2002 Ford Ford Truck Problems

AUTOMATIC TRANSMISSION SLIPPING AND HARD BANG WHEN IT GO INTO GEAR. FORD SERVICE DEPT.DIAOGNOSE TRANS OP, NO CODES,LINE PRESSURE TEST.R110-N-75 OD95 L-95. R&R TRANSMISSION PAN FOR INSPECTION, PIECES OF BRASS BUSHINGS IN PAN. R&R TRANS TO OVERHAUL. REPLACED OD PLANETARY ASSY .BUSHINGS BETWEEN GEARS COME APART) FLUSHED COLLING LINES,REPLACED CONVERTER(METAL CONTAMINATION.) REPLACED VALVE BODY(VALVES STICKING). CLEARED PCM MEMORY & REFLASHED PCM. ROAD TEST. ALL THE ABOVE WORK WAS DONE ACCORDING TO THE INVOICE. WHEN I DROVE THE TRUCK I COULD HEAR A NOISE THAT WASN'T THERE BEFORE, I TOOK THE TRUCK BACK TO THE DEALER AND CHECKED THINGS OUT AND TOLD ME EVERY THING WAS FINE, BUT IT WASN'T. *TR

DRIVING MY VEHICLE WITH MY 2 CHILDREN 2 AND 10 YEAR. DROPPING THE 2 YEAR OLD OFF TO SCHOOL. STOP THE VEHICLE GO TO PUT THE SHIFT GEAR INTO PARK, BREAKS RIGHT OFF IN HAND, IF THE RUBBER WASN'T AROUND IT, I COULD HAVE WALKED OUT OF THE CAR WITH IT. I WAS STUCK THERE KEEPING MY FOOT ON THE BRAKES BECAUSE THE GEAR WAS ALSO STUCK BETWEEN REVERSE AND PARK. *TR

2002 FORD EXPLORER VERY COLD NIGHT NOTICED A HUGE CRACK IN THE REAR PANEL BELOW REAR WINDOW RIGHT OUT OF NOWHERE THE CAR WAS FINE HOURS BEFORE AND AS I WALKED PAST IT AGAIN SAW A HUGE CRACK BY THE EMBLEM AND UNDER.*CN

TIRE TREAD PEALED OFF MY TIRE CAUSING SIGNIFICANT DAMAGES TO MY SIDE STEP, THE METAL AROUND MY TIRE WHEEL GOT BENT UP INTO MY DOOR AND TORE OFF ALL MY WHEEL WELL PLASTIC. ALMOST CAUSED MY FRONT BUMPER TO COME OFF IT IS NOW TORN ON THAT SIDE AND A PLASTIC PIECE UNDER THE BUMPER IS BARELY HANGING IN THERE. I STILL HAVE THE TIRE AS IT DIDN'T DEFLATE. MY STEERING WHEEL CLICKS AND MAKES MY CAR SKIP WHEN I MAKE A LEFT HAND TURN. AS IF THE TIRES ARE NOT TURNING CORRECTLY. THE AIR BAG LIGHT IS ON! *TR

WHILE GOING AROUND A HAIRPIN TURN THE DRIVER SIDE FRONT TIRE FELL OFF ROTOR AND ALL, THIS INCIDENT CAUSED THE 2002 FORD LIGHTNING TRUCK TO SLIDE INTO THE CURB CAUSING THE TRUCK TO ROLL COMPLETELY OVER LANDING BACK ON IT'S 3 TIRES THAT WERE LEFT. FROM THE LOOK OF IT THE AXLE BOLT FELL OFF CAUSING THE TIRE TO FALL OFF. DRIVER WAS GOING UNDER THE SPEED LIMIT & NO OTHER VEHICLES WERE INVOLVED. ACCORDING TO A FRIEND THIS SAME INCIDENT HAPPENED TO HIS LIGHTNING TRUCK. SOUNDS LIKE A DEFECT ON FORDS PART. *TR

75400 MILES. NOISE FROM REAR END BECOMING MORE NOTICEABLE. ALSO, THE TRANSMISSION SUDDENLY WON'T SHIFT FROM 2ND TO 3RD. DEALER DIAGNOSED THE REAR END PROBLEM AS BEARINGS NEEDED TO BE REPLACED AND PROBABLY THE REAR HUBS WERE BAD. THE TRANSMISSION WAS BAD, AND NEEDED TO BE REPLACED. FORD DEALER SERVICE ADVISED ME TO CONTACT FORD 800 NUMBER, AND OPERATOR AFTER PUTTING ME ON HOLD AND TALKING TO THE DEALER TURNED THE PROBLEM OVER TO THE NEXT LEVEL OF CUSTOMER CAR BECAUSE HER LIMIT OF $500 WOULD NOT BEGIN TO COVER THE REPAIRS. FORD COSTUMER CARE CALLED ME AND AFTER LETTING ME TELL MY STORY SAID THERE WAS NO PROGRAM DOLLARS AVAILABLE FOR ASSISTING IN FIXING EITHER PROBLEM, EVEN THOUGH THE REAR END PROBLEM WAS DIRECTLY RELATED TO THE PREVIOUS VISIT AT 74,400 MILES PER THE DEALERS RECOMMENDATION. ALSO INFORMED ME THAT NOT EVEN THE $500 WAS AVAILABLE ,AND THE OPERATOR HAD NO RIGHT TO OFFER THAT AMOUNT. TOOK THE CAR FROM THE DEALER AFTER PAYING $120, PLUS $100 CAR RENTAL THEY WOULD NOT COVE) SINCE THE MILEAGE WAS 400 OVER WARRANTY 75000 MILEAGE LIMIT TO DIAGNOSE A PROBLEM THEY FAILED TO CORRECTLY DIAGNOSE THE FIRST 2 TIMES. *AK

FORD F 250 TRITON V10 NO. 2 SPARK PLUG AND COIL BLEW OUT OF THE ENGINE HEAD. APPARENTLY THIS IS A COMMON PROBLEM WITH THIS MODEL AND OTHERS. FORD WILL CHARGE 650.00 TO FIX. *TR

CONTINUOUS ROARING NOISE COMING FROM REAR OF OUR 2002 FORD EXPLORER. WAS DETERMINED THAT REAR DIFFERENTIAL WAS BAD. IF IT WOULD HAVE GONE OUT WHILE DRIVING, TRUCK COULD HAVE LOCKED UP. WAS TOLD BY SERVICE THAT WAS A BIG SAFETY CHANCE TO TAKE. OUT OF WARRANTY ON MILES. (BUT NOT ON 3 YEARS).SO IT COST US $1900 OUT OF POCKET TO REPAIR. HAVE ALSO BEEN TOLD FORD IS AWARE OF PROBLEM. *JB

TIRE TREAD PEALED OFF MY TIRE CAUSING SIGNIFICANT DAMAGES TO MY SIDE STEP, THE METAL AROUND MY TIRE WHEEL GOT BENT UP INTO MY DOOR AND TORE OFF ALL MY WHEEL WELL PLASTIC. ALMOST CAUSED MY FRONT BUMPER TO COME OFF IT IS NOW TORN ON THAT SIDE AND A PLASTIC PIECE UNDER THE BUMPER IS BARELY HANGING IN THERE. I STILL HAVE THE TIRE AS IT DIDN'T DEFLATE. MY STEERING WHEEL CLICKS AND MAKES MY CAR SKIP WHEN I MAKE A LEFT HAND TURN. AS IF THE TIRES ARE NOT TURNING CORRECTLY. THE AIR BAG LIGHT IS ON! *TR

74400 MILES. NOISE COMING FROM REAR END AND FEELS LIKE THE BRAKES ARE DRAGGING WHEN SLOWING DOWN. THE NOISE WAS WORSE WHEN ENGAGING THE 4-WD HIGH. THE DEALER DIAGNOSED THE PROBLEM AS A BAD TRANSFER CASE ASSEMBLY. WAITED 2 DAYS BECAUSE THE FACTORY REPRESENTATIVE HAD TO APPROVE THE REPAIR. WAS TOLD THE MAIN SHAFT HAD CRACKED AND WAS ENGAGING THE 4-WD EVEN THOUGH IT DID NOT SHOW UP ON THE INSTRUMENT PANEL. AFTER PICKING UP THE VEHICLE IT SEEMED TO BE BETTER EVEN THOUGH NOT COMPLETELY GONE. MY MISTAKE FOR NOT RETURNING THE TRUCK BECAUSE IT STARTED TO GET WORSE AT 75400 , AND NOW THE FORD CUSTOM CARE CERTIFIED THE TRUCK AS A USED CAR COVERING DRIVE TRAIN UNTIL 75000 MILES, AND IT WOULD NOT AUTHORIZE ANY FURTHER WORK EVEN THOUGH THE PROBLEM STILL HAD THE SAME SYMPTOMS FROM 2 OTHER VISITS AT THE SAME DEALER. EVEN THOUGH THE SERVICE ADVISOR AT THE DEALERSHIP RECOMMEND THAT THE WORK BE DONE. *AK

TIRE TREAD PEALED OFF MY TIRE CAUSING SIGNIFICANT DAMAGES TO MY SIDE STEP, THE METAL AROUND MY TIRE WHEEL GOT BENT UP INTO MY DOOR AND TORE OFF ALL MY WHEEL WELL PLASTIC. ALMOST CAUSED MY FRONT BUMPER TO COME OFF IT IS NOW TORN ON THAT SIDE AND A PLASTIC PIECE UNDER THE BUMPER IS BARELY HANGING IN THERE. I STILL HAVE THE TIRE AS IT DIDN'T DEFLATE. MY STEERING WHEEL CLICKS AND MAKES MY CAR SKIP WHEN I MAKE A LEFT HAND TURN. AS IF THE TIRES ARE NOT TURNING CORRECTLY. THE AIR BAG LIGHT IS ON! *TR

AUTO ACCIDENT AND DRIVER'S AIRBAG DID NOT DEPLOY. I SUFFERED INJURIES TO ANKLES, FRACTURE TO RIGHT LEG, BRUISES TO CHEST AREA AND HIP AREA. VEHICLE WAS TOTALED. I REPORTED THIS PROBLEM TO FORD FOR THEIR RECORDS.

REF 2002 FORD EXPLORER, TRANSMISSION PROBLEMS. THIRD GEAR WENT OUT AT 57,000 MILES. BEACH FORD REPLACED. HAVE NEVER GOTTEN THE GEARS SYNCRONIZED. HAVE TO TOUCH GEAR SHIFT SOMETIMES TO PUT IN GEAR. TONIGHT CAR IS BACK AT BEACH FORD WITH A TRANSMISSION PUMP LEAK. REPORTED THIS CAR LAST WEEK FOR ACCELERATION PROBLEMS. *NM

TURNED CAR INTO PARKING LOT, HAD FOOT ON BRAKE CAR BEGAN TO ACCELERATE. FINALLY, WITH MUCH PUMPING OF THE BRAKE, IT FINALLY STOPPED. NEARLY HIT THE CAR IN FRONT OF ME. *JB

FORD F 250 TRITON V10 NO. 2 SPARK PLUG AND COIL BLEW OUT OF THE ENGINE HEAD. APPARENTLY THIS IS A COMMON PROBLEM WITH THIS MODEL AND OTHERS. FORD WILL CHARGE 650.00 TO FIX. *TR

FORD F 250 TRITON V10 NO. 2 SPARK PLUG AND COIL BLEW OUT OF THE ENGINE HEAD. APPARENTLY THIS IS A COMMON PROBLEM WITH THIS MODEL AND OTHERS. FORD WILL CHARGE 650.00 TO FIX. *TR

The contact owns a 2002 Ford Think Neighbor. The contact stated that after entering the vehicle and attempting to secure the front driver’s seat belt latch into the buckle, the seat belt latch failed to lock into place. The seat belt loosened and unlatched from the buckle while the contact was driving. The contact stated that the failure was intermittent. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 20,000.

ON THE RIDE HOME FROM PURCHASING MY NEW CAR, MY SEAT BELT CAME UNLATCHED. THIS EVENT REPEATED SEVERAL TIMES ON THE RIDE HOME. I CALLED THE DEALER THE NEXT DAY, AND THEY SAID TO BRING THE CAR IN AND THEY WOULD FIX IT. THE MIDDLE FRONT SEAT BELT WASN'T ASSEMBLED TO BEGIN WITH, SO THEY SAID THEY WOULD FIX BOTH PROBLEMS. DUE TO THE FAMILY CATCHING THE FLU THAT DAY I DID NOT BRING THE CAR IN, HOWEVER THE SEATBELT BEGAN ENGAGING PROPERLY. A FEW MONTHS LATER IT BEGAN LATCHING INTERMITTENTLY AGAIN. I TOOK IT TO THE DEALERSHIP, BUT THEY SAID IT WAS WORKING PROPERLY. I?VE HAD THIS HAPPEN NUMEROUS TIMES OVER THE LAST FEW YEARS, WHERE I CAN?T GET THE SEATBELT TO LATCH AT ALL, YET THE DEALERSHIP [I?VE BEEN TO SEVERAL] SAID THERE WAS NOTHING WRONG WITH IT. AFTER 2 YEARS OF CHECKING 2002 RECALLS AND FINDING NOTHING, I FINALLY CHECKED THE 2001 RECALLS AND FOUND SEVERAL EXPERIENCES JUST LIKE MINE. ABOUT TWO MONTHS AGO I MADE AN APPOINTMENT WITH THE DEALERSHIP BY PHONE FOR AN UNRELATED RECALL, AND THEY WERE AWARE I HAD A 2002. I TOLD THE PERSON ABOUT MY SEATBELT PROBLEM, AND WAS TOLD IT WAS A KNOWN ISSUE, AND WOULD BE FIXED FOR FREE. WHEN I ARRIVED AT THE DEALERSHIP I WAS TOLD THERE WAS NOTHING WRONG, AND THAT IT WOULD COST $125 TO FIX. I BOUGHT THIS CAR IN JANUARY 2002, AND IT WAS SOLD AS A 2002, BUT IT HAD SITTING ON THE LOT FOR MONTHS. THE SEATBELT PROBLEM HAS ME WONDERING IF I ACTUALLY BOUGHT A 2001. *AK

MY 2002 FORD EXPLORER, AT APPROX. 62,000 MILES WAS MAKING A LOUD HUMMING NOISE COMING FROM THE REAR WHEELS WHEN YOU HIT THE GAS. I TOOK IT TO A GOODYEAR SERVICE CENTER & WAS TOLD THEY'VE SERVICED AT LEAST 6-7 OF THE 2002 EXPLORERS FOR THE SAME ISSUE- SOME WITH ONLY 30,000 MILES. THEY TOLD ME THAT IT WAS POOR DESIGN ON FORD'S PART OF THE WHEEL HUB ASSEMBLY? IT COST ME OVER $300 TO FIX THE DRIVER'S SIDE REAR WHEEL ASSEMBLY- THEY HAD TO REPLACE A ROTOR IN THE PROCESS BECAUSE WATER GOT IN WHERE THE SEAL BROKE AND RUSTED TO THE ROTOR AND HAD TO BE CUT OFF. THEY SAID THE SEAL IS BAD ON THE ASSEMBLY AND THE WHOLE WHEEL ASSEMBLY COMES APART. THEY SAVED PARTS TO SHOW ME & SAID IT'S A SAFETY ISSUE (REAR WHEEL COULD COME OFF). I'M VERY ANGRY- I'M NOW HEARING THE SAME HUMMING NOISE COMING FROM THE PASSENGER SIDE REAR WHEEL. I FOUND NUMEROUS COMPLAINTS ONLINE FOR THE SAME ISSUE, YET FORD HAS NOT HAD A RECALL?!? THIS IS A SAFETY ISSUE, AND IF ANYTHING HAPPENS TO MY CAR WITH MY DAUGHTER INSIDE, FORD WILL HAVE A HUGE LAWSUIT ON THEIR HANDS. I HAVE BEEN VERY DISSATISFIED WITH MY FORD EXPLORER. THE CAR HAS ALSO FAILED TO START INTERMITTENTLY SINCE IT WAS NEW. EACH OF THE 4-5 TIMES I HAVE TAKEN IT TO THE DEALER, I AM TOLD THEY CAN'T RECREATE THE ISSUE AND THAT FORD HAS SERVICE GUIDELINES AND THEY CANNOT TEAR MY CAR APART TO FIGURE OUT WHAT THE PROBLEM IS. I HAD ANOTHER ELECTRICAL ISSUE WHERE FOR OVER A YEAR I'D BE DRIVING DOWN THE ROAD AND THE "DOOR AJAR" LIGHT WOULD SUDDENLY GO ON & THE INTERIOR LIGHTS AND BUZZERS WOULD SOUND. NUMEROUS TRIPS TO THE DEALER, AND THEY COULD NEVER RECREATE. FINALLY IT GOT TO THE POINT WHERE IT WAS SO BAD THAT THEY FINALLY HEARD WHAT I WAS TALKING ABOUT & REPLACED SOME REAR HATCH LOCK. IT SEEMED OK....UNTIL A WEEK LATER WHEN IT HAPPENED AGAIN. IT STILL DOES IT INTERMITTENTLY, BUT I AM SO SICK OF TAKING IT IN FOR THE SAME ISSUE. THEN I THINK THE TRANSMISSION HAS BEEN GOING AS WELL- IT STICKS WHEN YOU TRY TO PUT THE CAR IN REVERSE. *NM

THE TRANSMISSION SLIPPED, THE PAINT WAS DEFECTIVE, AND THE RUNNING BOARD ON THE PASSENGER SIDE WAS DAMAGED. THE BACK BED ON TRUNK NEEDED TO BE REALIGNED AND THE VEHICLE PULLED TO THE RIGHT WHILE DRIVING. IN ADDITION, THE FRONT PASSENGER DOOR DID NOT CLOSE PROPERLY EVEN AFTER REPAIR.*PH *JB

AUTOMATIC TRANSMISSION SLIPPING AND HARD BANG WHEN IT GO INTO GEAR. FORD SERVICE DEPT.DIAOGNOSE TRANS OP, NO CODES,LINE PRESSURE TEST.R110-N-75 OD95 L-95. R&R TRANSMISSION PAN FOR INSPECTION, PIECES OF BRASS BUSHINGS IN PAN. R&R TRANS TO OVERHAUL. REPLACED OD PLANETARY ASSY .BUSHINGS BETWEEN GEARS COME APART) FLUSHED COLLING LINES,REPLACED CONVERTER(METAL CONTAMINATION.) REPLACED VALVE BODY(VALVES STICKING). CLEARED PCM MEMORY & REFLASHED PCM. ROAD TEST. ALL THE ABOVE WORK WAS DONE ACCORDING TO THE INVOICE. WHEN I DROVE THE TRUCK I COULD HEAR A NOISE THAT WASN'T THERE BEFORE, I TOOK THE TRUCK BACK TO THE DEALER AND CHECKED THINGS OUT AND TOLD ME EVERY THING WAS FINE, BUT IT WASN'T. *TR

THE LIFTGATE MOLDING DEVELOPED A CRACK SEVERAL INCHES LONG AFTER OWNING THE VEHICLE FOR 2 1/2 YEARS WITH ROUGHLY 55,000 MILES. A RECALL NOTICE WAS RECEIVED DEALING WITH THE LIFT GATE WINDOW,BUT, THE RECALL DIDN'T INCLUDE THE CRACKED MOLDING. I HAVE NOTICED MANY EXPLORERS WITH THIS SAME ISSUE. I ADDRESSED THIS ISSUE WHEN I TOOK THE VEHICLE IN TO HAVE THE RECALL WORK COMPLETED, BUT MY FORD DEALERSHIP WAS NOT WILLING TO FIX THE LIFT GATE UNTIL I AGREED TO HAVE THEM PERFORM OTHER VEHICLE MAINTENANCE TO THE TUNE OF OVER $400. I FEEL THIS IS MORE OF A FORM OF BLACKMAIL THAN KINDNESS. I FEEL THIS LIFT GATE IS A FAULTY PRODUCT AND I SHOULDN'T HAVE HAD TO PAY THE "EXTRA" MONEY TO HAVE THE GATE MOLDING FIXED. I DO BELIEVE THE RECALL ON THE LIFT GATE WINDOW AND THE FAULTY MOLDING ARE CONNECTED. AFTER THE RECALL WINDOW WAS REPAIRED AND BEFORE THE MOLDING WAS REPLACED, THERE WAS A CONSTENT RATTLE DUE TO THE CRACKED MOLDING. *AK

I TOOK THE KIDS TO THE BABYSITTER AND WENT TO PUT THE TRUCK IN PARK AND THE GEAR SHIFTER BROKE OFF INSIDE THE STEERING COLUMN. IT HAS ALWAYS HAD A PLACE WHERE THE SHIFTER LEVER WOULD KIND OF CATCH BETWEEN REVERSE AND PARK AND YOU HAD TO WIGGLE IT WHEN PUTTING IT INTO PARK . I WAS TOLD IT HAD TO HAVE A NEW STEERING COLUMN THAT IS $500+ NOT INCLUDING LABOR. I THINK THIS COULD BE VERY DANGEROUS. WHAT IF IT HAPPENED GOING DOWN THE ROAD OR WHEN MY 15 YEAR OLD [BEGINNER DRIVER] WAS DRIVING. *TR

FORD F 250 TRITON V10 NO. 2 SPARK PLUG AND COIL BLEW OUT OF THE ENGINE HEAD. APPARENTLY THIS IS A COMMON PROBLEM WITH THIS MODEL AND OTHERS. FORD WILL CHARGE 650.00 TO FIX. *TR

THE MIRRORS ON BOTH MY 2002 FORD SPORT TRAC AND 2002 FORD RANGER DO NOT WORK PROPERLY. THE MIRRORS (X4) ARE ELECTRIC AND WILL NOT MOVE TO THE RIGHT. THEY WORK IN THE AXIS OF LEFT, UP, AND DOWN. I HAVE TALKED WITH OTHERS WHO HAVE THE SAME TYPE OF MIRROR ON THEIR 2002 VEHICLES AND ALL HAVE THE SAME PROBLEM. *TR