2001 Ford Ranger EV Owner Complaints

THE "PLASTIC" WHICH COVERS THE TWO "SPEED CONTROL SWITCHES," LOCATED ON EACH SIDE OF STEERING WHEEL, BADLY MELTED OVER TIME - APPARENTLY FROM HEAT OF THE LAMPS UNDER THE COVERS. IT HAS MADE ME AFRAID TO ATTEMPT TO USE THE SPEED CONTROLS FOR FEAR OF FURTHER HEAT PROBLEMS AND/OR IMPROPER FUNCTIONING OF THE DAMAGED CONTROLS. PHOTOS OF THE DAMAGED PARTS ARE ATTACHED. I HAVE CONTACTED FORD CUSTOMER SERVICE WITH THESE COMPLAINTS AND PHOTOS AND ALL I GOT WAS A "THANKS" FOR MAKING THIS KNOWN TO THEM - NOTHING MORE.

NHTSA ID

11193434

Incident

Feb 25, 2014

Mileage

45,000 mi

THIS 2001 FORD RANGER TRUCK'S BODY AND INTERIOR ARE PERFECT. THE FRAME IS TOTALLY RUSTED AND NO ONE WANTS TO PASS IT FOR INSPECTION BECAUSE OF THE UNSAFE CONDITION OF THE FRAME. I FEEL THAT I SHOULD BE COMPENSATED BY FORD MOTOR COMPANY. THE TRUCK HAS 103,000 HIGHWAY MILES AND IS MECHANICALLY PERFECT. I FEEL THAT FORD MOTOR COMPANY SHOULD EITHER REPLACE THE ENTIRE FRAME OF THE TRUCK OR BUY IT BACK FROM ME. THIS TRUCK WAS MY SECOND VEHICLE AND I NEED SOMETHING DONE WITH IT.

NHTSA ID

10872712

Incident

Apr 22, 2014

Mileage

103,000 mi

TL* THE CONTACT OWNS A 2001 FORD RANGER EV. WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVER SIDE SEAT BELT BUCKLE WOULD ERRONEOUSLY UNLOCK. THE FAILURE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 01V227001 (SEAT BELTS). THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 80,000.

NHTSA ID

10837229

Incident

Feb 1, 2016

Mileage

80,000 mi

RUSTED FRAME ON 01 4X4 RANGER . RUSTED REAR SPRING HANGERS& BRACKETS. RUSTED TAIL END OF LEFT & RIGHT FRAME . RUSTED TOP SECTION OF FUEL FILLER TUBE. RUSTED CROSS MEMBER BEHIND CAB. HAD TO REPLACE REAR BRAKE DRUM THAT RUSTED INTO (2) TWO PIECES. BOTTOM OF TRUCK BOX HAS BAD RUST HOLES. ONE AUTO TRANSMISSION FLUID LINE RUSTED IN 2 INCH AREA JUST BEFORE RADIATOR INLET. LEFT SIDE OF FRAME IS ALMOST RUSTED TO MUCH TO SAFELY USE TK. *TR

NHTSA ID

10436654

Incident

Nov 21, 2011

TL*THE CONTACT OWNS A 2001 FORD RANGER EV. WHILE DRIVING 25 MPH, THE OVERDRIVE LIGHT BEGAN BLINKING, BUT THE VEHICLE CONTINUED TO DRIVE AT A NORMAL EXPECTANCY. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP AND INSPECTED BY A TECHNICIAN, WHO DETERMINED THAT THE VALVE BODY TSB MODIFICATION AND SHIFT SOLENOID FAILED. THE VEHICLE WAS REPAIRED AT THE COST OF $612.38. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT THE FAILURE WAS NOT UNDER RECALL; THEREFORE, NO COMPENSATION WOULD BE PROVIDED. THE FAILURE MILEAGE WAS 55,000 AND CURRENT MILEAGE WAS 57,980.

NHTSA ID

10261558

Incident

Nov 15, 2008

Mileage

55,000 mi

I PURCHASED THIS MANUAL TRANSMISSION TRUCK FROM A ONE-TIME OWNER THROUGH A DEALERSHIP ON JULY 23, 2005 WITH 30,000 MILES. ON AUGUST 29, 2005, THIS VEHICLE FAILED TO START AS I TRIED TO TURN THE KEY SEVERAL TIMES. I HAD TO HAVE FRIENDS GIVE THE TRUCK A PUSH TO START. THIS DID GET THE TRUCK TO START, AND IT RAN FOR ABOUT 5 MILES BEFORE DECELERATING AND STOPPING COMPLETELY. NOW, NOT EVEN WITH A PUSH FROM OTHERS WILL THIS TRUCK START. AS A CONSEQUENCE, THE TRUCK HAS FAILED TO START. I PLAN TO TOW THE TRUCK TO THE DEALERSHIP ON AUGUST 31ST TO GET IT CHECKED OUT UNDER WARRANTY. *JB

NHTSA ID

10134828

Incident

Aug 29, 2005

Mileage

31,295 mi

DT: CONTACT OWNS A 2001 FORD RANGER EDGE. HE BOUGHT IT NEW IN 8-2001. THE NEXT WEEK HE STARTED HAVING PROBLEMS. IT WOULD CUT OFF WHILE DRIVING INTERSTATE. HE LET IT SIT FOR 30 MINUTES -1 HOUR, AND IT WOULD START AGAIN. THE FRONT DOORS STARTED TO COME OPEN UNEXPECTEDLY. THEN IT FINALLY JUST QUIT RUNNING AT 10,800 MILES. HE TOOK VEHICLE TO A DEALER APPROXIMATELY 52 TIMES. THEY WOULD NOT CREATE ANY PAPER WORK AT THE DEALERSHIP;. THEY WOULD NOT MAKE A SERVICE ORDER ON THE TRUCK. FORD FINALLY AGREED TO LET AN AREA ENGINEER MEET WITH HIM AND LOOK AT THE TRUCK. THEY AGREED TO FIX THE TRUCK. HE MADE AN APPOINTMENT TO HAVE THESE ISSUES RESOLVED. THE DAY HE MADE THIS APPOINTMENT IS THE DAY THAT THE DEALERSHIP GAVE HIM A MEMO STATING THAT FORD WOULD NOT WARRANTY THE TRUCK UNLESS THE CONSUMER SIGNED A DOCUMENT SAYING THAT HE WOULD PAY FOR THE REPAIR WORK. OTHERWISE, DEALER WOULD NOT WORK ON IT. HE TOOK IT TO FOUR DIFFERENT BODY SHOPS TO FIND OUT WHAT WAS WRONG WITH THE TRUCK. THEY TOLD HIM THE CAB WAS TWISTED SO BADLY THAT WAS WHY THE DOORS WERE FLYING OPEN. THE MANAGER OF THE FORD DEALERSHIP WHERE HE PURCHASED THE CAR ADMITTED FORD DROPPED IT FROM A TRAIN CAR AND REPLACED THE HOOD AT THE FACTORY, AND SENT IT TO RUSTY WALLACE TO LIQUIDATE. HE HAS LETTER FROM THE WARRANTY DEPARTMENT STATING THE WARRANTY WAS CUT OFF AT THE REGIONAL LEVEL.*AK

NHTSA ID

10133720

Incident

Aug 22, 2005

Mileage

75 mi

DRIVER'S SIDE SEAT BELT BROKE. TAKEN TO REPAIR SHOP AND THE PULLEY IS COMPLETELY BROKEN. *NM

NHTSA ID

10131901

Incident

Aug 1, 2005

Mileage

60,258 mi

ON FEBRUARY 11, 2005 MY FATHER WAS DRIVING HIS 2001 FORD RANGER WHEN HE SUFFERED A HEART ATTACK. AS A RESULT OF THE HEART ATTACK MY DAD HIT A TREE HEAD ON WITH THE FORD RANGER. THE TRUCK SUFFERED CATASTROPHIC FRONTAL DAMAGE WHICH ULTIMATELY WAS CONSIDERED A TOTAL LOSS BY MY DAD'S INSURANCE COMPANY. DESPITE THE EXTENT OF THE DAMAGE, THE AIRBAGS DID NOT DEPLOY. MY DAD NEVER REVIVED AND WAS PRONOUNCED DEAD APPROXIMATELY ONE HOUR LATER AT THE LOCAL HOSPITAL. *JB

NHTSA ID

10115977

Incident

Feb 11, 2005

Mileage

53,955 mi

I WAS INVOLVED IN A RECENT ACCIDENT WHERE I WAS HIT IN MY 2001 FORD RANGER WHILE STOPPED AT AN INTERSECTION. MY VEHICLE WAS SLAMMED INTO FROM THE BACK BY AN SUV AND KNOCKED INTO A SMALL TOYOTA TRUCK IN FRONT OF ME WHO WAS ALSO STOPPED AT THE IINTESECTION. MY TRUCK WAS TOTALED WITH THE TRUCK BED LOOKING LIKE AN INVERTED V WITH FRONT BUMPER AND HOOD DAMAGE AND A FLUID LEAK. NEITHER THE DRIVER OF PASSENGER SIDE AIRBAGS DEPLOYED EVEN AFTER BEING HIT THAT HARD FROM BOTH FRONT AND BACK.*AK

NHTSA ID

10088413

Incident

Aug 16, 2004

Mileage

36,500 mi

CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE GAS INTAKE. ALSO STATED THAT WAS INVOLVED IN A COLLISION WERE HE WAS HIT WHERE THE GAS INTAKE IS LOCATED AND STARTED LEAKING GAS. DEALER WAS NOT CONTACTED AT THE TIME OF THIS CALLED. TS

NHTSA ID

10001411

Incident

Dec 20, 2002

DOOR AJAR INDICATOR LIGHT STAYS ON. APPARENTLY THE DOOR SENSOR UNIT OR LOCATION IS FAULTY.

NHTSA ID

10000262

Incident

Aug 4, 2002

Mileage

26,000 mi