2007 Ford F Series Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2007 Ford F Series, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine240.0%
- Fuel system120.0%
- Powertrain (other)120.0%
- Visibility120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
WHILE DRIVING IN A PARKING LOT THE VEHICLE SHUT OFF COMPLETELY WITHOUT WARNING CAUSING LOSE TO ALL POWER SYSTEMS. THE VEHICLE WOULD NOT START, DEALER STATED THAT THE FUEL PUMP DRIVER CONTROL MODULE IS THE CAUSE OF THIS. THEY FURTHER STATED IT IS A COMMON ISSUE AND SHOULD HAVE A RECALL OR SOME THING FOR THE NORTHERN STATES. ALSO REPLACED WAS THE FUEL RAIL PRESSURE SENSOR(P0191 CODE). STILL NO RESOLVE TO ISSUE. *TR
TWICE NOW, MANUFACTURER INSTALLED SPARK PLUGS HAVE BEEN EJECTED FROM THE ENGINE. BOTH FROM THE PASSENGER SIDE CYLINDER HEAD. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
WHILE DRIVING IN A PARKING LOT THE VEHICLE SHUT OFF COMPLETELY WITHOUT WARNING CAUSING LOSE TO ALL POWER SYSTEMS. THE VEHICLE WOULD NOT START, DEALER STATED THAT THE FUEL PUMP DRIVER CONTROL MODULE IS THE CAUSE OF THIS. THEY FURTHER STATED IT IS A COMMON ISSUE AND SHOULD HAVE A RECALL OR SOME THING FOR THE NORTHERN STATES. ALSO REPLACED WAS THE FUEL RAIL PRESSURE SENSOR(P0191 CODE). STILL NO RESOLVE TO ISSUE. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
VEHICLE WAS PURCHASED USED FROM LOCAL FORD DEALER 10 MONTHS PRIOR (75,000 MILES), AND WAS A DEALER MAINTAINED VEHICLE. I DROVE VEHICLE 3,000 MILES SINCE PURCHASE. WHILE DRIVING AT 20 MPH, I EXPERIENCED SUDDEN AND SEVERE VIBRATION MAKING THE VEHICLE DIFFICULT TO CONTROL. I WAS ABLE TO PULL VEHICLE TO SIDE OF ROAD BUT COULD NOT MOVE VEHICLE > 1 MPH WITHOUT SEVERE VIBRATION. PROBLEM WAS FROM COMPLETE FAILURE OF DRIVE SHAFT CENTER SUPPORT BEARING. THERE WERE NO PREVIOUS INDICATIONS OF IMPENDING FAILURE. THE FAILURE WAS SUDDEN, UNEXPECTED AND COMPLETE. I HAVE SAFETY CONCERNS ABOUT VEHICLE CONTROLLABILITY SHOULD A BEARING FAILURE OCCUR AT HIGHWAY SPEED. IN ADDITION THE BEARING IS LOCATED IN CLOSE PROXIMITY TO THE FUEL TANK. SHATTERED BEARING PARTS COULD POTENTIALLY PENETRATE THE FUEL TANK. THE BEARING IS A NON-SERVICEABLE PART AND THE ENTIRE DRIVESHAFT MUST BE PURCHASED AT A COST OF $1,000, MAKING BEARING CHANGE PRIOR TO FAILURE HIGHLY UNLIKELY. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
DRIVER'S SIDE WINDOW IS BROKEN FROM THE TRACK ASSEMBLY. I BELIEVE THIS COULD POSE DANGEROUSLY IN THE EVENT OF AN ACCIDENT, WINDOW COULD BE BECOME AN PROJECTILE AND DISLODGE WHERE NO ONE WILL BE ABLE TO EXIT OUT OF THE VEHICLE. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .