2010 Ford F-550 Sd Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2010 Ford F-550 Sd, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine150.0%
- Powertrain (other)150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
This concerns the International 6.4 Liter Diesel engine used in 2008-2010 Ford Super Duty Trucks. It is common knowledge in the industry that these are "bad" engines however there has been no recall as of date. In my situation, while under warranty, and carrying a load (5,000 lbs), the vehicle when into "limp mode" during an extended trip. After the load was emptied I took the vehicle to the dealer and they found nothing wrong with. Now at 25,000 miles, and out warranty timewise, the turbo(s) blew, evidencing that the truck had weak turbos from the factory. When referenced these occurrences, Ford still will not honor their warranty even though my initial complaint was timely and validly made. Ford misdiagnosed or didn't have the proper equipment to investigate my initial complaint. In any event, considering the widespread knowledge of this particular engine's defects, the entire 6.4 Fleet should be recalled as these engines have been being replaced and repaired on a massive scale.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
This concerns the International 6.4 Liter Diesel engine used in 2008-2010 Ford Super Duty Trucks. It is common knowledge in the industry that these are "bad" engines however there has been no recall as of date. In my situation, while under warranty, and carrying a load (5,000 lbs), the vehicle when into "limp mode" during an extended trip. After the load was emptied I took the vehicle to the dealer and they found nothing wrong with. Now at 25,000 miles, and out warranty timewise, the turbo(s) blew, evidencing that the truck had weak turbos from the factory. When referenced these occurrences, Ford still will not honor their warranty even though my initial complaint was timely and validly made. Ford misdiagnosed or didn't have the proper equipment to investigate my initial complaint. In any event, considering the widespread knowledge of this particular engine's defects, the entire 6.4 Fleet should be recalled as these engines have been being replaced and repaired on a massive scale.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .