2000 Ford Ranger Problems

The contact owns a 2000 Ford Ranger equipped with Kenda Tire, tire line Kenetica, tire size P235/75/R15, and Dot Number K3DK. The contact stated he notice that tread separation from the rear passenger side tire. On another occasion the contact had a blowout on the front driver side where the tread separation. The front driver side tire was replaced with a used tired and the rear tire was not replaced. The manufacturer was not contact. The failure mileage 5,000 and 24,449.

NOT REALLY AN INCIDENT, MORE OF A COMPLAINT. WE BOUGHT A 2000 RANGER APPROXIMATELY A YEAR AGO. THE SPARE TIRE WAS MISSING AND WE FOUND OUT WHY. THE SPARE TIRE WINCH ASSEMBLY WAS A BLOCK OF RUST AND THE SHEET METAL THAT MADE UP THE HOLDER THAT THE CARRIER WAS ATTACHED TO IS SO SEVERELY ROTTED THAT IT COULD NOT POSSIBLY EVEN HOLD A TIRE. THE SHEET METAL MENTIONED IS A STRUCTURAL PART OF THE REAR FRAME AND IT HAS MAJOR ROT AND SHOULD PROBABLY BE REPLACED. MY SON NEEDED A SPARE TIRE SO SINCE THERE WAS NO HOLDER HE PUT IT IN THE BED. WHEN HE PUT IT IN THE BED IN BOUNCED TO THE RIGHT AND PUT A LARGE HOLE IN THE SIDE OF THE BED JUST BEHIND THE CAB. WE STARTED TO CHECK OUT THE REST OF THE BED ONLY TO FIND OUT THAT IT WAS SO RUSTED THAT IT WAS LITERALLY STATING TO CRUMBLE IN SPOTS. WHILE CHECKING IT OUT WE PUT SEVERAL MORE HOLES IN THE FLOOR OF THE BED AND THE SIDES JUST BY POKING AROUND WITH A SCREWDRIVER. THE BED IS A STEPSIDE AND THERE IS NO METAL LEFT UNDER THE STEPS AT ALL, IF YOU WERE TO STEP ON EITHER SIDE YOU WOULD CRACK THE FIBERGLASS SIDES. WE ARE NOW IN THE PROCESS OF HAVING TO REPLACE THE BED. ALL OF THE BOLTS HAD TO BE CUT OUT DUE TO THE RUST. ONCE WE GOT THE BED OFF WE WERE SHOCKED TO SEE THAT THE FRAME WAS COVERED TOP TO BOTTOM WITH RUST. I HAVE RESTORED OLDER TRUCKS IN THE PAST SOME FROM THE 40'S AND I HAVE NEVER ENCOUNTERED RUST LIKE I HAVE SEEN ON THIS ONE, IT ALMOST LOOKS LIKE THERE WAS NO PAINT ON IT FROM THE FACTORY AT ALL. WE ARE STILL IN THE PROCESS OF WIRE BRUSHING THE FRAME SO WE CAN SPRAY A RUST CONVERTER AND TRY TO REPAINT THE FRAME. I HAVE READ SEVERAL OTHER COMPLAINTS REGARDING THE RUST ON THESE TRUCKS AND FIRMLY BELIEVE THAT FORD SHOULD BE HELD ACCOUNTABLE JUST LIKE TOYOTA WAS WHEN THEY HAD A SIMILAR SITUATION INVOLVING RUSTED FRAMES ON THEIR TRUCKS. TRUST ME I AM A DIE HARD FORD FAN BUT I BOUGHT THIS FOR MY SON AND I AM VERY DISAPPOINTED. *TR

The contact owns a 2000 Ford Ranger. The contact stated that the entire subframe of the vehicle was corroded and was cracking and disintegrating. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 50,000.

The back end frame has completely rusted out, while the cab frame is in perfect condition. I have read about everyone that has a ranger from 1995-200 has had this issue. My truck only has 127k miles on it and has been kept in wonderful condition, and the bed frame has made it unsafe to drive.

TL* THE CONTACT OWNS A 2000 FORD RANGER. WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKE PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO SLOW DOWN. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND PARKED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE MASTER CYLINDER FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 42,000.

MY FRAME IS RUSTED OUT, 110,000, MILES, REPLACED TRANSMISSION, BRAKE LINES, GAS LINES, AND A # OF OTHER THINGS, DUE TO A RUSTED OUT UNDER CARRIAGE, THE MOTOR IS GREAT, THINGS ON THE FRAME ARE BREAKING OFF ALL THE TIME, SO MUCH RUST CANT EVEN SEE A BOLT.

THE FRAME RAILS AT THE REAR OF THE VEHICLE WHERE THE SHOCKS BOLT UP HAS COMPLETELY CRACKED THROUGH THE METAL ON PASSENGER SIDE & THE DRIVER SIDE HAS COMPLETELY RUSTED AWAY AND FRAME CRACKED

FRAME HAS RUSTED TO THE POINT WHERE IT IS UNSAFE TO DRIVE.

TL* THE CONTACT OWNS A 2000 FORD RANGER. WHILE DRIVING, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT CALLED PLANET FORD (20403 I-45, SPRING, TX 77388, (281) 719-3700) AND SCHEDULE A DIAGNOSTIC APPOINTMENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,900.

TANAKA RECALL - AIR BAG INDICATOR ON DASHBOARD STAYS ON FOR LONG PERIODS OF TIME INTERMITTENTLY

The contact owns a 2000 Ford Ranger. The contact stated after a short drive at approximately 30 MPH, the contact parked the vehicle at his residence. The contact heard a loud bang and observed through his residence window that the vehicle was on fire that was confined to the engine compartment. The flames eventually spread to the passenger cabin. The fire department was called. The fire was extinguished with chemicals. The fire marshal wrote a report and advised the contact that the fire could be related to a NHTSA Safety Campaign. The contact's vehicle shows one open recall associated with NHTSA Safety Campaign Number: 05V017000 (Vehicle Speed Control). The manufacturer had been informed of the failure. The failure mileage was approximately 200,000.

I LOOKED UP MY VIN ON THE NHTSA WEBSITE AND THERE ARE RECALLS THAT HAVE NOT BEEN FIXED.

I HAVE A 2000 FORD RANGER XLT EXTENDED CAB 4X4 I FIRST STARTED HAVING TROUBLE WITH THE ALTERNATOR IT JUST STOPPED WORKING, TOOK TO SHOP AND THE BRUSHES ON IT WAS WORE OUT HAD THE REPLACED AND IT LASTED 2 DAYS AND SAME PROBLEM SO HAD TO BUY A NEW ALTERNATOR AT 300.00 IT LASTED 4 DAYS TOOK IT BACK TO PARTS STORE GOT A REPLACEMENT AND IM STILL USING IT BUT IT STILL ISN'T WORKING AS GOOD AS IT SHOULD GOT STRANDED AT 1230 AM BESIDE ROAD WITH MY DAUGHTER WITH ME THE FIRST TIME, AND WHEN THAT HAPPENED THAT WHEN MY OD LIGHT STARTED FLASHING AND THE TRANSMISSION WOULDN'T SHIFT INTO THE RIGHT GEARS HAD TO MANUALLY SHIFT IT TO GET IT TO MOVE TOOK TO SHOP NOONE COULD FIND THE PROBLEM EVEN PUTTING IT ON THE COMPUTER NO CODES WAS FOUND ENDED UP GETTING STRANDED AGAIN WHEN TRAIN COMPLETELY QUIT PULLING HAD TOWED TO SHOP AND HAD TO BUY ANOTHER TRAIN AT 600.00 AND THAT IS 3 WEEKS PAY FOR US BUT ITS THE ONLY VEHICLE WE HAVE SO HAD TO GET IT FIXED LOOKED TO SEE IF ANY RECALLS HAVE BEEN ISSUED FOR THIS BUT NONE HAVE BUT HAVE SEEN MANY MANY COMPLAINTS I THINK FORD NEED TO LOOKING TO THIS PROBLEM SOON, IT COULD CAUSE AN ACCIDENT AND SOMEONE COULD GET SERIOUSLY HURT. THANKS HAVE READY EVERYONE'S ISSUES AND HAVE ALOT OF THE SAME WITH MY TRUCK. *TR

THIS IS A FOLLOW UP TO ODI #10217638. TRAVELING APPROX 60 MPH, TRUCK SEEMED TO LOSE UPPER TRANSMISSION GEAR, ENGINE LIGHT CAME ON AND COASTED UNTIL A HARD UPSHIFT . TOOK TRUCK TO DEALER ( OUT OF WARRANTY). WAITING TO HEAR BACK FROM DEALER. *TR

I LOOKED UP MY VIN ON THE NHTSA WEBSITE AND THERE ARE RECALLS THAT HAVE NOT BEEN FIXED.

TL* THE CONTACT OWNS A 2000 FORD RANGER. WHILE DRIVING AT 70 MPH, THE VEHICLE LOST ALL ACCELERATION WITHOUT WARNING. THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO RESPOND. THE SERVICE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE COULD BE RESTARTED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 72,000.

BOTH THE BACK SEAT SMALL DOORS WERE LOCKED AND UNOPERABLE SINCE 2015 (THE DEALER REFUSED TO REPAIR WITHOUT PAYING FOR SERVICE- THEY SAID WILL COST $1,000.00 FOR EACH DOOR AND JUST TO EXAM COST. THAT WAS NOT THE REPAIR COST YET) 2020 IN AUGUST, PERHAPS, THE BACK GATE DOOR FOR THE TRUNK SUDDENLY COLLAPSED, FELLED OUT FROM THE ROLLER. THAT WAS THE PASSENGER SIDE OF THE BACK GATE TO THE BED OF THE TRUCK I HAD TO PUT BACK TO THE ROLLER. AND, IT IS NOT SURE THAT THE GATE IS STABLE CONDITION. UNDER THE DASHBOARD, THE CIGARETTE LIGHTER JUST TOUCHED AND COLLAPSED-BROKEN INSIDE UNDER THE DASHBOARD AND COULD NOT PULL IT OUT. SO, IT IS STILL INSIDE UNDER THE DASHBOARD (NOTICE: THAT FEATURE-THE CIGARETTE LIGHTER NOBODY USED SINCE BOUGHT THE VEHICLE- NON SMOKER OWNER). THE UNDER BODY VEHICLE COST A LOT TO REPAIR THROUGH THE YEARS. THE VEHICLE HAS ABOUT 120,000 MILES CURRENTLY.

SPEED CONTROL ON WHEEL FAILED THROWING THE TRANSMISSION INTO FIRST GEAR, JUST LIKE THE RECENT RECALL ON NEWER FORD PICKUPS I WAS IN MOTION ON A CITY STREET GOING STRAIGHT.

STARTING FROM HOME, THE VEHICLE HAD NO INDICATION OF TROUBLE LIGHTS IN THE INSTRUMENT PANEL. THEN, DRIVING ABOUT 2 MILES AND UP THE BRIDGE, SUDDENLY THE VEHICLE SLOWLY CAME TO A STOP WITHIN QUICK TIME AND STALLED ON THE UPHILL DIRECTION. A FEW ATTEMPTS TO RESTART, I WAS NOT SUCCESSFUL. THE POLICE WAS CALLED AND CAME TO PUSH THE RANGER DOWN THE BRIDGE TO THE SAFETY AREA AND WAITING TWO HOURS LATER FOR THE TOW-TRUCK TO TOW TO THE FORD DEALER. AND, THE DIAGNOSIS WAS THAT THE FUEL PUMP IS OUT. THIS VEHICLE HAD HISTORIES OF REPAIR SINCE THE FIRST YEAR AND THEREAFTER . *TR

VEHICLE HAS SEVERE FRAME RUST. RECENTLY REAR BUMPER FELL OFF DUE TO FRAME DETERIORATION. BUMPER BRACKETS HAD NOTHING TO SECURE TO. MORE RECENTLY, ONE OF THE STRAPS HOLDING THE GAS TANK BROKE AWAY FROM THE FRAME DUE TO SEVERE DETERIORATION OF THE FRAME. I HAD TO IMPROVISE A RESTRAINT STRAP SINCE A REPLACEMENT WOULD DO NO GOOD SINCE THE FRAME CONNECTION AREA WAS ROTTED THRU. LEAF SPRING BRACKETS ARE ON THE VERGE OF SEPARATION FROM THE FRAME, AGAIN DUE TO SEVERE FRAME DETERIORATION. THE EXTERIOR BODY AND INTERIOR ARE IN GOOD CONDITION. FOR A 2000 VEHICLE TO HAVE THIS SERIOUS OF A FRAME PROBLEM HAS TO BE THE RESULT FOR POOR MATERIAL AND/OR MATERIAL RUST PROOFING. FOUND NUMEROUS COMPLAINTS BY OTHER 2000 RANGER OWNERS FOR SIMILAR ISSUES. *TR

THE STEERING COLUMN IS LOOSE. SOMETIMES HAVE TO MOVE AROUND BIT TO GET INTO PARK OR DRIVE. THE OTHER DAY I HAD IT IN PARK, WITH THE TRUCK RUNNING AND AFTER I WAS OUT OF IT, IT STARTED MOVING. I HAD TO RUN AROUND AND GET BACK IN TO STOP IT. LUCKILY HAD THE DOOR OPEN. NO MORE LEAVING IT RUNNING WHEN NOT IN THE TRUCK.

TL*THE CONTACT OWNS A 2000 FORD RANGER. WHILE DRIVING 55 MPH SHE HEARD A LOUD CLICKING NOISE COMING FROM THE STEERING COLUMN. THE DEALER STATED THAT THE STEERING RACK NEEDED TO BE REPLACED. THE DEALER MADE THE REPAIR AND THERE HAVE BEEN NO OTHER OCCURRENCES. THEY RECOMMENDED THAT THE CONTACT DRIVE THE VEHICLE TWENTY MILES THEN RETURN FOR A FOLLOW-UP. THE FAILURE MILEAGE WAS 22,310 AND THE CURRENT MILEAGE WAS 22,331.

The contact owns a 2000 Ford Ranger. The contact stated that the gear shifter had to be shifted into neutral to start the vehicle. The gear shifter was not matching with the actual gear that was selected. While the vehicle was in park, the vehicle would roll backward before the park was engaged. The vehicle was taken to an independent mechanic and the shift range bracket and ignition lock cylinder were replaced however, the failure recurred. The dealer was made aware of the failure and informed the contact that the VIN was not under recall. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA. The contact related the failure to NHTSA Campaign Number: 01V062000 (Power Train) however, the VIN was not included. The failure mileage was 91,264.

THE FRAME RAILS AT THE REAR OF THE VEHICLE WHERE THE SHOCKS BOLT UP HAS COMPLETELY CRACKED THROUGH THE METAL ON PASSENGER SIDE & THE DRIVER SIDE HAS COMPLETELY RUSTED AWAY AND FRAME CRACKED

I LOOKED UP MY VIN ON THE NHTSA WEBSITE AND THERE ARE RECALLS THAT HAVE NOT BEEN FIXED.

SEAT BELT RECEIVER STOPPED ACCEPTING THE SEATBELT. WITHOUT ANY DAMAGE AND NOT AS A RESULT OF AN ACCIDENT, AT APPROXIMATELY 120,000 MILES THE SEATBELT MECHANISM HAS FAILED.

WHILE DRIVING, DRIVERS SEAT BACK RECLINER BOLTS FAILED CAUSING SEAT TO FALL BACK UNTIL STOPPED BY REAR WALL OF VEHICLE. SINCE THIS WAS A SUPER CAB XLT, THE FALL BACKWARDS WAS SIGNIFICANT CAUSING TEMPORARY LOSS OF VEHICLE CONTROL. UPON INSPECTION FOUND THAT ONE OF THE TWO BOLTS HAD FAILED QUITE AWHILE AGO SINCE THE HEAD SHOWED SIGNS OF RUST.

SAT DOWN IN TRUCK, SEAT BROKE AWAY AND I FELL BACKWARD, NOTED 2 BROKEN BOLTS IN FLOOR, ONE LEFT SIDE ONE RIGHT SIDE,BOTH BOLTS APPEAR TO HAVE FRESHLY BROKEN. REMOVED SEAT TO SEE THE BOLTS WERE FROM THE RECLINER ASSEMBLY, REMOVED THE THREADED PART FROM THE FRAME, THE THREADS APPEARED TO BE APPROXIMATELY 1/4 INCH, ORDERED BOLTS FROM FORD AND REPLACED THE BOLTS FORD PART NUMBER F87Z-1060108-BB, PRICE APPROXIMATELY $40.00, UPON PICKING UP BOLTS ADVISED NO CHARGE. I HAVE MILD BACK STRAIN FROM THE INITIAL FALL BACKWARD. PLEASE NOTE: I AM NOT CONCERNED ABOUT MY INCIDENT, MY CONCERN IS IF I HAD BEEN DRIVING WHAT WOULD HAVE HAPPENED, AND THE NUMBER OF VEHICLES WHICH HAVE THE EXACT SEAT AND POSSIBLE DEFECTIVE BOLTS, IT APPEARS TO BE A DESIGN FLAW, SUCH SMALL BOLTS, I WILL GLADLY FORWARD THE BOLTS REMOVED UPON REQUEST

STARTING FROM HOME, THE VEHICLE HAD NO INDICATION OF TROUBLE LIGHTS IN THE INSTRUMENT PANEL. THEN, DRIVING ABOUT 2 MILES AND UP THE BRIDGE, SUDDENLY THE VEHICLE SLOWLY CAME TO A STOP WITHIN QUICK TIME AND STALLED ON THE UPHILL DIRECTION. A FEW ATTEMPTS TO RESTART, I WAS NOT SUCCESSFUL. THE POLICE WAS CALLED AND CAME TO PUSH THE RANGER DOWN THE BRIDGE TO THE SAFETY AREA AND WAITING TWO HOURS LATER FOR THE TOW-TRUCK TO TOW TO THE FORD DEALER. AND, THE DIAGNOSIS WAS THAT THE FUEL PUMP IS OUT. THIS VEHICLE HAD HISTORIES OF REPAIR SINCE THE FIRST YEAR AND THEREAFTER . *TR

TL* THE CONTACT OWNS A 2000 FORD RANGER. WHILE TRAVELING AT SPEEDS OF 65 MPH, THE CONTACT BEGAN TO SMELL AN UNUSUAL BURNING ODOR. THE HEADLIGHTS FAILED MOMENTS AFTER NOTICING THE ODOR. THE CONTACT STATED THE FAILURE HAD OCCURRED AT LEAST THREE TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR FURTHER INSPECTION OF THE HEADLIGHT FAILURE. THE FAILURE MILEAGE WAS 81,300 AND THE CURRENT MILEAGE WAS 81,318.

TL* THE CONTACT OWNS A 2000 FORD RANGER. THE CONTACT STATED THAT THE DRIVER FRONT WHEEL SPINDLE FAILED WHILE DRIVING AT 2 MPH. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS CONFIRMED THAT THE WHEEL SPINDLE HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 70,000.

CRACKED FRAME ON PASSENGER SIDE BY SHOCK MOUNT, BOTH REAR SHOCK MOUNTS RUSTED OFF. ALSO REAR LEAF SPRING SHACKLES ROTTED OFF. AS WELL AS THE SPARE TIRE CROSSMEMBER COMPLETELY ROTTED OFF CAUSING MY SPARE TIRE TO FALL OFF WHILE DRIVING!. THANK GOD NO ONE WAS BEHIND ME. TRUCK ONLY HAVE 124K ON IT AND IT IS IMACULENT SHAPE OTHER THAN THE FRAME..VERY DISAPPOINTED ALSO I CLEAN AND MAINTAIN MY TRUCKS VERY WELL.. I WASH IT AT LEAST ONE A WEEK AND I WASH THE UNDERNEATH THEN I DRIVE AROUND TILL ITS DRY AND STILL ITS IN POOR SHAPE.. NONE OF MY OTHER TRUCKS DO THIS SO ITS NOT HOW I MAINTAIN THEM. *TR

THERE IS A CLICKING NOISE WHEN TURNING ON AIR CONDITIONER. TOOK VEHICLE TO DEALER, AND THEY REPLACED SOME PARTS, CURRENTLY, ENGINE CHECK LIGHT IS ON, AND AIR CONDITIONER WON'T COME ON.*AK

ENGINE IS LEAKING OIL, REOCCURRENCES HAVE CAUSED CONSUMER TO TAKE VEHICLE TO DEALER 7 TIMES FOR THE SAME PROBLEM, LAST REPAIR WAS 1 YEAR AGO, VEHICLE IS ACTING SLUGGISH, THE OIL PAN AND REAR MAIL OIL SEAL WAS THE CAUSE OF THE OIL LEAK.*AK. CONSUMER ALSO STATED THE THE AIR CONDITIONER WAS BLOWING OUT HOT AIR, THE DEALER DISCOVERED THAT THE COMPRESSOR WAS LEAKING.*JB

WINDSHIELD WIPER MOTOR ON 2000 FORD RANGER XLT PICKUP TRUCK BEGAN TO FAIL ABOUT 1 YEAR AFTER I BOUGHT THE TRUCK. THE WIPERS WOULD WORK OCCASIONALLY AND THEN FAIL ON ME. TOOK IT TO FORD DEALERSHIP AND THEY DIAGNOSED PROBLEM AS THE WINDSHIELD WIPER MOTOR IS DEFECTIVE / BAD AND WILL NEED TO BE REPLACED. I NOTE THAT IN 2006 FORD RANGERS HAD A RECALL ON WIPER MOTOR PROBLEMS. I GOOGLED THIS PROBLEM ON GOOGLE.COM AND FOUND THAT NUMEROUS CONSUMERS HAVE EXPERIENCED FAULTY WIPER MOTORS ON FORD RANGER PICKUP TRUCKS. I BELIEVE IT IS A DEFECT IN THE MANUFACTURING OF THIS MOTOR. VERY DANGEROUS AS SUDDEN THUNDERSTORMS AND RAIN OCCUR WHERE I LIVE - CAN BE HEAVY AT TIMES, CAUSING COMPLETE LOSS OF VISIBILITY WHEN DRIVING AND COULD CAUSE AN ACCIDENT. *KB

WINDSHIELD WIPERS WORK INTERMITTENTLY. *AK