2002 Ford F-650 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 Ford F-650, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes225.0%
- Exterior lighting225.0%
- Transmission225.0%
- Electrical112.5%
- Powertrain (other)112.5%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
WHEN IT RAINS OUT IT MAY START ON ITS OWN TURN LIGHTS ON SITTING IN THE DRIVEWAY IN THE MIDDLE OF THE NIGHT WAS THE FIRST TIME IT ALWAYS STARTS WHILE SITTING TOLD THERE WAS A PROBLEM WITH WATER GETTING IN GEM MODUEL.
THE HYDRAULIC UNIT SLAVE CYLINDER WHEN PUSHING INTO THE CLUTCH DISENGAGED, WHICH CAUSED THE VEHICLE TO ACCELERATE SIMULTANEOUSLY. *AK FLUID LEAKED OUT OF THE MASTER CYLINDER AND WAS REMOVED AND REPLACED. *SCC ALSO THE TAIL LIGHT WAS REPLACED *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
WHEN IT RAINS OUT IT MAY START ON ITS OWN TURN LIGHTS ON SITTING IN THE DRIVEWAY IN THE MIDDLE OF THE NIGHT WAS THE FIRST TIME IT ALWAYS STARTS WHILE SITTING TOLD THERE WAS A PROBLEM WITH WATER GETTING IN GEM MODUEL.
THE HYDRAULIC UNIT SLAVE CYLINDER WHEN PUSHING INTO THE CLUTCH DISENGAGED, WHICH CAUSED THE VEHICLE TO ACCELERATE SIMULTANEOUSLY. *AK FLUID LEAKED OUT OF THE MASTER CYLINDER AND WAS REMOVED AND REPLACED. *SCC ALSO THE TAIL LIGHT WAS REPLACED *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
THE HYDRAULIC UNIT SLAVE CYLINDER WHEN PUSHING INTO THE CLUTCH DISENGAGED, WHICH CAUSED THE VEHICLE TO ACCELERATE SIMULTANEOUSLY. *AK FLUID LEAKED OUT OF THE MASTER CYLINDER AND WAS REMOVED AND REPLACED. *SCC ALSO THE TAIL LIGHT WAS REPLACED *JB
CLUTCH PEDAL STUCK AT FLOOR. @ 3,548 MILES ON TRUCK. INSTALLED DRIVE LINE AND ORDERED CLUTCH PEDAL SPRING (108T REPLACED CLUTCH MASTER ASSM AND RECALL SPG. ADJ. CLUTCH). 33,071 MILES NOTE ON OIL CHANGE INVOICE CLUTCH RETURN SPRING AT TRANS BROKE NEED REPAIR ASAP ALSO U-JOINT CLIP OFF NEED REPAIR, RELEASED BY RON MCMILLON. CLUTCH PEDAL STUCK TO FLOOR AT 43,954 AND TOLD NOT UNDER WARRANTY, CLUTCH SHIELDS WORN.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
WHEN IT RAINS OUT IT MAY START ON ITS OWN TURN LIGHTS ON SITTING IN THE DRIVEWAY IN THE MIDDLE OF THE NIGHT WAS THE FIRST TIME IT ALWAYS STARTS WHILE SITTING TOLD THERE WAS A PROBLEM WITH WATER GETTING IN GEM MODUEL.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
CLUTCH PEDAL STUCK AT FLOOR. @ 3,548 MILES ON TRUCK. INSTALLED DRIVE LINE AND ORDERED CLUTCH PEDAL SPRING (108T REPLACED CLUTCH MASTER ASSM AND RECALL SPG. ADJ. CLUTCH). 33,071 MILES NOTE ON OIL CHANGE INVOICE CLUTCH RETURN SPRING AT TRANS BROKE NEED REPAIR ASAP ALSO U-JOINT CLIP OFF NEED REPAIR, RELEASED BY RON MCMILLON. CLUTCH PEDAL STUCK TO FLOOR AT 43,954 AND TOLD NOT UNDER WARRANTY, CLUTCH SHIELDS WORN.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .