Fuel system
Filed May 16, 2025
I have this car since 2019 with 8000 miles and this is the 3rd time the code came up for the evap system to be repaired. P0456. The first time it was replaced was at mileage 47084 at winner Ford dealership. On June 11th 2021. The second time it was replaced was at Winter Ford dealership on March 17th 2022 with mileage 59,678. The light just came on today and the code came up again. PO456. I now have 102,000 mi on my car. I think that this should be a recall worth looking into. Thank you
- NHTSA ID
- 11661557
- Incident
- May 16, 2025
EngineFuel system
Filed Mar 18, 2025
The contact owns a 2017 Ford Fiesta. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with a purge valve solenoid. The contact was informed that the purge valve solenoid was stuck in the open position. The vehicle was repaired, but the failure reoccurred. The contact stated that the failure had occurred three times within four years. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 71,000.
- NHTSA ID
- 11649114
- Incident
- May 4, 2021
- Mileage
- 71,000 mi
Fuel system
Filed Feb 25, 2025
The contact owns a 2017 Ford Fiesta. The contact stated that after refueling, the vehicle failed to restart. The vehicle was jumpstarted. The check engine warning light was illuminated. The contact stated that the failure persisted after refueling. The contact stated that a bystander assisted with restarting the vehicle, by depressing the accelerator pedal. The contact stated that the canister purge valve had previously been replaced, but the failure recurred. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and referred the contact to the dealer. The failure mileage was approximately 44,000.
- NHTSA ID
- 11644795
- Incident
- Feb 14, 2025
- Mileage
- 44,000 mi
Fuel systemTransmission
Filed Oct 16, 2023
The contact owns a 2017 Ford Fiesta. The contact state that while driving at an undisclosed speed, the vehicle hesitated. A message displayed on the instrument panel “Transmission Failure - Service Now”. The vehicle was towed to the dealer where it was diagnosed that the clutch failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact stated that each time after the vehicle was refueled, while driving at undisclosed speeds, the vehicle hesitated. The check engine warning light illuminated. The vehicle was taken back to the dealer where it was diagnosed that the TCM failed, and the clutch needed to be replaced. The vehicle was repaired. The vehicle was taken to the dealer where it was diagnosed that the purge valve failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and the contact was provided a case number and advised to contact the NHTSA Hotline. The failure mileage was approximately 50,000.
- NHTSA ID
- 11550223
- Incident
- Oct 1, 2023
- Mileage
- 50,000 mi
Fuel system
Filed Dec 14, 2021
The contact stated there was a warning indicator of PO456 and P1450. The contact stated there was an abnormal winding sound detected. Additionally, while driving the vehicle hesitated. The vehicle was taken to the local dealer to be diagnosed and fixed but in 4 months again the problem showed in the car. The contact was informed that the canister purge valve needed to be replaced.
- NHTSA ID
- 11443825
- Incident
- Nov 28, 2021
Fuel system
Filed Oct 18, 2021
The contact owns a 2017 Ford Fiesta. The contact stated the vehicle lost motive power and stalled. The contact stated there was a warning indicator of PO456. The contact stated there was an abnormal winding sound detected. Additionally, while driving the vehicle hesitated. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the canister purge valve needed to be replaced. The vehicle was not repaired. The manufacturer was not notified. The contact mentioned another recall involving another year, make, and model and indicated the failure was like NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The approximate failure mileage was 60,000.
- NHTSA ID
- 11437125
- Incident
- Sep 1, 2021
- Mileage
- 60,000 mi
Fuel system
Filed Apr 1, 2021
FUEL PURGE VALVE LEAKING. FORD PART NUMBER D2B19C987AB FOR WHOLE ASSEMBLY OR B33TB BOSCH FOR SPECIFIC VALVE. FORD DENIES THIS IS RELATED TO EMISSIONS THEREFOR NOT COVERED UNDER THE EXTENDED WARRANTY FOR EMISSIONS PARTS. EVERYBODY IS CALLING IT AN EMISSIONS DEVICE THAT CONTROLS FUMES FROM GAS TANK. MANY OTHER OWNERS HAVE SAME PROBLEM, IT'S VERY COMMON. CODE P1450 AND P0456. CAUSES CAR TO NOT TURN ON AFTER FILLING UP GAS TANK. FOR SOME IT HAS STALLED THE CAR WHILE DRIVING AND UNABLE TO START CAR. THIS PART SHOULD BE REPLACED UNDER WARRANTY. 2017 FIESTA, 50K MILES. EASY WAY TO TEST IS PULL THE TUBE FROM BETWEEN THE ENGINE AND FIREWALL AND IF VACUUM IS PRESENT IT'S LEAKING. DOES NOT REQUIRE TOOLS TO DISCONNECT. THERE IS A GREEN TAB ON THE TUBE THAT YOU USE FINGERS TO PUSH. AGAIN NO TOOLS REQUIRED AND TAKES 10 SECONDS TO DO. PURGE VALVE IS SUPPOSE TO BE SHUT OFF BY DEFAULT. IF AIR IS MOVING THROUGH, YOU HAVE A LEAKING VALVE. IF YOU REMOVE THE WHOLE ASSEMBLY AND BLOW ON THE END, IT NEEDS TO NOT COME OUT FROM OTHER END.
- NHTSA ID
- 11405975
- Incident
- Mar 10, 2021
- Mileage
- 50,000 mi
EngineFuel system
Filed Mar 3, 2021
CAR WANTS TO STALL AFTER GETTING FUEL
- NHTSA ID
- 11398989
- Incident
- Jan 20, 2021
- Mileage
- 56,000 mi
Driver assistanceEngineFuel system
Filed Jan 26, 2021
I WAS IN AN ACCIDENT IN 2019 A FEW MONTHS AFTER PURCHASING CAR SINCE THEN MY ENGINE LIGHT WAS ON. HAD IT SERVICED AND THE ENGINE LIGHT WAS STILL ON. WAS TOLD IT COULD BE A TRANSMISSION PROBLEM. EVERY NOW AND THEN IT WOULD SHUTTLE ONCE STARTED. TODAY IT DIDN'T WANT TO EXCELLERATE WHILE DRIVING
- NHTSA ID
- 11390009
- Incident
- Jan 26, 2021
Fuel systemPowertrain (other)
Filed Jul 7, 2020
NOT SURE IF IT'S THE FUEL SYSTEM OR THE POWER TRAIN BUT I AM HAVING THE SAME PROBLEM AS LOTS OF OTHER PEOPLE WITH THIS CAR! THE CHECK ENGINE LIGHT IS ON AND HAS READ A CODE FOR A VALVE. MY CAR IS A 2017 AND WILL NOT START RIGHT AWAY AFTER I ADD GAS! I'VE BEEN TOLD ITS THE ENGINE VALVE AND HAVE HAD NO LUCK FINDING ANYONE TO COVER IT UNDER WARRANTY! FORD NEEDS TO RECALL THIS VEHICLE!
- NHTSA ID
- 11337832
- Incident
- Jun 30, 2020
- Mileage
- 70,000 mi
Fuel system
Filed Apr 30, 2020
ENGINE LIGHT CONTINUES TO COME ON. AFTER ADDING GAS TO VECHICLE, ℂ𝕒𝕣 WILL STALL. SOMETIMES TAKES SEVERAL MINUTES TO START. WAS TOLD BY SEVERAL MECHANICS IT'S THE FUEL SYSTEM BC THERE IS NO CAP, ONLY THE FLAP THAT DOESN'T CLOSE PROPERLY. CAR HAS STALLED WHILE DRIVING SEVERAL TIMES. ONLY 58,300 MILES ON VECHICLE. I'VE SEEN MANY COMPLAINTS ON THIS PARTICULAR ISSUE WITH THIS MODEL. IT IS A SAFETY ISSUE WHEN CAR STALLS ON HIGHWAY OR WHILE DRIVING. THIS HAS HAPPENED SEVERAL TIMES! CAR ALWAYS HAS ISSUES STARTING AFTER ADDING GASOLINE.
- NHTSA ID
- 11322787
- Incident
- Apr 29, 2020
- Mileage
- 58,300 mi
ElectricalFuel systemPowertrain (other)
Filed Feb 15, 2020
THE CAR EVAP PURGE VALVE STAYS OPEN. THE CAR IDLES AND DIES EVERYTIME I PUT GAS IN. THE PURGE VALVE WAS REPLACED LESS THAN A YEAR OF PURCHASING THE CAR AND IT'S GONE BAD AGAIN. THE CHECK ENGINE LIGHT AND ENGINE MALFUNCTION WARNING CAME ON THEN TWO DAYS LATER THE CAR DIED AFTER I ADDED GAS AND TOOK 2 HOURS TO START. I BOUGHT A NEW BATTERY AND DROVE IT ANOTHER WEEK. IT STILL IDLES AFTER ADDING FUEL EVEN WITH THE NEW BATTERY. IT FINALLY DIED AND I HAD IT TOWED TO THE FORD DEALER AND THEY DID A DIAGNOSTIC AND SAID THE CATALYTIC CONVERTER, THROTTLE BODY AND EVAO PURGE VALVE, O2 SENSOR IS BAD AND ALL 3 NEEDS REPLACING.
- NHTSA ID
- 11309426
- Incident
- Feb 6, 2020
- Mileage
- 96,000 mi
Fuel system
Filed Feb 1, 2020
EVERY TIME I GET GAS, MY CAR WILL NOT START FOR ABOUT 15 MINUTES.
- NHTSA ID
- 11306490
- Incident
- Jan 31, 2020
- Mileage
- 45,000 mi
Fuel system
Filed Jan 13, 2020
TL* THE CONTACT OWNS A 2017 FORD FIESTA. THE CONTACT STATED THAT AFTER FILLING THE VEHICLE WITH GASOLINE, THE VEHICLE WOULD NOT START WITHOUT WARNING. THE CONTACT STATED THAT THE ENGINE WARNING LIGHT HAD REMAINED ILLUMINATED ON THE VEHICLE PRIOR TO EXPERIENCING THE FAILURE. THE CONTACT TOOK THE VEHICLE TO VETERANS FORD LOCATED AT 7201 W LINEBAUGH AVE, TAMPA, FL 33625 WHERE SHE WAS INFORMED THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 19V515000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE AND REFERRED HER TO NHTSA. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 61,800.
- NHTSA ID
- 11298986
- Incident
- Jan 2, 2020
- Mileage
- 61,800 mi
Fuel system
Filed Dec 6, 2019
PURGE VALVE LEAKING, HAS CAUSED CAR TO STALL IN IDLE AT INTERSECTION. READ IN FORUMS IT IS A COMMON ISSUE IN FOCUS AND FIESTA MODELS.
- NHTSA ID
- 11287475
- Incident
- Dec 4, 2019
- Mileage
- 56,000 mi
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.