2022 Ford F-550 Sd Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2022 Ford F-550 Sd, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical323.1%
- Suspension323.1%
- Engine215.4%
- Driver assistance17.7%
- Body & structure17.7%
- Fuel system17.7%
- Steering17.7%
- Brakes17.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
Truck has approximate 60,000 miles. Was driving in rain and lost control of all electrical systems and died in the middle of the highway. No lights to warn other drivers. Shop said the pcm fried and will need a need pcm to fix the issue. Very dangerous
Went to shut vehicle off and it just kept running. No power inside the cab but the engine was still running and it could run and drive although zero inside electrical. Key was in off position. Very potentially deadly situation.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
Ford Motor Company has had a known issue with the truck frames cracking on the F-550 chassis. They acknowledged it by doing a recall, which either replaced or repaired the chassis frame or installed reinforcement braces if no cracks were visible. The recall expired in September of 2023. In October 2023 we noticed a crack on the frame just outside the recall reinforcement brace that Ford-certified technicians installed. We found another in November (reinforcement brace installed) and another in January (with Ford's new and improved frame produced due to a recall issue). Ford has denied making the repairs since the original warranty expired, even though this was the same related issue. We have been dealing with Ford Motor Company since October in hopes of resolving the issue but they continue to give us any resolution. The problem has not only caused a burden on our workforce but also caused great safety concerns. With Ford avoiding responsibility, they are allowing trucks to operate daily on our highway system, which becomes a safety concern for not only the driver but for many other motorists. The problem existed, but the issue was not resolved, all we are asking is that they take responsibility for making the repairs and permanently resolving the issue for the safety of all motorists.
at speeds starting 40 mph the Ford 550 tends to sway and require steering changes. This is a fire truck Chassie and when weighed on certified scales it is in the required specification range. The Ford dealer says not their problem. The builder of the fire body keeps asking for more information on tires and weighing the truck.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
Went to shut vehicle off and it just kept running. No power inside the cab but the engine was still running and it could run and drive although zero inside electrical. Key was in off position. Very potentially deadly situation.
The contact owned a 2022 Ford F-550. The contact stated that while driving 20 MPH, the vehicle started smoking and flames came from the left side of the engine. The vehicle inadvertently veered to the right of the road. In addition, the contact noticed smoke and flames were coming from the front passenger’s side and the rear of the vehicle. As a result, of the fire the contact sustained smoke inhalation that required medical attention. The Fire Department extinguished the fire. The contact was unaware of a Police report being filed. The vehicle was destroyed. The manufacturer was not made aware of the failure. The approximate failure mileage was 20,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
Truck has approximate 60,000 miles. Was driving in rain and lost control of all electrical systems and died in the middle of the highway. No lights to warn other drivers. Shop said the pcm fried and will need a need pcm to fix the issue. Very dangerous
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
Ford Motor Company has had a known issue with the truck frames cracking on the F-550 chassis. They acknowledged it by doing a recall, which either replaced or repaired the chassis frame or installed reinforcement braces if no cracks were visible. The recall expired in September of 2023. In October 2023 we noticed a crack on the frame just outside the recall reinforcement brace that Ford-certified technicians installed. We found another in November (reinforcement brace installed) and another in January (with Ford's new and improved frame produced due to a recall issue). Ford has denied making the repairs since the original warranty expired, even though this was the same related issue. We have been dealing with Ford Motor Company since October in hopes of resolving the issue but they continue to give us any resolution. The problem has not only caused a burden on our workforce but also caused great safety concerns. With Ford avoiding responsibility, they are allowing trucks to operate daily on our highway system, which becomes a safety concern for not only the driver but for many other motorists. The problem existed, but the issue was not resolved, all we are asking is that they take responsibility for making the repairs and permanently resolving the issue for the safety of all motorists.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
The contact owns a 2022 Ford F-550 SD. The contact stated that while driving on the highway at 60 MPH, the vehicle experienced a loss of automotive power, with the check engine warning light illuminated. The contact proceeded to pull over onto the side of the highway to safely park the vehicle. The contact attempted to restart the vehicle however, the vehicle failed to restart. The vehicle was towed to a local independent mechanic to be diagnosed. The contact was informed that the fuel pump was faulty and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 150,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
I was driving about 57 mph headed NW on I270 in the north Denver metro area. I went over a bridge abutment and the vehicle started shaking violently in the front end. I let off the gas but the extreme vibration/shaking continued until I slowed down to around 20 mph. I thought I had lost something in the front end. Then it happened again when I was driving between I70 and US 50 in western Colorado. I was only going 30 miles an hour and hit a rotomilled section of asphalt(a perfect edge drop to the rotomilled pavement) and the violent shaking started but ended much quicker as I slowed down to about 10 mph. First incident was 8/12/23 and second incident was 8/21/23
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
I receive notice about recall 22s17. Brought to Ford service in Woodbine, NJ. After my truck was reprogramed the truck doesn't intially connect to the trailer. If I turn off ignition and turn back on the truck doesn't realize it is connected to the trailer. I must idle the truck get out of my truck unplug then plug the trailer connector back into the 7 pin plug for the truck to recognize the trailer for the trailer brakes to work. This truck is my only work truck and I need a solution quickly.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .