RoadVitals

1996 Ford F-53 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Jul 28, 2015
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1996 Ford F-53, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes150.0%
  • Fuel system150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

1
report

From owner reports, verbatim

TL* THE CONTACT OWNS A 1996 FORD F-53. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 65 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOOR UPON DEPRESSING AND THE VEHICLE FAILED TO SLOW DOWN UNTIL THE EMERGENCY BRAKE WAS ENGAGED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THE FRONT BRAKE CALIPERS WERE REPLACED. THE CONTACT MENTIONED THAT TWO YEARS AFTER THE REPAIR WAS PERFORMED, THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED FOR THE MOST RECENT FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 09/17/15*LJ UPDATED 12/13/2017*CN

NHTSA ID 10744397 · filed Jul 28, 2015

Too few reports in this category for a page of its own — they appear in the full complaint list.

Fuel system

Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.

1
report

From owner reports, verbatim

WHIRRING NOISE FROM FUEL PUMP AS DESCRIBED IN FORD TECHNICAL BULLETIN AND LOSS OF SENDING UNIT SIGNAL TO FUEL GAUGE. PARTS DEPT AND SERVISOR FOR LOCAL FORD DEALER ADMIT SEVERAL UNITS REPLACED USING SPECIFIED FIELD REVISION PARTS SEPARATING FUEL PUMP AND SENDING UNIT USING NEW DESIGN JUMPER HARNESS. NOT COVERED BY ANY KNOWN RECALL. COST TO UNFORTUNATE CONSUMER, $371.80 FOR PARTS PLUS $75.00 PER HOUR WITH NO TIME ESTIMATE. ANY MALFUNCTION IN THE FULE TANK AND DELIVERY SYSTEM ALONG WITH THE GAUGING SYSTEM POWERED BY ELECTRICITY IS A MAJOR SAFETY PROBLEM AS I SEE IT AS A FORMER OSHA ASSOCIATE (WITH MY FORMER EMPLOYER, BEFORE RETIREMENT).*AK

NHTSA ID 763945 · filed Jul 8, 2002

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .