1997 Ford F Super Duty Chassis Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1997 Ford F Super Duty Chassis, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes240.0%
- Driver assistance120.0%
- Powertrain (other)120.0%
- Tires & wheels120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
DT: 1997 FORD SUPER DUTY CHASSE CLASS C MOTOR HOME. ALL FOUR BACK TIRES HAVE BLOWN OUT. THE FIRST HAPPENED 2 YEARS, AND IN THE PAST TWO YEARS ALL FOUR BLEW OUT. SPOKE TO THE MANUFACTURER AND THERE WERENO RECALLS. NO ONE KNOWS WHY THESE TIRES HAVE BLOWN OUT. THE CONSUMER WAS DRIVING UNDER NORMAL DRIVING CONDITIONS ON THE INTERSTATE AT 65 MPH. THERE WERE NO CRASHES OR INJURIES BECAUSE OF THE BLOW OUTS. HOWEVER , HAD TO REPLACE THE BACK BRAKES, ROTORS AND THE REAR SEALS ON THE AXLES. *AK
WHILE TRAVELING SOUTH ON US RTE 220 ON A CLEAR DRY FALL DAY, I APPLIED THE BRAKES LIGHTLY IN PREPARATION FOR A TRAFFIC LIGHT CONTROLLED INTERSECTION. THE BRAKE PEDAL WENT RIGHT TO THE FLOOR, PROVIDING NO STOPPING ACTION. I PUMPED THE PEDAL AND BUILT UP SOME PEDAL PRESSURE AND FELT SOME BRAKING ACTION ALTHOUGH NOT NEARLY ENOUGH. I DOWN SHIFTED THE TRANSMISSION AND CONTINUED TO HOLD PRESSURE ON THE BRAKE PEDAL. THE TIRES WERE SQUEALING BUT WE WER0E NOT SLOWING DOWN AS QUICKLY AS WE SHOULD HAVE BEEN. AS IT TURNS OUT THE FRONT WHEELS AND THE TAG AXLE WHEELS WERE THE ONLY ONES DOING ANY BRAKING. THE REAR DUAL AXLE HAD NO BRAKING DUE TO THE BRAKE LINE AT THE RIGHT REAR DUAL WHEELS HAD RUBBED THROUGH WHILE WE WERE TRAVELING. IT WAS RUBBING ON THE AIR SUSPENSION AIR BAG. WE VERY NARROWLY ESCAPED SERIOUS INJURY. WE STOPPED ABOUT 8FT BEHIND THE SEMI TRAILER THAT WE'D BEEN FOLLOWING. THANKFULLY, WE HAD BEEN STAYING FARTHER BEHIND THAN NORMAL AND KNEW WE HAD TO STOP OR AT LEAST SLOW DOWN TO TURN AT THE INTERSECTION AHEAD. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
1997 FORD F-SUPER DUTY WITH A SPEED SENSOR ISSUE. CUSTOMER STATED THAT HE RECEIVED A RECALL FOR THE SPEED SENSOR FAILURE. CUSTOMER SAW THAT HIS VEHICLE COULD CATCH FIRE. CUSTOMER WAS TOLD THE PARTS WOULD NOT BE READY UNTIL THE END OF THE YEAR. *KB THE CONSUMER STATED HIS PRIVATE MECHANIC TOOK CARE OF THE PROBLEM. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
DT: 1997 FORD SUPER DUTY CHASSE CLASS C MOTOR HOME. ALL FOUR BACK TIRES HAVE BLOWN OUT. THE FIRST HAPPENED 2 YEARS, AND IN THE PAST TWO YEARS ALL FOUR BLEW OUT. SPOKE TO THE MANUFACTURER AND THERE WERENO RECALLS. NO ONE KNOWS WHY THESE TIRES HAVE BLOWN OUT. THE CONSUMER WAS DRIVING UNDER NORMAL DRIVING CONDITIONS ON THE INTERSTATE AT 65 MPH. THERE WERE NO CRASHES OR INJURIES BECAUSE OF THE BLOW OUTS. HOWEVER , HAD TO REPLACE THE BACK BRAKES, ROTORS AND THE REAR SEALS ON THE AXLES. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
DT: 1997 FORD SUPER DUTY CHASSE CLASS C MOTOR HOME. ALL FOUR BACK TIRES HAVE BLOWN OUT. THE FIRST HAPPENED 2 YEARS, AND IN THE PAST TWO YEARS ALL FOUR BLEW OUT. SPOKE TO THE MANUFACTURER AND THERE WERENO RECALLS. NO ONE KNOWS WHY THESE TIRES HAVE BLOWN OUT. THE CONSUMER WAS DRIVING UNDER NORMAL DRIVING CONDITIONS ON THE INTERSTATE AT 65 MPH. THERE WERE NO CRASHES OR INJURIES BECAUSE OF THE BLOW OUTS. HOWEVER , HAD TO REPLACE THE BACK BRAKES, ROTORS AND THE REAR SEALS ON THE AXLES. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .