2025 Ford F-450 Sd Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2025 Ford F-450 Sd, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Other / unspecified150.0%
- Powertrain (other)150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
There is uneven tread wear and cupping on the Continental Tires installed by Ford. These tires were already replaced once and have the same issue after 7000 miles. The front tire Outer tread is wearing out and other owners are reporting tires ripping apart.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
Less than 4000 miles- first transmission failed while pulling a large trailer- ford replaced the transmission and the new transmission, only 200 miles later did the same thing when pulling a trailer, up hill. It throws the transmission into 10th gear and you loose all power, Check engine light comes on and it slams back into 4th gear. Will not shift in or out of 4th. We were almost in a head on collision pulling a trailer because it did it while passing a semi and we had no power. Two transmissions this low of mileage seems like it must be a batch of faulty transmissions that need to be recalled asap.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .