1992 Ford Ranger Problems

I HAVE A 1992 FORD RANGER THE PASSENGER SIDE SPRING TOWER MOUNT IS COMPLETELY RUSTED AND THE FRONT SHOCK AND SPRING HAVE DROPPED MAKING THE TRUCK UNSAFE TO DRIVE THE BRAKE LINE WAS SMASHED WHEN IT GAVE WAY. MY BOYFRIEND ALSO HAD A 1992 FORD RANGER THAT THIS HAPPENED TO CAUSING HIM TO WRECK AND TOTAL THE TRUCK SO WE HAD TO JUNK IT. I WISH I WOULD HAVE KNOWN IT WAS A COMMON THING FOR THE 1992'S ONLY ON THE PASSENGER SIDE. IT MUST BE PRETTY COMMON AS FORD HAS MADE A REPLACEMENT PART!!!! *TR

OVER THE COURSE OF ABOUT TWO DAYS, I NOTICED A SCRAPING NOISE COMING FROM THE RIGHT FRONT WHEEL. ON THE SECOND DAY, I NOTICED UPON APPROACHING THE TRUCK THAT THE RIGHT FRONT FENDER WAS ALMOST TOUCHING THE TIRE. REMOVING THE WHEEL, I DISCOVERED THAT THE UPPER SPRING SEAT HAD DETERIORATED TO THE POINT THAT THE COIL SPRING WAS THIRTY DEGREES FROM ITS ORIGINAL POSITION. THE SHEET METAL IN THE SEAT CRUMBLED IN MY HAND WHEN I TOOK HOLD OF IT, AND THE HOUSING WAS TORN 75% OF THE WAY THROUGH FROM FRONT TO BACK. AT HIGH SPEED, THIS VEHICLE WOULD HAVE BEEN A DEATH TRAP. I NOTE 15 SIMILAR COMPLAINTS IN YOUR DATABASE. LEFT SIDE SPRING SEAT IS PERFECT AND INTACT. *TR

WHILE DRIVING HOME FROM MY COAST GUARD DUTY MY TRUCK STARTED TO FILL WITH SMOKE. I PULLED OVER AND LOOKED IN MY DASH AGAINST THE STEERING COLUMN AND SAW FLAMES COMING OUT. IT WAS A TOTAL LOSS ENGULFING MY TRUCK IN FLAMES. *TR

DT*: THE CONTACT STATED WHILE DRIVING 5 MPH THROUGH AN ALLEYWAY, A FIRE ERUPTED FROM UNDERNEATH THE LEFT FRONT DRIVER SIDE DASH PANEL AREA WITHOUT WARNING. THE FIRE DEPARTMENT WAS ALERTED, AND EXTINGUISHED THE FIRE. THE VEHICLE SUSTAINED MODERATE FIRE DAMAGE; AN INSURANCE ADJUSTOR DEEMED THE VEHICLE TOTALED. THE POLICE WERE ALERTED, AND A REPORT WAS TAKEN. THE FIRE DEPARTMENT INSPECTED THE VEHICLE, AND DETERMINED THE FIRE WAS ELECTRICAL IN NATURE. THE MANUFACTURER WAS ALERTED.

TRUCK WAS WARMING UP WITH ME IN IT AROUND JANUARY. I WENT TO OPEN THE DOOR FROM THE INSIDE, THEIR WAS NO RESPONSE AND WAS STUCK IN TRUCK. EVENTUALLY, I WAS ABLE TO GET OUT OF THE REAR SLIDING WINDOW. I WAS AND AM NEVER ABLE TO USE MY PASSENGER DOOR AGAIN, FROM THE INSIDE OR OUTSIDE. *TR

WHILE DRIVING 35 MPH AND WITHOUT WARNING, EXTERIOR MIRRORS WILL FOLD IN, CONSUMER WOULD BE UNABLE TO VIEW OR USE THE MIRRORS.*AK *SLC

RIGHT FRONT UPPER SPRING SEAT BRACKET (PART NO. 5A318) HAS PREMATURELY RUSTED THROUGH ALLOWING BODY TO DROP ONTO FRONT TIRE. IT APPEARS AS THOUGH A THICK PLASTIC COATING ON THE PART ALLOWED MOISTURE TO BE TRAPPED CAUSING PREMATURE RUSTING. UPPER PART OF SPRING SEAT BRACKET PUSHED THROUGH FENDER LINER INTO ENGINE COMPARTMENT. IN VIEWING THE COMPLAINTS FOR THIS MODEL YEAR TRUCK THERE APPEAR TO BE NUMEROUS SIMILAR EVENTS ON THE APPARENT DEFECTIVE RIGHT FRONT UPPER SPRING SEAT BRACKET. *JB

DRIVER SIDE DOOR HANDLE SNAPPED OFF FROM THE INSIDE CABLE. WHILE OPENING THE DOOR TO THE VEHICLE. *AK

TL*THE CONTACT OWNS A 1992 FORD RANGER. THE VEHICLE HAS FUTURA GLS SUPER SPORT, SIZE P225/60R15 TIRES. THE FRONT DRIVER SIDE TIRE HAD TREAD SEPARATION. THE TIRE WAS ALSO BUBBLING, SPLITTING, AND HAD CRACKS ON THE SIDE. THE CONTACT STATED THAT THE TIRES BOUNCED AND SQUEAKED MORE WHILE DRIVING GREATER THAN 40 MPH. THE OTHER THREE TIRES ON THE VEHICLE WERE EXPERIENCING THE SAME FAILURE, BUT THE FRONT DRIVER SIDE TIRE WAS THE WORST. THE PURCHASE DATE WAS UNKNOWN. THE TIRE FAILURE MILEAGE WAS 15,000. THE VEHICLE CURRENT MILEAGE WAS 145,415 AND FAILURE MILEAGE WAS 142,415.

WHILE DRIVING AT 70MPH, MY REAR TIRE CAME APART AND TOTALLED THE BED OF MY TRUCK AND BROKE THE BRAKE LINE AND NEARLY CAUSED A ROLLOVER. THIS WAS THE FOURTH OF THE SET OF TIRES TO COME APART OR DEVELOP A BUBBLE.

OIL PRESSURE SUDDENLY WENT TO ZERO.ENGINE BEGAN TO CLATTER.I RETURNED HOME.

WHEN VEHICLE STARTED IN NEUTRAL, IT WAS PUT IN REVERSE AND THROTTLE WENT TO FLOOR WITHOUT ANYONE TOUCHING IT, VEHICLE TOOK OFF IN REVERSE , FRONT WHEEL HIT BUILDING BENDING AXLE AND OTHER COMPONENTS THIS HAPPENED ABOUT 30 DAYS PRIOR WITHOUT ANY DAMAGE. *TR

ABS COMPUTER FAILED AGAIN AFTER FORD DEALER REPLACED ORIGINAL. UPPER SHOCK/SPRING MOUNT COMPLETELY RUSTED AWAY CAUSING LOSS OF STEERING AND SUSPENSION. LOCAL DEALER REFUSED TO REVIEW FOR POSSIBLE MANUFATURERS DEFECTS. *AK

MAIN BRAKE LINE RUPTURED DUE TO RUBBING ON PARKING BRAKE CABLE, CAUSING COMPLETE BRAKE FAILURE. *AK

INSIDE DOOR HANDLE NO LONGER WORKS DUE TO A BROKEN CABLE LINKAGE DURING COLD WEATHER. FORD SAYS MY VIN IS NOT PART OF THE RECALL GROUP. OTHER PEOPLE THAT HAVE HAD THE RECALL PERFORMED HAVE HAD THE SAME PROBLEM OCCUR AGAIN. IF MY VEHICLE IS NOT PART OF THE RECALL GROUP IT WOULD MEAN THAT IT HAS THE UPDATED CABLE, YET THIS "UPDATED" CABLE ALSO HAS A HISTORY OF BREAKING. WHY NOT A RECALL ON THE UPDATED CABLE THAT WAS SUPPOSED TO FIX THE PROBLEM AND DIDN'T? *JB

I OWN 92 FORD RANGER. LAST THURSDAY,5/15/2003, WHILE DRIVING TO WORK I NOTICED MY PASSENGER SIDE FRONT LOWER THAN THE REST OF THE TRUCK. AFTER I PARKED AT WORK I INVESTIGATED AND NOTICED THAT THE SHOCK/SPRING TOWER WAS RUSTED SO BAD THAT IT WAS ALMOST READY TO FALL OFF. THE SPRING WAS BENT BACKWARDS AND THE SHOCK WAS BROKEN AT THE BOTTOM. AT THE FORD DEALER, THE MECHANIC SAID HE HAD NEVER SEEN ANYTHING LIKE THAT. HE ALSO TOLD ME THAT THEY ONLY MAKE THAT PART FOR THE RIGHT SIDE? THE LEFT SIDE LOOKS LIKE BRAND NEW. APPARENTLY ONLY THE RIGHT ( PASSENGER ) SIDE RUSTS OUT AND NOT THE LEFT. IT SEEMS THAT METAL IS INFERIOR AND CAN CAUSE A SERIOUS ACCIDENT. FORD MUST KNOW ABOUT THIS PROBLEM BECAUSE THEY ONLY MAKE THE PART FOR ONE SIDE AND NOT THE OTHER. I CAN'T FIND ANY RECALL INFO ON THIS. BESIDES THE $800.00 COST TO REPAIR, THIS CAN CAUSE A SERIOUS ACCIDENT. *NLM

THE PROBLEM WITH GETTING THE TRUCK TO GO INTO GEAR HAPPENS OFF AND ON. IT IS GETTING WORSE. IGNITION IS TO A POINT THAT I MUST JUMP START IT. I AM DISABLE TO THE POINT OF PUSHING THE TRUCK IN ORDER TO START IT.

TRANSMISSION MANUAL FAILED OUTPUT SHAFT AT 20 MPH REPLACED INTERNAL GEARS GAVE OUT AT 65 MPH.//ABS BRAKES BECAME SPONGY & LOCK IN REAR PULL TO RIGHT IN FRONT .//HEADLIGHTS BEGAN BLINKING OFF &ON AFTER 15 MINUTES OF DRIVING.//TRANSFER CASE SPLIT WHILE IN 2 WHEEL DRIVE AT 35 MPH.//FRONT SUSPENSION GIVING OUT CAN'T ALIGN FRONT END ,ERATIC STEERING & WORN TIRES.//REAR SPRINGS SLIPPED OUT ON LEFT SIDE AXLE SLID FORWARD TO BODY.//HEATER BEGAN RATTLIING ,MORE AS YOU TURN FAN UP.

JUST THIS PAST TWO WEEKS, WE TRADED TRUCKS. WE RECEIVED A 1992 FORD RANGER. DURING THE SMOG TEST IT WAS DISCOVERED THAT THE FUEL FILLER NECK WAS CRACKED AND REQUIRED REPLACEMENT. THE PART COST $241 , LABOR $175 WHICH WAS A COSTLY SMOG CHECK. WE HAVE FOUND OUT THAT THIS TYPE OF REPAIR IS VERY COMMON IN FORD RANGERS, ESPECIALLY THE OLDER ONES. THE FORD CO. HAS NOW REDESIGNED THE PART, AND THERE HAS BEEN NO RECALL OR OFFER OF HELP TO THE PEOPLE WHO HAVE THE POORLY DESIGNED FUEL FILLER NECK. YOU ASKED HOW OFTEN THIS OCCURS - QUITE OFTEN - THE TWO TIMES I WAS IN THE OFFICE OF THE REPAIR SHOP, I ENCOUNTERED 3 OTHER CUSTOMERS THAT WERE IN THERE FOR THE SAME REASON !! I WOULD SAY THAT IS TOO OFTEN. AND, I WOULD LIKE TO ASK THE FORD CO TO REPLACE THE POORLY DESIGNED FUEL FILLER NECKS AND PAY FOR THE LABOR INVOLVED. ADDITIONALLY, I THINK THAT THIS INFORMATION NEEDS TO BE MADE KNOWN TO THE PUBLIC, SO THAT THEY WILL NOT BE DRIVING AROUND WITH A POTENTIALLY HAZARDOUS FUEL VAPOR LEAK, AND THAT THEY CAN GET SOME FINANCIAL HELP WHEN IT IS TIME TO SMOG THEIR TRUCK AND THIS PROBLEM IS DISCOVERED. CAROLYN NEUMAN *TR

FUEL ODORS ARE INSIDE AND THE OUTSIDE OF THE VEHICLE. THE DEALER INSPECTED VEHICLE, AND DETERMINED THAT FUEL LINE NEEDED TO BE REPLACED. *AK THE CONSUMER FEELS THAT THIS IS A DESIGN FLAW. THE LEAK IS ACTIVE WHEN STOPPED, AND AFTER STOPPING, THE LEAK CONTINUES UNTIL THE PRESSURE IS RELIEVED ON THIS HIGH PRESSURE FUEL INJECTION LINE. THE LEAKS ARE LOCATED WHERE THE POWER STEERING HOSE RUBS AGAINST THE GAS LINES. *SCC

WHEN VEHICLE STARTED IN NEUTRAL, IT WAS PUT IN REVERSE AND THROTTLE WENT TO FLOOR WITHOUT ANYONE TOUCHING IT, VEHICLE TOOK OFF IN REVERSE , FRONT WHEEL HIT BUILDING BENDING AXLE AND OTHER COMPONENTS THIS HAPPENED ABOUT 30 DAYS PRIOR WITHOUT ANY DAMAGE. *TR

MY 1992 FORD RANGER SPONTANEOUSLY COMBUSTED ON THE MORNING OF JUNE 6, 2006. THE CRUISE CONTROL WENT OUT UNEXPECTEDLY AND WOULDN'T START. I LEFT IT OVERNIGHT AND RECEIVED A PHONE CALL FROM THE POLICE AT 5 A.M IN THE MORNING SAYING MY TRUCK WAS ON FIRE. APPARENTLY IT HAD CAUGHT FIRE (WHILE IT WAS OFF) AND COMPLETELY TOTALED THE ENTIRE VEHICLE, LEAVING ME AT A COMPLETE LOSS (INSURANCE DID NOT COVER THIS TYPE OF CLAIM). BEING A 19 YEAR OLD IN COLLEGE THIS CAME AS A COMPLETE NIGHTMARE FINANCIALLY. FORD HAS REFUSED TO DO ANYTHING ABOUT IT. I WILL NEVER DRIVE A FORD AGAIN. VEHICLE WAS TOWED TO A NEARBY JUNKYARD, WHERE THE BRAND NEW 1,000 CLUTCH AND NEW TIRES WERE REMOVED AND SOLD FOR SOMEONE ELSE'S PROFIT. I GOT NOTHING. *NM

TRANSMISSION MANUAL FAILED OUTPUT SHAFT AT 20 MPH REPLACED INTERNAL GEARS GAVE OUT AT 65 MPH.//ABS BRAKES BECAME SPONGY & LOCK IN REAR PULL TO RIGHT IN FRONT .//HEADLIGHTS BEGAN BLINKING OFF &ON AFTER 15 MINUTES OF DRIVING.//TRANSFER CASE SPLIT WHILE IN 2 WHEEL DRIVE AT 35 MPH.//FRONT SUSPENSION GIVING OUT CAN'T ALIGN FRONT END ,ERATIC STEERING & WORN TIRES.//REAR SPRINGS SLIPPED OUT ON LEFT SIDE AXLE SLID FORWARD TO BODY.//HEATER BEGAN RATTLIING ,MORE AS YOU TURN FAN UP.

WHILE TRAVELING HEADLIGHT'S WOULD FLICKER WITHOUT INDICATION INTERMITTENTLY, CAUSING POOR VISIBILITY. DEALER HAS BEEN CONTACTED. PLEASE PROVIDE FURTHER INFORMATION. *AK

TIE RODS ARE BENT. ALSO, VEHICLE IS OUT OF LINE, AND WILL NOT GO STRAIGHT ON ROAD. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

TRANSMISSION MANUAL FAILED OUTPUT SHAFT AT 20 MPH REPLACED INTERNAL GEARS GAVE OUT AT 65 MPH.//ABS BRAKES BECAME SPONGY & LOCK IN REAR PULL TO RIGHT IN FRONT .//HEADLIGHTS BEGAN BLINKING OFF &ON AFTER 15 MINUTES OF DRIVING.//TRANSFER CASE SPLIT WHILE IN 2 WHEEL DRIVE AT 35 MPH.//FRONT SUSPENSION GIVING OUT CAN'T ALIGN FRONT END ,ERATIC STEERING & WORN TIRES.//REAR SPRINGS SLIPPED OUT ON LEFT SIDE AXLE SLID FORWARD TO BODY.//HEATER BEGAN RATTLIING ,MORE AS YOU TURN FAN UP.

THE RIGHT FRONT WHEEL SEPARATED FROM THE VEHICLE. *JB

THE PASSENGER SIDE WHEEL WAS RUSTED. *JB

DURING VEHICLE COLLISION THE SHOULDER SEATBELT BROKE CAUSING INJURY TO CONSUMER DUE TO FASTNER FAILURE. *MJS

FRONTAL COLLISION IMPACT 12:00 POSITION, LOST CONTROL HIT A TREE, LAP/SHOULDER FAILED IN REAR SEATS SPEED 30 MPH. TT

WHILE DRIVING THE PASSENGER'S COMPARTMENT WAS FILLED WITH SMOKE. AIR CONDITIONER EVAPORATOR HOUSING HAD MELTED. DEALER HAS SEEN. *AK

THE RESISTOR MOUNTED ON THE AIR CONDITIONER HEATER CASE BOX OVERHEATED, CAUSING A SHORT WHICH STARTED A FIRE UNDER THE HOOD. THERE WAS DAMAGE TO THE EVAPORATOR CASE/BLOWER MOTOR ASSEMBLY AND THE CORE. VEHICLE IS BEING SERVICED AT THIS TIME. *AK

UNIVERSAL JOINT: CONSTANT VELOCITY FAILURE; ALSO ENGINE VALVE COVER/WATER PUMP LEAKS. *AK

A SMALL TOYOTA CAR WAS TRAVELING AT APPROXIMATELY 60 MPH AND IMPACTED DRIVERS SIDE OF CONSUMER'S VEHICLE, CAUSING VEHICLE TO ROLL TWO TIMES.FRONT END SUFFERED SEVERE DAMAGE, AND DRIVER'S FRONTAL AIR BAG FAILED TO DEPLOY. DRIVER SUFFERED LEG/ARM, AND NECK INJURIES AS WELL AS BROKEN RIBS. *AK