2002 Ford F Series (light) Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 Ford F Series (light), grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine1058.8%
- Fuel system211.8%
- Brakes15.9%
- Electrical15.9%
- Body & structure15.9%
- Powertrain (other)15.9%
- Suspension15.9%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
WE PURCHASED A CAR FROM NAB AUTOS IN FREDERICKSBURG, VA. AFTER THE 7TH DAY OF DRIVING IT, THE MOTOR BLEW UP. WRONG SPARK PLUGS WERE INSTALLED BY DEALER. ALSO THE TRUCK HAD BEEN RACED WITH NITROUS WHICH WE WERE UNAWARE OF UNTIL WE TRIED TO FIND OUT WHAT HAPPENED TO MOTOR. I HAVE DOCUMENTATION FROM THE REPAIR SHOP. MY 18 YEAR OLD SON DRIVES THIS VEHICLE WHICH BEGAN LOSING POWER AND SHAKING BEFORE HE WAS ABLE TO PULL OFF TO THE SIDE OF THE HIGHWAY.
SPARK PLUG FAILURE AS ACCELERATING FROM A STOP LIGHT, AND ENGINE PROBLEM RESULTING FROM 7 CYLINDER OPERATION. GOT IT TO A MECHANIC AND HE WAS ABLE TO SLEEVE THE SPARK PLUG THREAD AND INSTALL A NEW PLUG. NOW THE SAME IS STARTING AGAIN. I AM TAKING THE VEHICLE TO THE MECHANIC TO MAKE PERMANENT REPAIRS FOR ALL THE SPARK PLUG. THIS MAY END UP WITH THE ENGINE HEADS BEING REMOVED IN ORDER TO MAKE COMPLETE REPAIRS, AND THE COST FOR THAT WILL BE THOUSANDS OF DOLLARS. THIS IS A FORD ENGINE DESIGN PROBLEM THAT FORD HAS BEEN AWARE OF, YET THEY CONTINUE TO DENY ANY RESPONSIBILITY. *TR
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
A SPARK PLUG WORKED LOOSE FROM THE HEAD AND BLEW OUT CAUSING DAMAGE TO THE HEAD AND THE IGNITION COIL. ALL 8 PLUGS HAD TO BE REPLACED, TWO DAMAGED SPARK PLUG HOLES REPAIRED AND TWO IGNITION COILS REPLACED. *TR
GAS TANK LEAK AT STRAP HOLDING TANK IN PLACE. 2002 FORD F-150 4X4 4.6 LITER. AT THIS TIME I CAN NOT FILL THE VEHICLES TANK TO FULL. THE PROBLEM WILL ONLY GET WORSE WITH TIME. AT THIS TIME THE VEHICLE IS ONLY FILLED TO 1/2 FULL. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
CROSS FRAME MEMBER WHICH CONTAINS THE TRANSMISSION MOUNT WAS EXTREMELY RUSTED OUT AND CRACKED. STATE SAFETY INSPECTION REP INDICATED IT WOULD NOT PASS INSPECTION IN THE NEAR FUTURE. FORD NO LONGER MANUFACTURES THE FRAME MEMBER. I WAS LUCKY AFTER A LONG SEARCH TO FIND A DEALER WHICH STILL HAD THE PART AVAILABLE. PART # IS: XL3Z6A023CA. THE VEHICLE HAS BEEN OPERATED IN WARWICK NY SINCE NEW AND IN NORTHEASTERN PA SINCE 2007. I BELIEVE IF THE FRAME MEMBER WOULD FAIL THE TRANSMISSION WOULD DROP DOWN. I HAVE PHOTOS OF THE RUSTED UNIT. IF YOU CARE TO SEE THEM PLEASE SEND AN E-MAIL ADDRESS AND I'LL ATTACH THEM TO A E-MAIL. SOMETHING MUST BE DONE TO REQUIRE MANUFACTURES TO USE BETTER MATERIAL FOR PICKUP TRUCK FRAMES AND BRAKE LINES. I HAVE ALSO REPORTED PROBLEMS WITH BRAKE LINES ON THIS TRUCK RUSTING OUT. ONE INCIDENT, I REPORTED, OCCURRED AFTER BACKING UP A RV IN A CAMPSITE AFTER JUST DRIVING OVER 150 MILES ON THE INTERSTATE HIGHWAY. PROVIDENCE PROTECTED ME AS I COULD HAVE LOST THE BRAKES WHILE TRAVELING ON THE INTERSTATE! *JS .
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
SPARK PLUG BLEW OUT OF PLUG HOLE, STRIPPING THREADS OF INTAKE CYLINDER HEAD. PLUG WAS FOUND LAYING BETWEEN VALVE COVER AND INTAKE MANIFOLD. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
CROSS FRAME MEMBER WHICH CONTAINS THE TRANSMISSION MOUNT WAS EXTREMELY RUSTED OUT AND CRACKED. STATE SAFETY INSPECTION REP INDICATED IT WOULD NOT PASS INSPECTION IN THE NEAR FUTURE. FORD NO LONGER MANUFACTURES THE FRAME MEMBER. I WAS LUCKY AFTER A LONG SEARCH TO FIND A DEALER WHICH STILL HAD THE PART AVAILABLE. PART # IS: XL3Z6A023CA. THE VEHICLE HAS BEEN OPERATED IN WARWICK NY SINCE NEW AND IN NORTHEASTERN PA SINCE 2007. I BELIEVE IF THE FRAME MEMBER WOULD FAIL THE TRANSMISSION WOULD DROP DOWN. I HAVE PHOTOS OF THE RUSTED UNIT. IF YOU CARE TO SEE THEM PLEASE SEND AN E-MAIL ADDRESS AND I'LL ATTACH THEM TO A E-MAIL. SOMETHING MUST BE DONE TO REQUIRE MANUFACTURES TO USE BETTER MATERIAL FOR PICKUP TRUCK FRAMES AND BRAKE LINES. I HAVE ALSO REPORTED PROBLEMS WITH BRAKE LINES ON THIS TRUCK RUSTING OUT. ONE INCIDENT, I REPORTED, OCCURRED AFTER BACKING UP A RV IN A CAMPSITE AFTER JUST DRIVING OVER 150 MILES ON THE INTERSTATE HIGHWAY. PROVIDENCE PROTECTED ME AS I COULD HAVE LOST THE BRAKES WHILE TRAVELING ON THE INTERSTATE! *JS .
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
CROSS FRAME MEMBER WHICH CONTAINS THE TRANSMISSION MOUNT WAS EXTREMELY RUSTED OUT AND CRACKED. STATE SAFETY INSPECTION REP INDICATED IT WOULD NOT PASS INSPECTION IN THE NEAR FUTURE. FORD NO LONGER MANUFACTURES THE FRAME MEMBER. I WAS LUCKY AFTER A LONG SEARCH TO FIND A DEALER WHICH STILL HAD THE PART AVAILABLE. PART # IS: XL3Z6A023CA. THE VEHICLE HAS BEEN OPERATED IN WARWICK NY SINCE NEW AND IN NORTHEASTERN PA SINCE 2007. I BELIEVE IF THE FRAME MEMBER WOULD FAIL THE TRANSMISSION WOULD DROP DOWN. I HAVE PHOTOS OF THE RUSTED UNIT. IF YOU CARE TO SEE THEM PLEASE SEND AN E-MAIL ADDRESS AND I'LL ATTACH THEM TO A E-MAIL. SOMETHING MUST BE DONE TO REQUIRE MANUFACTURES TO USE BETTER MATERIAL FOR PICKUP TRUCK FRAMES AND BRAKE LINES. I HAVE ALSO REPORTED PROBLEMS WITH BRAKE LINES ON THIS TRUCK RUSTING OUT. ONE INCIDENT, I REPORTED, OCCURRED AFTER BACKING UP A RV IN A CAMPSITE AFTER JUST DRIVING OVER 150 MILES ON THE INTERSTATE HIGHWAY. PROVIDENCE PROTECTED ME AS I COULD HAVE LOST THE BRAKES WHILE TRAVELING ON THE INTERSTATE! *JS .
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
REAR WHEELS HAVE ENOUGH PLAY IN THEM THAT THERE IS A NOTICEABLE CLUNK WHEN TURNING. TOOK THE TRUCK TO THE DEALER AND THE END PLAY OF THE AXLES ARE .020. FORD MANUFACTURER SAID UP TO .030 IS TOLERABLE AND I WILL HAVE TO LIVE WITH THE CLUNKING SOUND. I DID NOT PAY $30,000 FOR A TRUCK TO LISTEN TO A CLUNKING SOUND!
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .