2018 Ford F-53 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2018 Ford F-53, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure535.7%
- Electrical214.3%
- Driver assistance17.1%
- Other / unspecified17.1%
- Powertrain (other)17.1%
- Seat belts17.1%
- Steering17.1%
- Suspension17.1%
- Brakes17.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
The contact owns a 2019 Thor Motor coach Windsport built on a 2018 Ford F-53 Chassis. The contact stated that while she was cleaning the RV, she noticed that the metal screws that maintained the overhead unit of the driving compartment attached to the ceiling were pulling out. However, the brackets installed on each side of the overhead unit prevented it from falling. An independent RV mechanic diagnosed that the failure was due to metal screws being installed on the wooden surface. The independent mechanic informed the contact that brackets needed to be installed to maintain the overhead unit into position. The RV was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure but did not provide any assistance. The failure mileage was approximately 9,000.
The contact owns a 2019 Jayco Alante manufactured on a 2015 Ford F53 chassis. The contact stated while driving 28 mph, the front grill detached from the RV inadvertently. The contact took the RV to the local dealer, where it was diagnosed with needing the grill to be replaced however, the dealer did not provide the service at their location. The dealer referred the contact to a body shop for the repair. The RV was not yet repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 7,376.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2018 FORD F53. THE CONTACT STATED WHILE THE VEHICLE WAS STATIONARY, THE ROOF STARTED TO LEAK CAUSING WATER TO GET INSIDE OF THE VEHICLE. THE CONTACT ALSO STATED THAT THE INVERTER UNIT SHORTED OUT AND CAUGHT ON FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER. THE FIRE OR POLICE DEPARTMENT WAS NOT NOTIFIED. THE CONTACT STATED THAT THE FLOOR HEATING UNITS AND WOULD OCCASIONALLY OVERHEAT BURNING THE CONTACTS FEET. THE CONTACT SUSTAINED A SORE FOOT BUT NO MEDICAL ATTENTION WAS REQUIRED. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR AN INDEPENDENT MECHANIC TO HAVE IT DIAGNOSED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE AND INFORMED THE CONTACT THAT THEY WOULD NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.
TL* THE CONTACT OWNS A 2018 FORD F-53 RV. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE BACK-UP CAMERA DETACHED AND BECAME INOPERABLE. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO APPLETON CAMPING CENTER (2100 N MCCARTHY RD, APPLETON, WI 54913, (920) 757-6112) TO BE DIAGNOSED. THE CONTACT WAS INFORMED OF A LOOSENED ELECTRICAL WIRE. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED OR NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 3,000.*DT*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2018 FORD F-53 RV. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE BACK-UP CAMERA DETACHED AND BECAME INOPERABLE. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO APPLETON CAMPING CENTER (2100 N MCCARTHY RD, APPLETON, WI 54913, (920) 757-6112) TO BE DIAGNOSED. THE CONTACT WAS INFORMED OF A LOOSENED ELECTRICAL WIRE. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED OR NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 3,000.*DT*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
VEHICLE SOLD AS NEW TO ME BY GIANT RV WITH A 15 YEAR OLD TIRE INSTALLED ON THE FRONT DRIVER SIDE. THIS WAS A MISMATCH, OFF BRAND "EXPIRED" TIRE THAT CAUSED A BLOW OUT REQUIRING REPAIRS AND CREATING AN OPPORTUNITY OF RISK. THIS WAS NOT DISCLOSED AND THE DEALER REFUSES TO TAKE OWNERSHIP OF THE ISSUE OR PROVIDER NECESSARY BACKGROUND AS TO THE CAUSE OF WHY THIS TIRE WAS IMPROPERLY REPLACED. CONCERN BEING THAT THERE MAY HAVE BEEN A NON DISCLOSED VEHICLE EVENT (ACCIDENT ETC.) THAT CAUSED DAMAGES WHICH WERE IMPROPERLY AND UNSAFELY REPAIRED WITHOUT PROPER DISCLOSURE. CONCERN BEING THAT THERE MAY BE OTHER HIDDEN ISSUES WHICH MAY CONTINUE TO PUT MY FAMILY AT RISK. WHEN ASKED THE DEALER AND MANUFACTURER (THOR) PLACE BLAME WITH FORD AS THE CHASSIS MANUFACTURER. I DO NOT BELIEVE FORD MOTOR COMPANY STORES AND INSTALLS 15 YEAR OLD TIRES ON BRAND NEW CHASSIS. I BELIEVE THERE WAS AN EVENT WHEN THE VEHICLE WAS BEING TRANSPORTED BY GIANT RV FROM THOR'S MANUFACTURING CENTER TO THEIR DEALERSHIP IN CALIFORNIA. I BELIEVE THEY REPLACED THE TIRE FOR THE LOWEST COST AS POSSIBLE WITH INFERIOR AND UNSAFE MATERIAL - PUTTING ME AND MY FAMILY AS WELL AS MY VEHICLE AT RISK. I FEEL IT IS REASONABLE AND AND I FEEL A RESPONSIBLE DEALER WOULD DO ALL THEY COULD TO DETERMINE WHERE AND HOW THIS HAPPENED. IF THIS IS THEIR BUSINESS PRACTICE THERE ARE OTHER VEHICLES AND CONSUMERS AT RISK. THE TIRE BLEW OUT WHILE IN A TYPICAL TRAVEL SITUATION, AFTER RECENTLY BEING SERVICED BY THE DEALER (GIANT RV) FOR UNRELATED WARRANTY ISSUES. TIRE BLEW OUT ON 2/24/19 DURING REGULAR TRAVEL. (FEWER THAN 4,000 ORIGINAL MILES ON THE COACH). THE FAILURE WAS DUE TO A FRONT DRIVER SIDE MISMATCHED TIRE THAT HAD A DOT DATE OF 2005 AND FAILED DUE TO AGE. THE UNSAFE TIRE WAS IDENTIFIED AS BEING A 2005 DATED DOT TIRE BY BOTH HIGHWAY PATROL AND A TIRE AGENCY WHICH DID THE ROADSIDE REPAIR FOR ME. THE TIRE WAS PROVIDED TO GIANT RV SERVICE DEPARTMENT WHERE THEY TOO AGREED THAT THIS WAS AN UNSAFE ("EXPIRED") TIRE. ULTIMATELY THOR AGREED TO REIMBURSE ME FOR THE TIRE. *DT *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
TRANSMISSION FAILED AT 54000 MILES DUE TO INTERNAL DEFECTIVE PART. THE VEHICLE STARTED TO JUMP ON SHIFTING FROM 1 ST GEAR TO 2 ND .
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
THE FRONT PASSENGER SHOULDER HARNESS IN MY RV IS MOUNTED SO HIGH THAT THE BELT GOES ACROSS MY WIFE'S THROAT INSTEAD OF HER CHEST. WHY IS THERE NO SAFETY STANDARD WHICH REQUIRES A SHOULDER HARNESS MOUNT TO BE ADJUSTABLE VERTICALLY TO KEEP SHORT PEOPLE SAFE?*DT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2018 JAYCO 31Z. WHILE DRIVING 65 MPH, THE STEERING WAS UNSTABLE AND UNCONTROLLABLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (ALBANY RV, 48 RENSSELAER AVE, LATHAM, NY 12110, (518) 459-4695), BUT WAS NOT DIAGNOSED OR REPAIRED. ALBANY RV REFERRED THE CONTACT TO ANOTHER UNKNOWN LOCAL DEALER. THE MANUFACTURER WAS NOTIFIED AND REFERRED THE CONTACT TO THE DEALER. THE FAILURE MILEAGE WAS 781.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
TRANSMISSION FAILED AT 54000 MILES DUE TO INTERNAL DEFECTIVE PART. THE VEHICLE STARTED TO JUMP ON SHIFTING FROM 1 ST GEAR TO 2 ND .
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2018 FORD F-53. WHEN THE EMERGENCY BRAKE WAS RELEASED, THE EMERGENCY BRAKE CHIME CONTINUED TO BE AUDIBLE AND COULD NOT BE DEACTIVATED. THE EMERGENCY BRAKE WARNING INDICATOR ALSO ILLUMINATED. THE CONTACT MENTIONED THAT THE BRAKE ASSEMBLY WAS REPLACED TWICE PRIOR TO THIS FAILURE. THE DEALER WAS NOT CONTACTED FOR THE EMERGENCY BRAKE CHIME FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND RECOMMENDED THAT THE CONTACT CALL THE DEALER THAT SERVICED THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 3,000. *TT *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .