RoadVitals

1991 Ford F-53 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Sep 22, 2014
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1991 Ford F-53, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes2100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

2
reports

From owner reports, verbatim

TL* THE CONTACT OWNS A 1991 FORD WINNEBAGO F-53 CHASSIS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH ATTEMPTING TO ENGAGED THE BRAKES, THE VEHICLE DELAYED TO STOP AND ALMOST RESULTED IN A CRASH. THE VEHICLE WAS TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,542.

NHTSA ID 10638098 · filed Sep 22, 2014

I HAVE A SEVERE BREAK FADING PROBLEM. I HAPPENS AFTER YOU HAVE DESCENDED A STEEP DOWNGRADE AND STOP. AT THAT POINT THE BREAK PEDAL GOES COMPLETELY TO THE FLOOR. AFTER A RESTING PERIOD THE PEDAL COMES BACK AGAIN. FORD HAS TOLD ME THE ONLY WAY TO CORRECT THE PROBLEM WITH MY 1991 M53, 50,000 MILES, IS TO DO A $2,500.00 TO $3,000.00 OVERHAUL OF THE BREAK SYSTEM USING PHONELIC PARTS. I FEEL IF AN EXTENSIVE OVERHAUL IS REQUIRED AT THIS POINT, IT WAS A SYSTEM DESIGNED TO FAIL. A SYSTEM DEFECT. THIS PROBLEM COULD HAVE COST THE LIFE OF MY WIFE AND TWO OF MY GRANDCHILDREN AND MYSELF. I HAVE BEEN RESTRICTED TO DRIVING ON FLATLAND EVER SINCE THIS INSTANCE ABOUT 2 YEARS AGO. I HAVE ATTEMPTED TO GET AN ANSWER OR A CORRECTION BUT NO ONE SEEMS TO HAVE ONE EXCEPT $2,500- $3,000. I FEEL FORD HAS A RESPONSIBILITY HERE AND SHOULD PAY ALL OR A SUBSTANTIAL PART OF THE CORRECTION OF THEIR DESIGN ERROR. *NLM

NHTSA ID 10016465 · filed Apr 24, 2003

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .