FOR WORK AND DRIVE MANY DIFFERENT TYPES OF RENTAL CARS. I HAVE HAD THE FOLLOWING OCCUR IN MORE MODELS THAN I CAN REMEMBER. VEHICLE ACCELERATES WHEN YOU APPLY THE BRAKES. ROOT CAUSE: THE ELEVATION / SPACING RELATIONSHIP BETWEEN THE BRAKE PEDAL AND THE ACCELERATOR. OPERATOR ERROR CONTRIBUTES TO THE PROBLEM ALSO. PEOPLE HAVE A TENDENCY TO ROLL THEIR FOOT FROM THE GAS PEDAL TO THE RIGHT HAND SIDE OF THE BRAKE PEDAL. DEPENDING ON THE ANGLE OF THEIR FOOT, THE EDGE OF THEIR SHOE WILL HANG OVER THE GAS PEDAL. WHEN THEY APPLY THE BRAKE THEY ALSO APPLY THE GAS. THE ENGINE TORQUE OVER COMES THE BRAKE FRICTION AND THE CAR ACCELERATES. MOST OF THE TIME WHEN THIS HAPPENS I CAN REMOVE MY FOOT, RELOCATE IT ON THE BRAKE PEDAL AND SAFELY STOP. SEVERAL TIMES MY SITUATION REQUIRED ME TO HOLD THE BRAKE / GAS PEDALS IN POSITION AND QUICKLY USE MY LEFT FOOT TO APPLY THE BRAKE TO PREVENT AN ACCIDENT. WEARING MY HEAVY BOOTS WITH A LARGE SOLE INCREASES THE FREQUENCIES OF THESE INCIDENTS. *TR

DRIVING DOWN THE ROAD AT 65 MPH PULLING A HORSE TRAILER, TRANSFER CASE BLEW UP, BREAKING THE FRONT DRIVE SHAFT, WHICH WIPED OUT THE BRAKE LINES, TRAILER BRAKE LINE AND THE FUEL LIFT PUMP AND LINES. HAD NO POWER OR BRAKES. HAD FORD FIX THE TRUCK, BUT THEY WOULD NOT TAKE ANY RESPONSIBILITY FOR THE FAILURE. THE REASON FOR THE FAILURE WAS NOT FOUND. *TR

I TRAVEL FOR WORK AND DRIVE MANY DIFFERENT TYPES OF RENTAL CARS. I HAVE HAD THE FOLLOWING OCCUR IN MORE MODELS THAN I CAN REMEMBER. VEHICLE ACCELERATES WHEN YOU APPLY THE BRAKES. ROOT CAUSE: THE ELEVATION / SPACING RELATIONSHIP BETWEEN THE BRAKE PEDAL AND THE ACCELERATOR. OPERATOR ERROR CONTRIBUTES TO THE PROBLEM ALSO. PEOPLE HAVE A TENDENCY TO ROLL THEIR FOOT FROM THE GAS PEDAL TO THE RIGHT HAND SIDE OF THE BRAKE PEDAL. DEPENDING ON THE ANGLE OF THEIR FOOT, THE EDGE OF THEIR SHOE WILL HANG OVER THE GAS PEDAL. WHEN THEY APPLY THE BRAKE THEY ALSO APPLY THE GAS. THE ENGINE TORQUE OVER COMES THE BRAKE FRICTION AND THE CAR ACCELERATES. MOST OF THE TIME WHEN THIS HAPPENS I CAN REMOVE MY FOOT, RELOCATE IT ON THE BRAKE PEDAL AND SAFELY STOP. SEVERAL TIMES MY SITUATION REQUIRED ME TO HOLD THE BRAKE / GAS PEDALS IN POSITION AND QUICKLY USE MY LEFT FOOT TO APPLY THE BRAKE TO PREVENT AN ACCIDENT. WEARING MY HEAVY BOOTS WITH A LARGE SOLE INCREASES THE FREQUENCIES OF THESE INCIDENTS. *TR

HAVE HAD ACCELERATION ISSUES WITH THIS FORD F-450 SINCE APRIL OF 2010, THE FIRST TIME THE DRIVER WAS ABLE TO STOP THE VEHICLE WITHOUT INCIDENT BUT THE ENGINE BLEW UP WHEN HE PUT IT IN NEUTRAL TO STOP THE VEHICLE. IT WAS AT THE FORD DEALERSHIP FOR 6 WEEKS, I RETRIEVED THE VEHICLE, WHILE ON THE WAY HOME THE ENGINE FAILED AGAIN, IT WAS TOWED BACK TO THE DEALERSHIP. 1 WEEK LATER I RETRIEVED THE VEHICLE AGAIN, 2 DAYS AFTER THAT THE ACCELERATOR STUCK ONCE AGAIN WHILE HAULING A TRAILER LOADED WITH A RENTAL TRENCHER. THIS TIME THE RESULT WAS A TRAFFIC ACCIDENT THAT SENT ONE OF MY EMPLOYEES TO THE HOSPITAL AND CAUSED MAJOR PROPERTY DAMAGE, THE VEHICLE WAS TOWED BACK TO THE DEALERSHIP AND HAS BEEN THERE EVER SINCE. THEY HAVE REPLACED THE SHORT BLOCK, INJECTORS, AND OTHER VARIOUS ENGINE COMPONENTS. *TR

TL* THE CONTACT OWNS A 2008 FORD F-450 SD. WHILE DRIVING VARIOUS SPEEDS, THE DRIVER AND REAR PASSENGER WINDOWS INDEPENDENTLY ROLLED DOWN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000. THE VIN WAS NOT AVAILABLE.

THE SUNROOF EXPLODED WHILE DRIVING DOWN THE HIGHWAY. A LOUD POP WAS HEARD AND THE GLASS EXPLODED OUT OR UPWARD. SUNROOF WAS CLOSED, AS WAS SHADE THAT COVERS IT. THERE WAS A CAMPER ON THE TRUCK THAT COVERS THE CAB OF THE TRUCK, AND THERE WERE NO MARKS ON THE TRUCK OR CAMPER TO SAY A ROCK HAD SOMEHOW RICOCHETED AND HIT THE SUNROOF. (I DON'T THINK THIS WOULD BE POSSIBLE ANYWAY.) THERE IS PLENTY OF CLEARANCE BETWEEN THE CAMPER AND THE CAB AND IT HAS NEVER IT THE ROOF. THERE IS A ROW OF LIGHTS ACROSS THE CAB THAT SIT HIGHER THAN THE SUNROOF, AND THEY ARE ALL FINE. ALL THIS TO SAY, THE 'EXPLOSION' HAPPENED WITHOUT COMING IN CONTACT WITH ANYTHING, AND THE FACT THAT IT EXPLODED OUT, NOT IN, ALSO WOULD TELL ME IT'S SOME SORT OF DEFECT. FORD WOULD NOT TAKE RESPONSIBILITY FOR IT, AND WILL NOT LOOK INTO IT, SINCE WE ALREADY HAD IT FIXED. I SEE MANY OTHER COMPLAINTS OF THIS HAPPENING, SEVERAL ON FORDS, BUT ALSO OTHER CARS AS WELL. I'M HOPING SOMEONE WILL LOOK INTO THIS. *TR

TRUCK WAS RECALLED TO GIVE WARNING WHEN THE TRUCK GOES INTO REGENERATION. WHEN THE CHECK ENGINE LIGHT WOULD COME ON NOW FORD CURRENT FIX IS FOR THE MESSATO DISPLAY FOR JUST A FEW SECONDS. SO IT CAN BE IN THE REGENERATION MODE AND YOU WILL NOT KNOW IT. BACK TO THE SAME OLD SAFETY AND FIRE HAZARD AS BE FORE THE RECALL.. BEEN AT THE DEALER SEVERAL TIMES TO CORRECT THE PROBLEM. LAST TIME 10/11/10. *TR

INJECTORS TURBO EXHAUST AND ALOT MORE PROBLEMS, BEEN TOWED 6 TIMES BEEN TO THE DEALER OVER 30 TIMES WENT THROUGH LEMON LAW DIDN'T QUALIFY VEHICLE TO HEAVY. *TR

TL* THE CONTACT OWNS A 2008 FORD F-450 SD. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE REAR DRIVER'S SIDE DOOR OPENED INDEPENDENTLY AS THE DOOR AJAR WARNING INDICATOR ILLUMINATED. THE CONTACT MANEUVERED TO THE SIDE OF THE ROAD. HOWEVER, THE DOOR FAILED TO LATCH IN A SECURED POSITION. AFTER NUMEROUS ATTEMPTS, THE DOOR LATCHED PROPERLY. THE FAILURE RECURRED TEN TIMES. IN ADDITION, THE SAME FAILURE OCCURRED WITH THE REAR PASSENGER SIDE DOOR ON A SEPARATE OCCASION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS 2008 FORD F-450 SD. THE CONTACT STATED THAT THE METAL CABLE THAT HOLD THE VEHICLE SPARE TIRE BROKE STRIKING THE HORSES THAT WERE BEING HAULED IN THE REAR TRAILER. THE DEALER WAS NOTIFIED OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE FAILURE WAS NOT COVER UNDER THE WARRANTY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFERED ANY ADDITIONAL ASSISTANCE. THE FAILURE MILEAGE WAS 62,000 AND THE CURRENT MILEAGE WAS 64,000.

CPSC#X1190467A. 2008 FORD F450. CONSUMER STATED WHILE DRIVING THE TRUCK EXPLODED. HE LOST CONTROL OF THE TRUCK AND RAN OFF THE ROAD. THE TRANSFER CASE HAD EXPLODED AND SENT METAL INTO MY TRANSMISSION AND BUSTED IT. *LN THE CONSUMER STATED THE FUEL LINE WAS CUT AND THE WIRING WAS BURNED AS WELL. THE VEHICLE WAS TOWED TO THE DEALER, WHERE THEY INFORMED THE CONSUMER THE EXPLOSION OCCURRED AS A RESULT OF A FACTORY DEFECT. THE CONSUMER SUFFERED MINOR INJURIES. *JB

RIGHT FRONT TIRE THREW ITS TREAD WHILE DRIVING ON THE HIGHWAY. NO WARNING VIBRATIONS OR NOISES PRIOR TO THE INCIDENT. TIRE FAILURE CAUSED THE TRUCK TO VEER HARD RIGHT ACROSS THREE LANES OF HIGHWAY TRAFFIC BUT MANAGED TO AVOID ANY COLLISIONS. TIRE WAS OEM. WE HAVE NOTICED THAT THE FRONT TIRE SIDEWALLS GET TOO HOT TO TOUCH AFTER HIGHWAY TRIPS (THE REAR ONES DO NOT). THE FAILED TIRE STILL HAD 3/4" OF UNUSED TREAD. WE VERIFY PRESSURES BEFORE EACH TRIP (110 PSI FRT) AND HAVE NEVER TAKEN THE TRUCK OFF-ROAD. WE TOW WITH IT BUT IT'S THE SAME RIG WE TOWED WITH A 2004 F350 SD WITH NO PROBLEMS. THE TIRE INFO IS NOT IN THE DROPDOWN MENU BUT THE SIZE IS 225/70R19.5, IT'S A DESIGNATED STEER AXLE TIRE ON AN ALCOA RIM (FORD OE) DOT CODE IS A39Y1XL0607. *GEM UPDATED 03/25/10 *BF RECEIVED PICTURES OF DAMAGED TIRE. UPDATED 09/15/10

VEHICLE LOST COMPLETE POWER WHILE DRIVING ON INTERSTATE AT CRUISING SPEED. THERE WERE ABSOLUTELY NO WARNINGS, THE ENGINE JUST QUIT, DISABLING THE VEHICLE IN HIGH SPEED TRAFFIC. THE DEALER REPAIR WAS TO REPLACE WIRING HARNESS FOR HIGH PRESSURE FUEL PUMP DUE TO WIRES SHORTING THE ENGINE AFTER THE INSULATION WAS CHAFED BY INTERNAL CONTACT WITH OTHER ENGINE PARTS, WHICH WAS A KNOWN ISSUE WITH THIS ENGINE FOR BUILDS PRIOR TO AUGUST 20, 2007, ACCORDING TO A FORD TSB: 07-26-2. THIS PART IS COMPLETELY INTERNAL AND NOT SUBJECT TO INSPECTION UNTIL FAILURE. MY FAMILY AND I WERE EXTREMELY FORTUNATE THAT WE WERE ABLE TO GET SAFELY TO THE SHOULDER OF THE INTERSTATE WITH MANY SEMI'S AND CARS AROUND US WHEN THE FAILURE OCCURRED. ALSO, SINCE ENGINE WOULDN'T START AT ALL, WE WERE SUBJECTED TO EXTREME COLD WEATHER CONDITIONS WHILE WAITING FOR TOW VEHICLE, OVER 2 HOURS. THIS IS A POTENTIAL LIFE-THREATENING DEFECT!! LOSING ALL POWER IN SECONDS WITHOUT WARNING IN HIGH-SPEED TRAFFIC IS UNACCEPTABLE, FORD! *TR

INJECTORS TURBO EXHAUST AND ALOT MORE PROBLEMS, BEEN TOWED 6 TIMES BEEN TO THE DEALER OVER 30 TIMES WENT THROUGH LEMON LAW DIDN'T QUALIFY VEHICLE TO HEAVY. *TR

INJECTORS TURBO EXHAUST AND ALOT MORE PROBLEMS, BEEN TOWED 6 TIMES BEEN TO THE DEALER OVER 30 TIMES WENT THROUGH LEMON LAW DIDN'T QUALIFY VEHICLE TO HEAVY. *TR

NEW FORD F-450, REAR SEAT BELT BOLTS UNINSTALLED AND REAR SEAT BOLTS INSTALLED IMPROPERLY. DETAILS: 4 REAR SEAT BELT BOLTS WERE ONLY INSTALLED BY 1 - 2 THREADS FOR A 1-1/2 BOLT CLEARLY PRESENTING A DANGER TO A CHILD OR ANYONE RIDING IN THE REAR SEAT. ALL REAR SEAT BOLTS SCREWED IN ONLY "FINGER TIGHT", NOT TORQUED PROPERLY. NOTE: FORD WAS NOTIFIED (ANSWERER: ROSE ON WED, 28 NOV @ 0845 HRS) NO RESPONSE AS REQUESTED TO INSURE THAT PROBLEM WAS BEING INVESTIGATED. NOTE: IT WOULD SEEM THAT FORD SHOULD TRY TO DETERMINE IF ANY OTHER UNITS (SOMEWHAT BEFORE AND SOMEWHAT AFTER PRODUCTION ) HAD SIMILAR DANGEROUS PROBLEMS. - CLEARLY, A CHILD IN A SAFETY SEAT ATTACHED TO THE REAR SEAT OF SUCH A DEFECTIVE VEHICLE WOULD BE THROWN FORWARD. (RELATED VEHICLE INFORMATION: MODEL YEAR=2008, MAKE=FORD F-450 CREW, MODEL=F-450 CREW CAB). *TR