Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 2020 Ford F-450 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
The contact owns a 2020 Ford F-450. The contact received notification of NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
The contact owns a 2020 Ford F-450 The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Vehicle caught fire. Fire in the engine compartment after heavy fuel smell/odor.
The contact owns a 2020 Ford F-450. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel). The contact stated that while hauling an RV at 65 MPH, with the cruise control feature activated, the message that the "Engine has Stopped - Pull Over Immediately" was displayed, and the vehicle stalled. The vehicle was steered to the side of the road, and the contact attempted to restart the vehicle. The contact stated that the engine was turning over however, the vehicle failed to start. The vehicle was towed to a dealer to be diagnosed, and the dealer retrieved DTC: P0087. Additionally, there were metal shavings found in the fuel system. The contact was informed that the fuel pump and the entire fuel system needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 104,717.
The contact owns a 2020 Ford F-450. The contact stated that after starting the vehicle, the engine ran for several minutes before the vehicle independently shut off. No warning lights were illuminated. The contact attempted to restart the vehicle however, the vehicle failed to start. The vehicle was towed to the residence. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact referenced NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL) as probable cause for the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 184,000.
The contact owns a 2020 Ford F-450. The contact stated that while driving 60 MPH, there was an abnormal knocking sound coming from the vehicle, with the "Reduced Engine Power" message displayed on the instrument panel. The contact pulled over to the shoulder of the highway, and the vehicle shut off. The contact stated that the vehicle failed to restart after several attempts. Due to the failure, the vehicle was towed to a dealer where a diagnostic test was performed, and it was determined that the high-pressure fuel pump had failed. The contact was informed that the entire fuel system needed to be replaced. The contact then received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and informed the contact that the remedy for the recall was a software update. The contact was informed that due to the fuel pump failure, the vehicle was no longer qualified for the recall repair. The dealer referred the contact to the manufacturer who offered to cover 50% of the cost for the repair. The contact stated that the recall repair was not a permanent repair and that the recall remedy failed to adequately address the failure. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 40,000. VIN tool confirms parts not available.
The contact owns a 2020 Ford F-450. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The contact stated that while starting, the "Low Fuel Pressure" message was displayed. The contact stated that while driving at an undisclosed speed, the vehicle lost power. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the fuel filter had exploded and needed to be replaced. The vehicle was then towed to a dealer where it was diagnosed and determined that the fuel system was contaminated with metal and that the entire fuel system needed to be flushed and replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 103,000. VIN tool confirms parts not available.
The contact owns a 2020 Ford F-450. The contact stated that while driving 65 MPH, the vehicle lost motive power. The vehicle was towed to the dealer and diagnosed with metal shards in the fuel system. The dealer informed the contact that the fuel system kit needed to be replaced but parts were on backorder. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and a case was opened. The failure mileage was 33,875.
Kept smelling faint diesel fuel odor would come and go while driving for 11,000 miles, never saw a leak, then became worse and saw drops on driveway size of a dime. Found a steady drip of fuel only while running from fuel filter under hood above valve cover, replaced filter and leak stopped. Closer look found heavy stains from fuel leak on top of engine. Has been that way since new. Leak now fixed. This could be a fire hazard. Glad I found it.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Data on this page last refreshed .