2020 Ford Fusion Brakes Problems

When these problems started it was only 6 months after purchase and I was already having issues with power train malfunctions and it didnt want to switch gears. I purchased this at roughly 47,000 miles and it didnt make it to 70,000 miles before I ultimately decided it was not the safe vehicle that was advertised to my family and I. It was taken to the dealership over 3 times in under a year and for some reason the problem never got resolved. I have been sued for the remaining balance now despite that toward the end of my time owning it the vehicle was reving out with barely any pressure on the gas pedal, having issues braking on its own (anti-collision assist), and occasionally the steering wheel would jerk me in to oncoming traffic. I am just trying to get a recall issued at this point because this car is going to kill someone if it stays on the road.

NHTSA ID

11705924

Incident

Jan 19, 2025

Speed sensor radar on right front tire sending alerts to car all at once — Antilock Brake Fault, Pre Collision Assist not available, Hill start assist. Steering wheel gets heavy randomly. And brakes start slipping. This is a safety hazard I have a baby. My car is only 5 years old problems like this shouldn’t be happening. Ford checked it and said it’s a speed sensor but would cost $450 that’s not a fair deal. And those sensors shouldn’t show all at once randomly. I barely drive my car. I have 57,000 miles on it. Happens randomly.

NHTSA ID

11687799

Incident

Aug 29, 2025

Tire Pressure Monitor System Warning Action Now Issue Since 09-22-2024 The tire pressure monitoring system has detected one or more tires are significantly under-inflated. Suggested Actions: Check the tire pressure to ensure the tires are properly inflated. WARNING: The tire pressure monitoring system is NOT a substitute for manually checking tire pressure. The tire pressure should be checked periodically (at least monthly) using a tire gauge. See Inflating Your Tires in the Wheels and Tires chapter of your Owner's Guide. Failure to properly maintain your tire pressure could increase the risk of tire failure, loss of control, vehicle rollover and personal injury.

NHTSA ID

11674798

Incident

Sep 24, 2024

Hard shifting when accelerating/decerating, jerking of the car due to transmission issues (80k miles), ABS/Braking issues due to engine components not being in sync, etc

NHTSA ID

11638449

Incident

Jan 25, 2025

2020 Fusion Compressor one, delivered from factory went out-repaired Compressor 2 just went out Needs 3rd compressor now in 3 years or 38,000-Pending I was very concerned each time the compressor went out (x2) I was on the highway when it ceased up and I lost the ability to effectively control the vehicle. I was put in an unsafe position with the ceasing up and with excessive heat buildup with smelling burning. This was very scary and was unsafe and this part should be investigated for potential to cause harm and injury to those in the car should it happen to anyone else. Limited control of car, notice no more Belt as well after i was able to stop. It appaired to in tiny pieces as small as bee bees all over the car. Not even recognizable as a belt. This has happed 2 times (this is not normal in 38,000 miles, having very limited control of car and breaking and steering and no power with smell of fire/burning.

NHTSA ID

11531801

Incident

Jun 21, 2023

CONSTITUENT WRITES REGARDING AN ISSUE WITH THEIR BRAKES ON THEIR 2020 FORD FUSION.

NHTSA ID

11520452

Incident

May 4, 2023

Brake fluid completely empty?

NHTSA ID

11506116

Incident

Feb 7, 2023

The contact owns a 2020 Ford Fusion. The contact stated that while driving and attempting to make a right turn, the parking brake activated causing the vehicle to abruptly stop. The contact was turned off and then restarted the vehicle. Approximately 3 miles later while driving, the failure reoccurred. The odometer lights began flickering, the gear shift indicator (PRNDL) light started to change, the location of the gear shifter started to switch gears, and the radio malfunctioned. The shift sensor malfunction and fault warning lights were illuminated. The failure occurred a total of 5 times. The contact took the vehicle to a certified mechanic who reset the vehicle to remove of all the codes however, the failure reoccurred. The contact scheduled an appointment with the dealer however, the vehicle had not yet been diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 38,750.

NHTSA ID

11490801

Incident

Oct 11, 2022

Mileage

38,750 mi

I WAS BACKING OUT OF MY DRIVEWAY AND MY BRAKE PEDAL WENT TO THE FLOOR. I COULD NOT STOP AND HIT A VEHICLE BRHIND ME.

NHTSA ID

11487834

Incident

Oct 3, 2022

The contact owns a 2020 Ford Fusion. The contact stated that their husband was coming to a stop light at approximately 5 mph, he attempted to stop the vehicle by depressing the brake pedal but the vehicle failed to respond. In order to avoid a crash, the driver veered to the right where they went over a curb, into a bush, and eventually came to a stop by crashing into a guard wire. The driver then drove the vehicle in a parking lot nearby and when attempting to stop the vehicle again, the vehicle failed to stop again. The driver had to place the vehicle in neutral and shut it off. There were no injuries reported. A police report was not filed. The contact took the vehicle to the dealer but the diagnosis was unknown. The vehicle had not been repaired as of yet. The manufacturer was made aware of the failure and opened a case and referred them to the NHTSA Hotline. The approximate failure mileage was unknown.

NHTSA ID

11470252

Incident

Jun 16, 2022