2014 Ford F-450 Sd Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2014 Ford F-450 Sd, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine150.0%
- Fuel system150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
THE HIGH PRESSURE FUEL PUMP FAILED. FORD CLAIMED THAT THIS WAS FROM CONTAMINATED FUEL. FORD HAS TWO FUEL FILTERS AND A WATER SEPARATOR. I PERSONALLY ADDED TWO ADDITIONAL FILTERS AND AN ADDITIONAL WATER SEPARATOR, FOR A TOTAL OF FOUR FILTERS AND TWO SEPARATORS. FORD ALSO HAS A WATER IN FUEL LIGHT THAT IS SUPPOSED TO ALERT THE DRIVER TO CONTAMINATION. AT NO TIME DID THIS LIGHT COME ON. IN SHORT, I BELIEVE FORD HAS A DEFECTIVE FUEL PUMP AND A DEFECTIVE FILTRATION AND WATER ALERTING SYSTEM. THIS TRUCK SHUTDOWN, WITH NO WARNING AT 70 MPH ON A LIMITED ACCESS HIGHWAY. FORD REFUSES TO ADDRESS THE PROBLEM AND CONTINUES TO BLAME THE OWNER. THIS IS A SAFETY ISSUE AND I WAS FORTUNATE THAT THERE WAS LIGHT TRAFFIC AND I WAS ABLE TO SAFELY STEER THE POWERLESS TRUCK TO THE SIDE OF THE ROAD. IN RESEARCHING THIS ISSUE, I'VE SEEN THAT THERE ARE NUMEROUS REPORTS OF THE SAME PROBLEM ON THE 6.7 LITER POWERSTROKE DIESEL ENGINE FROM 2011 ON.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
THE HIGH PRESSURE FUEL PUMP FAILED. FORD CLAIMED THAT THIS WAS FROM CONTAMINATED FUEL. FORD HAS TWO FUEL FILTERS AND A WATER SEPARATOR. I PERSONALLY ADDED TWO ADDITIONAL FILTERS AND AN ADDITIONAL WATER SEPARATOR, FOR A TOTAL OF FOUR FILTERS AND TWO SEPARATORS. FORD ALSO HAS A WATER IN FUEL LIGHT THAT IS SUPPOSED TO ALERT THE DRIVER TO CONTAMINATION. AT NO TIME DID THIS LIGHT COME ON. IN SHORT, I BELIEVE FORD HAS A DEFECTIVE FUEL PUMP AND A DEFECTIVE FILTRATION AND WATER ALERTING SYSTEM. THIS TRUCK SHUTDOWN, WITH NO WARNING AT 70 MPH ON A LIMITED ACCESS HIGHWAY. FORD REFUSES TO ADDRESS THE PROBLEM AND CONTINUES TO BLAME THE OWNER. THIS IS A SAFETY ISSUE AND I WAS FORTUNATE THAT THERE WAS LIGHT TRAFFIC AND I WAS ABLE TO SAFELY STEER THE POWERLESS TRUCK TO THE SIDE OF THE ROAD. IN RESEARCHING THIS ISSUE, I'VE SEEN THAT THERE ARE NUMEROUS REPORTS OF THE SAME PROBLEM ON THE 6.7 LITER POWERSTROKE DIESEL ENGINE FROM 2011 ON.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .