1996 Ford F Super Duty Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1996 Ford F Super Duty, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Driver assistance330.0%
- Engine220.0%
- Fuel system220.0%
- Electrical110.0%
- Suspension110.0%
- Transmission110.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
SPEED CONTROL DEACTIVATION SWITCH FAILURE THAT RESULTED IN AN ENGINE COMPARTMENT FIRE WHILE THE VEHICLE WAS BEING DRIVEN. THIS VEHICLE IS EQUIPPED WITH A DIESEL ENGINE AND HAS NOT BEEN INCLUDED IN THE RECALL TO DATE. *TR
TL*THE CONTACT OWNS A 1996 FORD F SUPER DUTY. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V336000 (VEHICLE SPEED CONTROL) AND FORD RECALL NUMBER 05S28 IN AUGUST OF 2007. HE CALLED FORD SEVERAL TIMES AND THEY STATED THAT THE PARTS WOULD BE AVAILABLE IN MID'DECEMBER OF 2007 AND THEN IN JANUARY OF 2008. THE DEACTIVATION SWITCH WAS DISCONNECTED. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 25,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
THE PASSENGER'S SIDE EXHAUST MANIFOLD ON MY 1997 MOTORHOME HAS WARPED, WHICH SUBSEQUENTLY CAUSED A BOLT HOLDING THE MANIFOLD IN PLACE TO BREAK OFF. THE FORD DEALER NOW REPAIRING THE VEHICLE SAID THAT FORD HAS HAD MANY PROBLEMS WITH EXHASUT MANIFOLDS ON THE 460 CID ENGINE IN MOTORHOMES...WHY NO RECALL, WHY NO ACTION ON THIS? THE RESULTING EXHAUST LEAK CLEARLY POSED A DANGER TO MY FAMILY AS WE TRAVELED IN OUR MOTORHOME. *AK
RECALL # 97V20900/FORD/EXHAUST GAS LEAK, OWNER NOT ABLE TO MAKE CONTACT WITH MANUFACTURER TO CORRECT RECALL. THE 800 NUMBER LISTED ON THE NOTICE IS CONSTANTLY BUSY. OWNER HAS BEEN TRYING TO REACH MANUFACTURER FOR A TOTAL OF 3 DAYS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
WE WERE TRAVELING FROM LIVINGSTON TEXAS BEFORE LEAVING LIVINGSTON WE GASED OUR MOTOR HOME UP AND WE BEGIN TO SMELL GAS WE TRAVELED TO SAN ANTONIO TEXAS AND NOTICED WHEN WE FILLED THE TANK THAT WE COULD SMELL GAS LOOKING AROUND THE MOTOR HOME WE SAW NOTHING SO WE TRAVELED ON TO EL PASO TEXAS. UPON ARRIVING IN EL PASO WE DECIDED TO FILL UP AND THEN PARK FOR THE EVENING. WHEN I BEGIN TO FILL THE TANK GAS STARTED SPILLING OUT. WE WERE INFORMED TO TAKE THE VEHICLE TO SHAMALAY FORD ON LE TREVINO DRIVE IN EL PASO WHEN WE TOOK IT TO A FORD DEALER THEY LOOKED AND DISCOVERED THAT THE PUMP WAS BROKEN AND THAT THREE SCREWS WERE MISSING FROM THE TANK IN FACT THE TANK WAS BARELEY HOLDING ON. IT SHOWED THAT THE SCREWS WERE SEVERED AND THE GAS TANK HAD COME LOOSE. WHEN WE WERE DRIVING WE HAD HEARD A NOISE THAT SOUNDED AS IF SOMETHING WAS FALLING INSIDE OF THE MOTOR HOME. THE FORD SUPER DUTY E SERIES HAS A WINNEBEGO MOTOR HOME BUILT ON IT. WE HAD JUST FILLED OUR PROPANE TANKS AND IF WE WOULD HAVE DRIVEN ANY FURTHER THER MAY HAVE BEEN A TERRIBLE ACCIDENT. THE DEALER TOLD US THAT FORD WOULD NOT PAY FOR THIS BECAUSE IT IS NOT LISTED AS A COMPLAINT ON RECALL.*AK
FAILURE OF THE FUEL PUMP, FUEL FILTER AND SENDING UNIT CAUSED THE MOTOR HOME TO STALL OVER AND OVER AGAIN. YH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
FAILURE OF THE FUEL PUMP, FUEL FILTER AND SENDING UNIT CAUSED THE MOTOR HOME TO STALL OVER AND OVER AGAIN. YH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
REAR LEAF SPRINGS FAILED. QCAW
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
WHILE DRIVING TRANSMISSION QUIT RUNNING, UNABLE TO ACCELERATE. DEALERSHIP REPLACED THE TRANSMISSION, BUT THE PROBLEM RECURRED.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .