2006 Ford Mustang GT Engine Problems

THE ELECTRONIC THROTTLE BODY AND ELECTRONIC THROTTLE SENSOR WERE SENDING MY CAR INTO "LIMP MODE", AND VERY NEARLY CAUSED TWO ACCIDENTS BEFORE I COULD HAVE THE ISSUE DIAGNOSED AND REPAIRED. THE FIRST INSTANCE OF "LIMP MODE" CAME WHILE I WAS DRIVING HOME ON THE FREEWAY IN COMMUTE TRAFFIC. IT WAS WARM, TRAFFIC WAS ERRATIC STOP-AND-GO, AND I HAD THE AC ON. AFTER A PERIOD OF COASTING AT IDLE, TRAFFIC OPENED UP; BUT WHEN I TRIED TO ACCELERATE THE CAR STAGGERED AND NEARLY STALLED. I THOUGHT IT WAS DUE TO HEAT AND THE AC. THE CAR THEN JERKED FORWARD BEFORE RUNNING SMOOTHLY AGAIN. THE SECOND TIME, I WAS ON MY WAY TO WORK, AGAIN IN FREEWAY COMMUTE TRAFFIC. TRAFFIC WAS AT A STOP FOR SEVERAL MINUTES, AND THEN I HEARD A NEWS REPORT THAT THERE WERE ACCIDENTS AHEAD. I MOVED OVER TO THE 4TH LANE OF 5, IN PREPARATION FOR EXITING AT THE NEXT OFF RAMP. WHEN I TRIED TO PULL OUT AND SPEED UP INTO THAT LANE, THE CAR AGAIN STAGGERED AND THEN STALLED; I MANAGED TO RE-START IT AND GET MOVING AGAIN AS A TRUCK CAME RACING TOWARDS ME, WITH THE DRIVER HITTING HIS BRAKES AND HORN. I BARELY AVOIDED A CRASH.

NHTSA ID

11133476

Incident

Dec 5, 2016

Mileage

70,000 mi

THE ENGINE SHUTS OFF WHILE DRIVING AFTER IT HEATS UP. THIS HAS HAPPENED SEVERAL TIMES IN THESE LAST COUPLE OF MONTHS AFTER PURCHASING THE USED VEHICLE. I TOOK IT TO THE DEALERSHIP TO FIX. THEY REPLACED O2 SENSORS AND I GOT IT BACK LAST NIGHT AND TODAY I WAS DRIVING ON THE FREEWAY WHEN THE CAR JUST SHUT OFF ON ME AGAIN AND THE RPMS DROPPED TO ZERO. I WAS ABLE TO PULL THE CAR OFF TO THE SIDE SAFELY. I PUT THE CAR IN PARK AND RESTARTED IT. I DROVE FOR ABOUT A MINUTE OR TWO AND IT SHUT OFF AGAIN, SO AGAIN I PULLED OVER AND RESTARTED THE CAR. THIS HAPPENED ABOUT THREE OR FOUR TIMES BEFORE I WAS ABLE TO REACH MY FINAL DESTINATION.

NHTSA ID

10908952

Incident

Sep 23, 2016

Mileage

134,000 mi

DRIVING HOME FORM A TRIP I STARTED HEARING A SLAPPING/TICKING NOISE FORM UNDER THE HOOD. INVESTIGATED THE PROBLEM AND SEEMS TO BE COMING FORM TIMING CHAIN COVER/ VALVE COVER AREA ON PASSENGER SIDE. AFTER DOING RESEARCH ON THIS MATTER AND A MECHANIC VISIT IT IS A TIMING CHAIN GUIDE/TENSIONER. ITS A COSTLY REPAIR AND SEEMS TO BE A COMMON PROBLEM ON 05-09 MUSTANGS FORM INTERNET RESEARCH. THEY USE THE TIMING CHAIN CAUSE THEY SHOULD LAST THE LIFE OF THE CAR, CAUSE THEY WONT BREAK. I THINK THE GUIDES SHOULD ALSO LAST, BUT THEY ARE MADE OF PLASTIC AND CAN BREAK AT ANYTIME. I THINK THIS IS A PLOY BY FORD OR A DEFECT THAT NEEDS TO BE ADDRESSED AS PLASTIC CONTAINED INSIDE OF A MAJOR CAR PART THAT CAN BREAK EASILY, MAY CAUSE CHAIN TO SLIP OFF AND SHUT OFF ENGINE CAUSING BLOWN ENGINE, OR WORSE WHILE ON HIGHWAY CAUSING AN ACCIDENT. THEY SHOULD BE REPLACED BY STAINLESS OR ALUMINUM FOR STRENGTH AND BETTER SUPPORT. *TR

NHTSA ID

10523603

Incident

Apr 19, 2013

Mileage

55,000 mi

ON AUGUST 13, 2013 AT 1:45PM WHILE DRIVING TO A CAR DEALERSHIP IN ELGIN, IL, MY WIFE AND I WERE DRIVING NORTH ON RT59 WHICH IS A 45 MPH ZONE. MY PRESSED THE ACCELERATOR PEDAL AND THE CAR STARTED TO SPUTTER AND HESITATE. SHE PRESSED THE PEDAL A LITTLE MORE AND THE CAR JUST TOOK OFF BY ITS SELF. BEFORE WE KNEW IT, WE WERE TRAVELING AT 70 MPH THOUGH A LARGE POPULATION AREA. MY WIFE WAS TERRIFIED AND TRIED PRESSING THE BRAKES TO THE FLOOR BUT THEY ONLY SLOWED THE CAR A LITTLE. I TOLD MY WIFE TO TAP THE ACCELERATOR PEDAL TO SEE IF THE SPEED WOULD REDUCE. IT ONLY INCREASED IN SPEED. I TOLD MY WIFE TO TAP THE PEDAL AGAIN. THE CAR DID NOT SLOW AND SHE WAS STILL UNABLE TO SLOW THE CAR WITH THE BRAKES. I TOLD MY WIFE TO PRESS THE PEDAL HARDER. THE CAR LURCHED FORWARD AND THEN BEGAN TO SLOW DOWN. MY TOLD ME LAST YEAR THAT WHILE SHE WAS DRIVING THE CAR THAT IT DID THE EXACTED SAME THING, BUT I DIDN'T UNDERSTAND WHAT SHE WAS TALKING ABOUT UNTIL I EXPERIENCED IT MYSELF. MY WIFE WAS TERRIFIED AND IT SCARED THE [XXX] OUT OF ME AS WELL. THE CAR IS SHOWING NO CHECK ENGINE LIGHTS OR SERVICE ENGINE SOON LIGHTS. THIS MALFUNCTION COULD COST SOMEONE THEIR LIFE AND NEEDS TO BE ADDRESSED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

NHTSA ID

10503056

Incident

Mar 13, 2013

Mileage

85,108 mi

AFTER CHANGING THE BATTERY ON MY 2006 FORD MUSTANG GT WITH 5 SPEED MANUAL TRANSMISSION IT IDLES VERY ROUGH AND SOMETIMES DIES DURING DRIVING OR IDLES SO LOW THE POWER STEERING IS NOT FULLY FUNCTIONAL RESULTING IN EXCESSIVE STEERING EFFORT. THE CAR RAN FINE UNTIL THE BATTERY WAS REPLACED. I FOLLOWED THE RELEARN PROCEDURE IN THE OWNERS MANUAL BUT IT DID NOT HELP. *TR

NHTSA ID

10369024

Incident

Oct 15, 2010

Mileage

40,000 mi

VEHICLE HAS INTERMITTENT HESITATION PROBLEM. COULD RESULT IN SERIOUS PROBLEM WHEN ENTERING PARKWAY. DEALERSHIP IS PRIVY TO THIS COMPLAINT, BUT SAY THEY CAN'T DO ANYTHING UNLESS THEY CREATE THE PROBLEM WHICH CAN'T BE DONE UNLESS VEHICLE IS DRIVEN ON PARKWAY FOR 1-2 HRS. THOUGH THIS PROBLEM HAS OCCURRED LOCALLY ITS NOT LIKELY THAT TECHNICIAN WILL BE ABLE TO RE-CREATE THIS DRIVING LOCALLY. THIS PROBLEM CAN BE A DANGEROUS ONE IF NOT REPAIRED. FORDS TSB RECOGNIZES WHAT'S CAUSING PROBLEM AND I HAVE THE SOLUTION FOR IT. BUT ONCE AGAIN, DEALER SAYS THEIR HANDS ARE TIED. *TR

NHTSA ID

10237333

Incident

Jun 18, 2007

Mileage

6,000 mi

#1 - THERE ARE NO IDENTIFIABLE EVENTS THAT EITHER ORIGINALLY, OR SUBSEQUENTLY LEAD UP TO THE FAILURE(S). #2 - THE 'FAILURE' IS ON-GOING, AND INTERMITTENT IN NATURE, WITH THE CAR STALLING RANDOMLY, NOT RESPONDING TO THE GAS PEDAL AND THEN SURGING FORWARD A FEW SECONDS LATER AND EXHIBITING LAG TIME WHEN SHIFTING. WE HAD SEVERAL EPISODES OF STALLING WHEN GOING THROUGH AN INTERSECTION WHICH HAS PUT US IN 'THE LINE OF FIRE' WITH ON-COMING TRAFFIC. WE HAVE ALSO EXPERIENCED COMPLETE SHUT-DOWN OF THE VEHICLE WHEN JUST GOING DOWN THE ROAD. #3 - THE CAR HAS BEEN IN AND OUT OF THE SHOP FOR OVER TWO YEARS, WITH PERIODS EXPERIENCING O.K. PERFORMANCE, AND THESE INTERMITTENT ISSUES. *TR

NHTSA ID

10232021

Incident

Jun 15, 2008

AT 19,000 MILES MY CAR BEGAN OVERHEATING DURING THE TEST DRIVE AND HAD RADIATOR FLUID SPILLED IN THE ENGINE COMPARTMENT. INSPECTING THE UPPER RADIATOR HOSES ONE OF THE CLAMPS WAS BROKEN. WHILE REPLACING THE CLAMP I DISCOVERED THAT ANOTHER ONE WAS BROKEN AS WELL. A SEARCH ONLINE OF COMPLAINTS ABOUT THIS PROBLEM REVEALED SIMILAR COMPLAINTS. I NO LONGER HAVE THE OLD CLAMPS. *TR

NHTSA ID

10218827

Incident

May 15, 2007

Mileage

19,000 mi

MY 2006 MUSTANG GT HAS BEEN IN THE SERVICE DEPARTMENT THREE TIMES WITHIN 2 MONTHS TIME. WHEN YOU MAKE A LEFT OR RIGHT TURN THERE IS A GRINDING SOUND. THEY HAVE INSTALLED 2 CLUTCH PACKS (KIT-AXLE DIF, 3 GEAR AND PINIONS, AND A NEW FLANGE. I KNOW IT IS NOT THE WAY THE VEHICLE IS DRIVEN. IT WAS BOUGHT NEW IN MARCH 2006 AND IT ONLY HAS 7000 MILES ON IT AND THIS IS FEBRUARY 2007. THE CAR IS NOT "BEAT" AT ALL. IF THESE VEHICLES ARE SUPPOSED TO BE HIGH PERFORMANCE VEHICLES. COULD YOU IMAGINE WHAT WOULD HAPPEN IF THE "REAR END" WAS TO LOCK UP? AM I THE ONLY ONE HAVING THIS PROBLEM? ALSO THERE IS A TICKING SOUND THAT SOUNDS LIKE THE VALVES ARE RATTLING, THERE IS A TSB ON THE VALVES BUT DEALERSHIP SAYS THAT IS NOT THE PROBLEM. I ONLY USE BP AND AMOCO GAS, THE GAS THAT IS PREFERRED FOR THE VEHICLE. *NM

NHTSA ID

10182275

Incident

Jan 26, 2007

Mileage

4,400 mi

OUR FORD MUSTANG GT THAT WAS PURCHASED FOR OUR 17 YR OLD DAUGHTER WAS PURCHASED 2-21-2006 IT HAD ITS FIRST PROBLEMS AT 629 MILES ON 3-4-2006 THE DEALERSHIP REPLACED SOME FOLLOWERS AND SOME LIFTERS AND SOME CAMSHAFT PARTS. WE'VE BEEN TOLD ALL SHOULD BE REPLACED THE WHOLE BANK. DEALER WON'T DO ANYTHING ABOUT IT CAR STARTED SMOKING A WEEK LATER AND MAKING TICKING NOISE AGAIN. DEALER SAID IT DIDN'T DO IT THERE SO NOTHING WAS DONE. NEXT, CAR STARTED HESITATING AFTER DRIVING ON HWY COUPLE HRS. DEALERSHIP REPLACED FUEL PUMP AND GEAR BOX WAS HOT AND RATTLING SO THEY REPLACED IT. THEN CAR ACCELERATED ON ITS OWN FROM 50 TO 90 MILES HR. DEALERSHIP COULDN'T FIND ANYTHING THAT WAS AT 8300 MILES NOW AT 9700 MILES CAR HAS TAKING OFF AGAIN FROM 40 TO 80 WHEN OUR DAUGHTER PUT IT IN NEUTRAL AND COAST TO SIDE OF ROAD OUR DAUGHTER AND HER FRIENDS ARE TO AFRAID TO DRIVE IT NOW AND ITS BEEN AT DEALERSHIP FOR 2 FULL WEEKS ALSO THE PAINT ON THE PASSENGER REAR FENDER IS BUBBLING OFF THE CAR. SOMEONE IS GOING TO GET HURT, PROBABLY ALREADY HAVE DIED BUT KNOW ONE HAS CHECKED INTO IT. SORRY ABOUT WORDING YOU ONLY GET 2000 WORDS TO DESCRIBE EVERYTHING. LIKE YOU REALLY WANT TO KNOW IF YOUR RESTRICTING THE AMOUNT OF WORDS. *JB

NHTSA ID

10167713

Incident

Mar 4, 2006

Mileage

629 mi