Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 2006 Ford Focus submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 17 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
DRIVING DOWN THE ROAD AND GAS PEDDLE GET STUCK AND SOMETIMES WONT PUSH DOWN TO GO SOMETIMES WHILE ON THE HIGHWAY THE HEADLIGHTS AND ALL LIGHTS FLICKER ALL THE TIME WHEN I HAVE THEM ON AT NIGHT GOTTIN PULLED OVER A COUPLE OF TIMES TOOKIN IT TOO THE SHOP AND THEY SAID EVERYTHINGS OK ON HIGHWAY 36 BETWEEN BROOKFIELD AND CHILLICOTHE MO
TL* THE CONTACT OWNS A 2006 FORD FOCUS. THE CONTACT STATED THAT WHEN THEY ATTEMPT TO FILL THE FUEL TANK, THE FUEL WOULD BEGIN TO LEAK FROM THE VEHICLE. THE CONTACT STATED THE FUEL WOULD LEAK OUT OF THE SAME OPENING THEY WERE ATTEMPTING TO PUT THE FUEL INTO AS IF THE FUEL WAS SPEWING BACK AT THEM. THE CONTACT CONTACTED THE DEALER (MULLINAX FORD OF PALM BEACH LOCATED AT 1210 NORTHLAKE BLVD, LAKE PARK, FL 33403; PHONE NUMBER 888-856-1675) WHO INFORMED THE CONTACT THAT THEIR VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06E056000 (FUEL SYSTEM, GASOLINE). THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 128,156.
WHILE DRIVING, THE VEHICLE BEGAN TO ACCELERATE ON IT'S OWN. WHEN BRAKES WERE APPLIED THE RPMS SKY ROCKETED. TURNS OUT IT WAS A BROKEN CRUISE CONTROL MODULE CABLE THAT WOULD CAUSE THE THROTTLE TO GET "STUCK". AT THE SAME TIME IT WAS ALSO BOGGING OUT AND SHUTTING ITSELF OFF WHILE DRIVING. THE CHECK ENGINE LIGHT REMAINED ON THROWING A P071? CODE WHICH IS ASSOCIATED WITH O2 LEVELS.THIS TURNED OUT TO BE A BROKEN "BREATHER HOSE" WHICH IS CONNECTED TO THE AIR INTAKE. BOTH PARTS HAVE PROVEN TO BE EXTREMELY DIFFICULT TO TRACK DOWN. AFTER REPLACING THE "BREATHER HOSE", CCM THROTTLE CABLE, AND ALSO AN O2 SENSOR THE OVERALL COST FOR PARTS WAS $300 AND LABOR WAS $300. THANKFULLY NO INJURIES.
HELLO NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION, I WOULD LIKE TO CREATE A VEHICLE COMPLAINT REGARDING THE FORD FOCUS 2006 SEDAN ZX4 THAT I PURCHASED THE VEHICLE SEPTEMBER 20, 2017. WHILE DRIVING WITHIN A SERVICE ROAD, THE VEHICLE'S STALLED AND STOPPED RUNNING WHILE DRIVING UPON MULTIPLE INSTANCES OVER THE SAME DAY OF PURCHASING AND THROUGH OUT THE WEEKEND OF SEPTEMBER 22 - SEPTEMBER 30TH. AS A RESULT, I RETURNED THE VEHICLE TO THE DEALER OF LANSING POWER MOTORS INC. FOR AN INSPECTION SEPTEMBER 23, 2017. UPON COMPLETION OF THE INSPECTION, THE MECHANICS CONFIRMED THAT "NOTHING WAS WRONG WITH THE VEHICLE" AND SUGGESTED TO PURCHASE A NEW COMPUTER FOR THE VEHICLE. ON OCTOBER 30, 2017 I WAS INVOLVED IN A CAR ACCIDENT WHICH I THINK WAS DUE TO BAD ELECTRICAL BRAKES WHICH RESULTED IN THE VEHICLE BEING T-BONED BY ANOTHER DRIVER WITHIN A RESIDENTIAL INTERSECTION. THE VEHICLE CONTINUES TO STALL OR STOP COMPLETELY WHILE DRIVING AS OF MAY 14, 2018. IN ADDITION, NOTICED THAT ALL LIGHTS ON THE DASHBOARD DISPLAYED WHILE THE CAR STALLED AND DURING START-UP OF THE VEHICLE. UNCERTAIN ABOUT THE CAR NOT BEING RECALLED, DUE TO RECEIVING A MAILED NOTIFICATION REGARDING THE RECALL OF THE VEHICLE FROM THE ORIGINAL MANUFACTURER. CAN PROVIDE THE NAME UPON CONTACT REGARDING THE VEHICLE COMPLIANT SUBMISSION OF THE FORM. THANKS FOR YOUR TIME, CONSIDERATION, AND I HOPE THAT THIS INFORMATION MAY ASSIST YOU REGARDING THE CREATION OF A VEHICLE COMPLAINT.
HAVE PROBLEM WITH GAS PEDAL STICKING SINCE VEHICLE WAS 2 YEARS OLD, HAD FORD DEALERSHIP FIX IT UNDER WARRANTY WHICH THEY CLEANED STICKING THROTTLE BODY. UNIT STICKING AGAIN AFTER A FEW MONTHS AND FORD REPLACED IT WITH NEW ONE WHICH I PAID OVER 500 DOLLARS OUT OF POCKET AFTER WARRANTY WAS UP. AFTER A YEAR THROTTLE BODY STICKING AGAIN WHICH CAUSES HIGH IDLE PROBLEM UNTIL VEHICLE COMES TO A STOP THEN IDLE TURNS TO NORMAL RPM'S.
WHEN IT IS UNDER 32 DEGREES. GAS PEDAL FREEZES UP WHEN TRYING A ACCELERATE FROM A STOPPED POSITION. I WHEN TRYING TO CORRECT CAUSES SUDDEN ACCELERATION. *TR
GAS PEDAL STARTED STICKING IRREGULARLY AT AROUND 30,000 MILES, EVEN AT LOW SPEEDS. WAS VERY SPORADIC. MOST RECENT EVENT HAPPENED 12/5/2014 WHEN GAS PEDAL WAS FROZEN COMPLETELY WHILE TRAVELING AT 70 MPH. IT WOULDN'T BUDGE. THEN I PUT MY FOOT ON THE LOWEST EDGE OF THE PEDAL AND IT STARTED WORKING AGAIN. IF YOU GOOGLE "FORD FOCUS GAS PEDAL STICKS", THERE ARE NUMEROUS COMPLAINTS. THE THROTTLE BODY IS THE APPARENT CAUSE. FORD SHOULD RECALL THESE VEHICLES DUE TO THE NUMBER OF COMPLAINTS ONLINE. *TR
DRIVING DOWN THE STREET AND VEHICLE JUST STOPPED RUNNING/DIED. IT HAS BEEN AT THE DEALER FOR ALMOST TWO WEEKS AND THEY HAVEN'T FIGURED IT OUT YET. NO CALL, SAME RUN AROUND WHEN I CALL ABOUT UPDATE.... *TR
MY 2006 FORD FOCUS HAD A GAS PEDAL STICKING ON TWO OCCASIONS. THE DEALER EVENTUALLY FIGURED OUT THE THROTTLE CABLE FROM THE CRUISE CONTROL HAD KINKED. THE RESULT IS A PEDAL THAT COMPLETELY STOPS AND FREEZES. IT FEELS LIKE IT IS A LEAD WEIGHT. THE CAR TEMPORARILY HAS NO ACCELERATION. IN A CONGESTED TRAFFIC AREA THIS IS AN EXTREMELY DANGEROUS SITUATION. IT MOST LIKELY ONLY HAPPENS AT HIGH SPEEDS, BECAUSE OF WHERE THE KINK IS. THIS HAPPENED WITH NO WARNING. THERE APPEARS TO BE SIMILAR EVENTS HAPPENING TO OTHER OWNERS. THE DEALER DID NOT OFFER TO FIX THE CABLE (POST WARRANTEE), BUT DID DISCONNECT IT, AFTER I PAID $100 DIAGNOSES. THE PROBLEM HAS NOT RE-OCCURRED YET. *TR
VEHICLE GAS PEDDLE STICK WIDE OPEN ABOUT 6000 RPM COLD OUT SIDE WITH SNOW, 10 DEGREES F. YOUNG GIRL 2 YEARS OF DRIVING EXPERIENCE DROVE OUT OF CONTROL UNTIL TOLD TO SHUT ENGINE OFF AND PUT IN NEUTRAL. DROPPED OFF AT CERTIFIED MECHANIC HE CLEANED CARBURETOR TRIED TO LOOK AT CONTROL CABLE THINGS CHECKED OUT FINE. NO WARNING CODES CAME UP. DROVE HE NEXT DAY AFTER PICKING UP 10 DEGREES F, SAME ISSUE STICKING ACCELERATOR. I LOOK AGAIN AT IN TAKE CLEANED IT OUT AGAIN, ISSUE HAPPENED AGAIN BUT NOT AS BAD. VERY DANGEROUS FOR A YOUNG GIRL WITH 2 YEARS DRIVING EXPERIENCE. *TR
I HAVE A 2006 FORD FOCUS ZX4 5 SPEED. I HAVE HAD TO REPLACE THE CLUTCH MASTER CYLINDER 3 TIMES WITHIN A YEARS TIME. THE PROBLEM IS THE PART IS PLASTIC AND OVER TIME IT STARTS TO LEAK DUE TO THE PRESSURE IT TAKES TO CHANGE GEARS. I'M IN RUSH HOUR TRAFFIC DAILY AND HAVING TO STOP AND START. THE MASTER CYLINDER SHARES FLUID FROM THE BRAKE RESERVOIR. I HAVE HAD LOW TO NON EXISTENT BRAKING POWER. THE MASTER CLUTCH HAS LEAKED INSIDE MY CAR AND OIL DRIPPED ONTO THE CLUTCH AND BRAKE PEDDLES CAUSING FOOT SLIPPAGE. THE LATEST SITUATIONS I WAS STUCK IN TRAFFIC,STOP AND GO, AND BEGAN HAVING PROBLEMS GETTING THE CAR IN GEAR. NEXT I WAS BACKING UP SLOWLY WHEN I EXPERIENCED NO CLUTCH PEDDLE AND THE CAR BEGAN SPEEDING UP I COULD NOT GET IT OUT OF GEAR I HAD TO SHUTDOWN THE ENGINE TO STOP THE CAR FROM PULLING AND GET IT OUT OF GEAR. THE CAR IDLES HIGH WHEN I COME TO A LIGHT OR STOP SIGN AND EVENTUALLY COMES DOWN. THE GAS PEDDLE STICKS IN COOLER WEATHER. THERE ARE TIMES WHEN I'M IN TRAFFIC I HAVE TO PRESS REALLY HARD. *TR
GAS PEDAL STICKING DUE TO MANUFACTURES DEFECT IN THE WAY THE GAS PEDAL CABLE IS DESIGNED. THERE WAS NOT REALLY A CRASH, BUT WE DID HAVE TO GO OFF OF THE ROAD TO KEEP FORM HITTING THE CAR IN FRONT OF US AT A STOP LIGHT. THE CABLE WAS FRAYED AND WAS GETTING STUCK INSIDE OF THE JACKET CAUSING THE PEDAL TO STICK AT THE PREVIOUS SETTING. I CONTACTED FORD, I WAS TOLD "TOO BAD NOTHING WE CAN DO" IF THIS PROBLEM IS NOT FIXED PEOPLE WILL DIE AND FORD DOESN'T CARE! NOT ANY REAL PROPERTY DAMAGE, JUST MUD AND A FEW SCRATCHES FROM GOING OFF OF THE ROAD. *TR
TL* THE CONTACT OWNS A 2006 FORD FOCUS. WHILE DRIVING AT APPROXIMATE SPEEDS OF 55-60 MPH, THE VEHICLE BEGAN ABNORMALLY ACCELERATING AND THEN STALLED. THE CONTACT WAS ABLE TO COAST OFF THE ROADWAY AND AFTER TWENTY MINUTES HE WAS ABLE TO RESTART THE VEHICLE. THE FAILURE PERSISTED. THE FUEL FILTER WAS REPLACED BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE FUEL FILTER, PUMP AND DRIVER MODULE WERE REPLACED. THE FAILURE MILEAGE WAS 52,814 AND THE CURRENT MILEAGE WAS 54,000.
TL*THE CONTACT OWNS A 2006 FORD FOCUS. WHILE THE CONTACT WAS TRAVELING APPROXIMATELY 55 MPH THE CHECK ENGINE WARNING LIGHT ILLUMINATED ON THE DASHBOARD. THE VEHICLE BEGAN TO HESITATE IN A JERKING MOTION. THE VEHICLE WAS DRIVEN OFF THE ROADWAY. THE ENGINE WAS TURNED OFF AND RESTARTED AFTER WAITING FOR A FEW MOMENTS. THE VEHICLE WAS ABLE TO OPERATE NORMALLY. THE FUEL FILTER WAS REPLACED BY A CERTIFIED MECHANIC AND THE FAILURE STOPPED. THE ENGINE LIGHT FAILURE OCCURRED ON A SEPARATE OCCASION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN STATED THE FAILURE WAS CONTRIBUTED TO THE FUEL PUMP AND FUEL PUMP DRIVER MODULE. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS 50,000. UPDATED 06/04/10. *LJ THE FUEL PUMP WAS REPLACED.
THE ACCELERATOR PEDAL BINDS IN MY WIFE'S 2006 FOCUS. THE OTHER DAY IT STUCK OPEN AND WOULD NOT RELEASE WHILE SHE WAS ON THE EXPRESSWAY. SHE GRABBED THE FLOOR MAT AND PULLED IT AWAY IN CASE IT WAS CAUSING IT TO NO EFFECT. SHE HIT THE BRAKES AND THE CAR WOULDN'T SLOW DOWN. THE ACCELERATOR PEDAL WOULDN'T RESPOND TO INPUT IT WAS JAMMED, AFTER STOMPING HER FOOT ON IT SEVERAL TIMES IT FINALLY RELEASED. DEALER CLAIMED AT FIRST WAS FLOOR MAT BUT POINTED OUT MAT WAS SITTING ON THE OTHER SIDE OF THE CAR - THEN CLAIMED IT WAS CARBON BUILD UP ON THROTTLE BODY CAUSING IT TO JAM. *TR
AFTER ACCIDENT OCCURRED ON SEPT 6, 2009, I NOTICED THAT THE GAS PEDAL SEEMS TO STICK ESPECIALLY AFTER OR DURING USE OF THE CRUISE CONTROL. CAR ENGINE ALSO REVVED IN PARK ONCE, AND A COUPLE OF TIMES SEEMED HARD TO BRAKE. CAR TAKEN TO DEALERSHIP AND DIAGNOSED FOR $100. DEALERSHIP SAYS IT IS NOT RELATED TO ACCIDENT BUT THAT THE THROTTLE BODY NEEDS TO BE REPLACED BECAUSE THE PEDAL IS STICKING AND IT IS A SAFETY ISSUE - COST ALMOST $400 NOT INCLUDING THE COST OF THE DIAGNOSTICS. SECOND DEALERSHIP CONFIRMED PRICE OF THROTTLE BODY AND SAID THAT I NEEDED TO GET IT FIXED BECAUSE IT'S A SAFETY ISSUE. MY CAR IS A 2006 FORD. I WAS NOT ABLE TO GET THE CAR FIXED. I DON' T HAVE THAT MUCH MONEY, DEALERSHIP PUT THAT I REFUSED SERVICE. *TR
DT*: THE CONTACT STATED THAT GASOLINE OVERFLOWED FROM THE GAS TANK ON AN INTERMITTENT BASIS. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER WHO UPON EXAMINATION DETERMINED THAT THERE WAS MINOR DEBRIS IN THE VENT HOSE OF THE GAS TANK. THE DEALER BLEW OUT THE VENT HOSE. AFTER THE PROCEDURE THERE WERE NO FURTHER PROBLEMS WITH THE GAS TANK. THERE WAS A NHTSA RECALL # 06E056000 REGARDING FUEL SYSTEM, GASOLINE WHICH WAS FOUND THAT WAS SIMILAR TO THIS ISSUE. UPDATED 01/10/06. *JB
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .