Owner-reported complaints naming the engine system, filed with NHTSA
Data refreshed
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components. Every record below is an owner-reported complaint about the 1999 Ford F-550 Sd submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 10 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
DT: THE CONTACT STATED WHILE DRIVING THE VEHICLE MISFIRED. THE MECHANIC DETERMINED THAT THE SPARK PLUG WIRES WERE CROSSED, WHICH SEND THE SPARK TO THE WRONG AREA. THIS WAS CAUSING AIR POLLUTION. THE WIRES NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. *AK UPDATED 1/5/2006 - *NM
WHILE DRIVING, THE TRANSMISSION STOP SHIFTING GEARS. THE VEHICLE WAS TOWED TO A DEALERSHIP AND THE TRANSMISSION WAS REPLACED. THE VEHICLE ALSO HAD MAJOR OIL LEAKS THROUGH THE FUEL SYSTEM. *JB
AS THE CONSUMER ATTEMPTED TO STOP THE VEHICLE, THE PEDAL WENT TO THE FLOOR AND STAYED. THE MASTER CYLINDER AND SLAVE CYLINDER HAD EXCESS WERE ON THE PRESSURE PLATE FINGERS. THE TRANSMISSION WAS HARD TO SHIFT INTO REVERSE AND LOW GEAR. THE HARD CLUTCH MADE NOISE. THE CLUTCH COMPANY WAS WELL AWARE OF FORD'S PROBLEM AND HAD RE-ENGINEERED AND DESIGNED A NEW PACKAGE TO REMEDY THE PROBLEM. THERE WAS FUEL LEAKING AT THE FUEL FILTER, THE SWAY BAR WAS BROKEN, THE DOOR AJAR LIGHT STAYED ON, ENGINE OIL LEAK, AND THE GAS CAP WAS BROKEN. *AK *SC *JB
WE PURCHASED OUR F550 FROM FACT. ON 2/7/99, IN DEC 1999 THE 4 SPEED AUTO TRANSMISSION WENT OUT WITH 9470 MILES ON THE VEHICLE. THREE WEEKS BEFORE REPLACING WITH A REMANUFACTURED TRANSMISSION, WE WERE TOLD THAT THE REMANUFACTURED ARE BETTER AS THEY ARE COMPLETLY GONE THROUGH; APPARENTLY THE NEW ONES ARE NOT. ALSO HAD TO REPAIR A MAJOR OIL LEAK BY REPLACING SEVERAL HOSES, O RINGS AND THE RIGHT CYLINDER HEAD HIGH PRESSURE OIL LINE AND FITTING. MAY 4 OF 2000 REPAIR TO THE SWITCHES IN THE DOOR LATCH ALONG WITH MISC INSIDE ELEC REPAIRS. JULY 24, 2001 ENGINE OVERHEATING, DEALER REPLACED GASKETS, THERMOSTATS AND OTHER RELATED ITEMS, SERVICE DOCUMENT INDICATED RECALL WORK DONE BUT NO EXPLAINATION AS TO WHAT. SEPTEMBER 2, 2003 TRUCK FIRE, BURNS AN EMPLOYEE ATTEMPTING TO EXTINGUISH. TRUCK TOWED TO DEALER, WIRE HARNESS ON BOTH SIDES REPLACED, FIRE WAS ON DRIVER SIDE THE PASSENGER SIDE WAS READY TO BURN ALSO. RECEIVED TRUCK BACK, 6 HOURS LATER TRANSMISSION GOES OUT WHILE DRIVING ON FREEWAY. TOWED BACK TO DEALER AND FORDS RESPONSE IS, WE PAY $2000.00 TOWARDS A REMANUFACTURED TRANSMISSION AND THEY WOULD IN TURN PICK UP THE REST OF THE COSTS AND EXTEND OUR POWER STROKE DIESEL ENGINE WARRENTY FOR 4 MORE YEARS, NY PROBLEM IS THE TRANSMISSION NEW IN 1999 ONLY COST $995.00 LET ALONE THE FACT THAT THIS TRANSMISSION ONLY HAS 28,000 MILES ON IT, AM I PAYING FOR THE DEFECTIVE WIRING ALSO? I THINK FORD IS YANKING OUR CHAIN AND YOUR CHAIN AND IT NEEDS TO STOP NOW. WE IMPOWER YOU TO HELP US THE CONSUMER AND TAX PAYERS FIGHT THIS KIND OF CONSUMER ABSUE AND I HOPE IT DOES NOT HAVE TO RESULT TO THE LOSS OF TOO MANY MORE LIVES BEFORE IT IS STOPPED. IT IS SO OBVIOUS THAT THERE ARE SOME SERIOUS DEFECTS WITH THIS VEHICLE SERIES AND I AM CURIOUS AS TO WHEN IT WILL BE ADDRESSED.*AK
WHEN ANY TYPE OF DUST CAME INTO CONTACT WITH THE ENGINE, THE ENGINE WOULD IMPLODE AND IT CAUSED THE CONSUMER TO LOSE CONTROL OF THE VEHICLE. *JB
WHILE DRIVING THE "HOT PIPE" TO THE TURBO-CHARGER BLEW OFF OF ITS COUPLING CAUSING LOSS OF POWER, THE DEALERSHIP INDICATED THAT THIS IS A COMMON PROBLEM AND INSTALLED A NEW DESIGNED PIPE THAT WAS REDESIGNED DUE TO THE COMMON FAILURE, CONSUMER IS REQUESTING REIMBURSEMENT DUE TO THE FAULTY PART. *MJS
HEARD A CLUNKING NOISE, AND HAD VEHICLE SERVICED FOR UNIVERSAL JOINTS. TWO WEEKS LATER, WHILE DRIVING ON HIGHWAY WENT TO APPLY BRAKES AND ALL OF A SUDDEN THERE WAS SMOKE EVERYWHERE, TIRES CAUGHT ON FIRE, AND BRAKES FAILED. INSIDE BRAKES SPUN AROUND TO CALIPER AND FROZE. *AK
WATER PUMP GOES OUT EVERY 18000 MILES OR TWO MONTHS AT COST $250.00 WITH 12K WARRENTY BY FORD. FORD CAN NOT REMEDY EXHAUST LEAKS AFTER 4 TIMES. *AK
CLUTCH BURNS OUT PREMATURALLY. THE CLUTCH HAS BEEN REPLACED THREE TIMES PRIOR TO THIS FAILURE. LEFT HIGH PRESSURE FUEL LINE HOLE RUBBED FROM ENGINE BLOCK/ WATER PUMP FAILURE. *AK
VEHICLE IS CONSUMING EXCESSIVE AMOUNTS OF OIL WITHIN SHORT PERIODS. CAUSE UNKNOWN. DEALER CANNOT IDENTIFY PROBLEM. *AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .