2015 Ford Fusion Energi Problems

The contact owns a 2015 Ford Fusion Energi. The contact stated that the engine control module failed to shutoff the vehicle causing the battery to drain. The contact was then unable to start the vehicle. The failure happened several times over a two-year period. The contact stated that to restart the vehicle he would break into the vehicle through the trunk to get to the battery and jumpstart the vehicle. The contact had taken the vehicle to the dealer and was informed that there was no recall associated with the VIN and that there were no known issues. The contact stated that the manufacturer knew about the issue but decided not to issue a recall. The manufacturer was made aware of the failure and confirmed that there was no recall associated with the issue. The contact was referred to NHTSA for assistance. The approximate failure mileage of 96,000. Consumer found a website explaining exactly what was happening with consumer's car was found on lenberglaw.com lemon law vehicles.

TL* THE CONTACT OWNS A 2015 FORD FUSION ENERGI. WHILE THE VEHICLE WAS CHARGING, THE PLUG MELTED INTO THE WALL AT THE CONTACT'S HOME. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 18V592000 (EQUIPMENT). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO WEST HILLS FORD (1100 OYSTER BAY AVE S, BREMERTON, WA 98312) AND THEY STATED THAT THE PART WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

The contact owns a 2015 Ford Fusion Energi. The contact stated while driving approximately 45-60 MPH, the vehicle started making an abnormally loud humming sound while releasing the accelerator pedal. The contact stated that upon depressing the accelerator pedal, the vehicle hesitated and jerked backward several times. The contact was able to continue driving; however, the failure reoccurred increasingly while driving the following day. The warning message "Engine coolant temperature - Pull Over As Soon As Possible" was displayed. The contact veered to the side of the road. The vehicle was towed to the local dealer where the failure was diagnosed as a transmission failure. The dealer informed the contact that the repair would be covered by the manufacturer; however, the parts were on back order. The contact became aware that the VIN was included in NHTSA Campaign Number: 22V413000 (Power Train). The manufacturer was notified of the failure but provided no assistance. The vehicle was not repaired. The failure mileage was approximately 100,070.

SHIFTER BUSHING CABLE - THIS PART BROKE OFF FROM MY VEHICLE BACK IN JULY. THE BUSHING CONNECTS SHIFTER ARM TO TRANSMISSION. WITHOUT THIS PIECE, MY VEHICLE NEEDS ASSISTANCE TO COMPLETE EVERY SINGLE SHIFT. WHEN ATTEMPTING TO MOVE FROM PARK TO DRIVE, I HAVE TO GET OUT OF MY VEHICLE, OPEN THE HOOD, PLACE THE SHIFTER DOWN ON THE TRANSMISSION ARM, THEN SHIFT THE CART. TO GO FROM DRIVE TO PARK, I HAVE TO ENGAGE THE PARKING BREAK, GET OUT OF THE CAR, POP THE HOOD, REATTACH THE SHIFTER ARM, THEN SHIFT THE CAR. THIS ISSUE HAS BEEN ONGOING SINCE JULY 2018 WITH NO NOTICE FROM FORD ON WHEN THE REPLACEMENT PART WILL BE AVAILABLE. THIS SPECIFIC PART IS NOT SOLD ON THE AFTERMARKET EITHER, MEANING THAT I DO NOT HAVE ANY WAY TO FIX MY CAR AND THUS HAVE TO DEAL WITH THE ISSUE EVERY SINGLE TIME I DRIVE THE CAR. I'M VERY CONCERNED THAT ALL OF THIS SHIFTING AND OPENING AND CLOSING OF MY HOOD IS CAUSING LONG-TERM DAMAGE TO THE CAR (THAT FORD WOULD MOST LIKELY NOT FIX). I HAVE CALLED FORD OVER 8 TIMES TO COMPLAIN AND HAVE RECEIVED NO ETA ON PARTS, NO OTHER WAY TO FIX THE ISSUE, NOR ANY COMPENSATION/HELP TOWARDS ME BEING ABLE TO USE MY CAR. RECALL WAS ISSUED ON JULY 20TH, 2018; OVER 3 MONTHS LATER, NO REPLACEMENT PART HAS BEEN PROVIDED.

The contact owns a 2015 Ford Fusion Energi. The contact stated while driving at various speeds, the steering wheel became difficult to turn to the left or the right. The contact stated that the ABS and traction control warning lights were illuminated. The vehicle was towed to a local dealer where it was diagnosed and determined that the electrical rack and pinion needed to be replaced and recalibrated. In addition, the contact linked the failure to NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included. The vehicle was not repaired due to costs. The manufacturer was made aware of the failure. The failure mileage was approximately 100,008.

WHILE DRIVING DOWN A CITY STREET MY CAR HAD A COMPLETE LOSS OF POWER, WITH MULTIPLE WARNING LIGHTS AND ALARMS GOING OFF. THERE WAS NO WARNING OF THIS FAILURE PRIOR AS THE CAR WAS OPERATING NORMALLY. ASSOCIATED WITH THIS LOSS OF POWER WAS A LOSS OF STEERING AND A LOSS OF POWER ASSIST BRAKING, WHICH RESULTED IN THE CAR CAME TO A STOP IN THE MIDDLE OF THE STREET. ONCE IN PARK IT WOULD NOT ALLOW CHANGING GEARS. A TOW TRUCK REQUIRED THE USE OF TIRE DOLLY'S TO LOAD THE VEHICLE, WHICH WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER MAINTENANCE DEPARTMENT WAS UNABLE TO DIAGNOSE A CAUSE, AND USED THE ANALOGY THAT THE CAR HAD AN "ELECTRICAL SEIZURE," WHICH I INTERPRET AS A CATASTROPHIC ELECTRICAL SYSTEM FAILURE. THEY WERE ABLE TO MAKE THE CAR OPERABLE BY REBOOTING, AND REINSTALLING SOFTWARE, TO THE CAR'S COMPUTER. *TR

The contact owns a 2015 Ford Fusion. The contact stated while driving approximately 55 MPH, the vehicle lost motive power. The contact stated that upon inspection, an oil leak was found. The vehicle was towed to an independent mechanic; however, the vehicle was not diagnosed or repaired. The vehicle was towed to a local dealer where it was diagnosed and determined that the engine needed to be replaced due to several holes and cracks being found on the engine block. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 150,000.

The contact owns a 2015 Ford Fusion Energi. The contact stated that the engine control module failed to shutoff the vehicle causing the battery to drain. The contact was then unable to start the vehicle. The failure happened several times over a two-year period. The contact stated that to restart the vehicle he would break into the vehicle through the trunk to get to the battery and jumpstart the vehicle. The contact had taken the vehicle to the dealer and was informed that there was no recall associated with the VIN and that there were no known issues. The contact stated that the manufacturer knew about the issue but decided not to issue a recall. The manufacturer was made aware of the failure and confirmed that there was no recall associated with the issue. The contact was referred to NHTSA for assistance. The approximate failure mileage of 96,000. Consumer found a website explaining exactly what was happening with consumer's car was found on lenberglaw.com lemon law vehicles.

SEVERAL TIMES NOW. WHILE DRIVING THE CAR (AC NORMALLY ON), WE WILL GET TO A FULL STOP FROM DRIVING (OVER ~40 MIN TRIPS)... WHETHER IN TRAFFIC ON A FREEWAY OR STOP SIGN... THE CARS CHECK BRAKE SYSTEM LIGHT WILL FLASH & BEEP, AND THE CAR WILL NOT ACCELERATE. NEITHER THE ELECTRIC MOTOR NOR THE GAS/HYBRID ENGINE WILL ENGAGE AND DRIVE. TURNING OFF AND ON THE CAR DOES NOT RESET IT... IT TAKES REPEAT EFFORT AND SEVERAL MINUTES (ONCE OVER 10 MINUTES) TO BE ABLE TO START UP. CAN'T IMAGINE IF IT WERE TO HAPPEN ON A FREEWAY AGAIN WITH A CHILD OR MY OTHER HALF IN THE CAR! SCARY! TOOK IT TO THE DEALERSHIP SEVERAL TIMES WITHOUT ANY LUCK DIAGNOSING OR FIXING THE ISSUE... WE NEED A RELIABLE VEHICLE THIS IS INSANE. NOW THE CAR IS OUT OF WARRANTY AND DOING IT AGAIN. FORD NOR ANY DEALER SHOP CAN HELP FIX THIS. THEY CAN'T REPRODUCE IT, THE ISSUE IS SPORADIC WHICH MAKES IT WORSE & MORE TERRIFYING TO EXPERIENCE. SO FAR 4 OCCURRENCES WITHIN THE LAST 4 MONTHS. ABOUT 10 + OVER THE 3 YEARS SINCE WE PURCHASED THE CAR NEW. THE LIGHTS ALWAYS RESET BY THE TIME WE MAKE IT TO A DEALER LOT. THEIR SYSTEMS CANNOT TROUBLE SHOOT ANYTHING AT THAT POINT! IT HAPPENED AGAIN RECENTLY WHEN PARKED FOR OVER AN HOUR, AFTER A 80 MILE DRIVE. WHEN WE WENT TO DRIVE HOME, IT WOULD NOT DRIVE/ACCELERATE. SAME BRAKE SYSTEM LIGHT ISSUE WAS POPPING UP AGAIN. ALMOST HAD TO GET A TOW, THEN ALL OF A SUDDEN IT STARTED BACK UP AGAIN AS THE DRIVER GOT TO US.

WHILE DRIVING DOWN A CITY STREET MY CAR HAD A COMPLETE LOSS OF POWER, WITH MULTIPLE WARNING LIGHTS AND ALARMS GOING OFF. THERE WAS NO WARNING OF THIS FAILURE PRIOR AS THE CAR WAS OPERATING NORMALLY. ASSOCIATED WITH THIS LOSS OF POWER WAS A LOSS OF STEERING AND A LOSS OF POWER ASSIST BRAKING, WHICH RESULTED IN THE CAR CAME TO A STOP IN THE MIDDLE OF THE STREET. ONCE IN PARK IT WOULD NOT ALLOW CHANGING GEARS. A TOW TRUCK REQUIRED THE USE OF TIRE DOLLY'S TO LOAD THE VEHICLE, WHICH WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER MAINTENANCE DEPARTMENT WAS UNABLE TO DIAGNOSE A CAUSE, AND USED THE ANALOGY THAT THE CAR HAD AN "ELECTRICAL SEIZURE," WHICH I INTERPRET AS A CATASTROPHIC ELECTRICAL SYSTEM FAILURE. THEY WERE ABLE TO MAKE THE CAR OPERABLE BY REBOOTING, AND REINSTALLING SOFTWARE, TO THE CAR'S COMPUTER. *TR

IF I CRANK THE CAR SOON AFTER CUTTING IT OFF, (WHILE IT'S STILL WARM) ENGINE SPUTTERS THEN QUITS, AS IF IT ISN'T GETTING ENOUGH FUEL. SO WHEN GETTING GAS, I HAVE TO HOLD DOWN THE GAS PEDAL OR ENGINE QUITS. AS SOON AS I START PUMPING, THE ENGINE STARTS CHOKING. I CAN'T TURN OFF THE IGNITION WHILE PUMPING GAS BECAUSE IT WON'T STAY CRANKED ONCE I TRY TO DRIVE AWAY UNLESS I REV THE RPM'S UP REALLY HIGH FOR A PERIOD OF TIME. I'VE HAD IT LOOKED AT SEVERAL TIMES AND NO ONE CAN FIGURE OUT WHAT'S WRONG. THIS HAS BEEN AN ONGOING PROBLEM FOR OVER A YEAR. AND NOW WHITE SMOKE BILLOWS OUT OF THE TAIL PIPE WHEN IT'S CRANKED. SECOND PROBLEM....ELECTRICAL. SOME OF THE STEERING WHEEL BUTTONS, SUCH AS CRUISE AND HANDS-FREE CALLING STOP WORKING OVER TIME. THIRD PROBLEM.... FRONT CV JOINTS WEAR OUT WAY TOO SOON. I HEARD OF A RECALL ON THE NEWS A COUPLE OF MONTHS AGO FOR MY CAR THAT SOUNDED LIKE MY ENGINE ISSUE, BUT NOW I CAN'T LOCATE THE RECALL ANYWHERE. THEY EVEN TOOK IT OFF OF THE NEWS CHANNEL'S WEBSITE. DURING THE BROADCAST, THEY SAID THE RECALL WOULD BEGIN DECEMBER 10TH. WHAT HAPPENED??? DID FORD CHANGE ITS MIND? SURE WOULD HELP ME OUT! I'M ENTERING THE OCCURRENCE DATE 1/1/17, BUT THIS HAS BEEN GOING ON WELL OVER ONE YEAR, MAYBE 2.

IF I CRANK THE CAR SOON AFTER CUTTING IT OFF, (WHILE IT'S STILL WARM) ENGINE SPUTTERS THEN QUITS, AS IF IT ISN'T GETTING ENOUGH FUEL. SO WHEN GETTING GAS, I HAVE TO HOLD DOWN THE GAS PEDAL OR ENGINE QUITS. AS SOON AS I START PUMPING, THE ENGINE STARTS CHOKING. I CAN'T TURN OFF THE IGNITION WHILE PUMPING GAS BECAUSE IT WON'T STAY CRANKED ONCE I TRY TO DRIVE AWAY UNLESS I REV THE RPM'S UP REALLY HIGH FOR A PERIOD OF TIME. I'VE HAD IT LOOKED AT SEVERAL TIMES AND NO ONE CAN FIGURE OUT WHAT'S WRONG. THIS HAS BEEN AN ONGOING PROBLEM FOR OVER A YEAR. AND NOW WHITE SMOKE BILLOWS OUT OF THE TAIL PIPE WHEN IT'S CRANKED. SECOND PROBLEM....ELECTRICAL. SOME OF THE STEERING WHEEL BUTTONS, SUCH AS CRUISE AND HANDS-FREE CALLING STOP WORKING OVER TIME. THIRD PROBLEM.... FRONT CV JOINTS WEAR OUT WAY TOO SOON. I HEARD OF A RECALL ON THE NEWS A COUPLE OF MONTHS AGO FOR MY CAR THAT SOUNDED LIKE MY ENGINE ISSUE, BUT NOW I CAN'T LOCATE THE RECALL ANYWHERE. THEY EVEN TOOK IT OFF OF THE NEWS CHANNEL'S WEBSITE. DURING THE BROADCAST, THEY SAID THE RECALL WOULD BEGIN DECEMBER 10TH. WHAT HAPPENED??? DID FORD CHANGE ITS MIND? SURE WOULD HELP ME OUT! I'M ENTERING THE OCCURRENCE DATE 1/1/17, BUT THIS HAS BEEN GOING ON WELL OVER ONE YEAR, MAYBE 2.

VEHICLE LOST ALL POWER AND DID NOT ALLOW ACCESS TO VEHICLE BY OWNER. EVENTUALLY, OWNER WAS ABLE TO GAIN ACCESS. VEHICLE TOWED TO DEALERSHIP, WHERE VEHICLE DIAGNOSED WITH A "DEAD" BATTERY. SEVEN DAYS LATER BLUE CHARGING RING CONTINUOUSLY BLINKED CREATING ISSUES WITH OTHER VEHICLES AND INDIVIDUALS AND CENTER ELECTRONIC WENT BLANK ELIMINATING BACK UP CAMERA AND SYSTEM CONTROLS AND REMAINED BLANK FOR SEVERAL MINUTES AND WOULD FLICKER BACK ON (THIS OCCURRED MORE THAN ONCE.). AGAIN TAKEN TO DEALERSHIP, CHARGING PORT AND CABLE REPLACED. NEXT MORNING VEHICLE SHOWED A "WRENCH" WARNING SIGN WHICH INDICATES A "POWER TRAIN" ISSUE AND VEHICLE WOULD NOT ENGAGE IN GEAR. AFTER FOUR ATTEMPTS, VEHICLE ENGAGED IN GEAR AND VEHICLE WAS TAKEN BACK TO DEALERSHIP. VEHICLE HAS BEEN IN DEALERSHIP SERVICE DEPARTMENT FOR OVER 64 DAYS AWAITING ELECTRICAL COMPONENTS FROM EUROPE. *TR

TL* THE CONTACT OWNS A 2015 FORD FUSION ENERGI. WHILE THE VEHICLE WAS CHARGING, THE PLUG MELTED INTO THE WALL AT THE CONTACT'S HOME. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 18V592000 (EQUIPMENT). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO WEST HILLS FORD (1100 OYSTER BAY AVE S, BREMERTON, WA 98312) AND THEY STATED THAT THE PART WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.