2006 Ford Ranger Problems

The contact owned a 2006 Ford Ranger. The contact stated that while at a stop light, a crash occurred involving two other vehicles. During the crash, one of the other vehicles crashed into the contact’s vehicle, causing severe damages to the front-end of the vehicle; however, the air bags failed to deploy. The Fire Department was called to the scene and removed the front driver’s side door to free the contact from the vehicle. The contact sustained a neck injury and was later taken by her daughter to seek medical attention. A Police report was filed at the scene. The vehicle was destroyed and towed away. The cause of the failure was not determined. The manufacturer and local dealer were not notified of the failure. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 21V081000 (AIR BAGS). The contact was concerned that after the recall repair was performed, the air bag failed to deploy during the crash. The failure mileage was 98,000.

The contact owns a 2006 Ford Ranger. The contact received notification of NHTSA Campaign Number: 17V788000 (Air Bags). The contact stated that while stopped at a red light, both driver and passenger front air bags deployed without impact. The contact lost control and the vehicle then crashed into the rear of another vehicle. The contact received shoulder and neck injuries, medical attention was needed. The second vehicle occupant also sustained a back injury and medical attention was sought. A police report was filed but the information was not available. The contact cut the air bags out with a pocket knife and the vehicle was taken to the resident. The vehicle was taken to a dealer where the dealer refused to diagnose or repair the vehicle under the recall until the SRS system and passenger seat belt were repaired since it was locked. The vehicle was not repaired. The manufacturer was notified of the failure and was transferred to the NHTSA Hotline. The failure mileage was 220,000.

Frame prematurely rotting out in critical areas near fuel tank/middle of vehicle frame

The spare tire stabilizing bracket rusted away and fell off. The rear shackles for the springs broke on both sides, and is coming up through the bed. The frame has rusted apart and it’s not possible to bolt a new shackle for the rear springs on. The body is not rusting out. They used inferior steel on the frame and it has rusted away. They should do a recall on these like other manufacturers have. This is a serious safety issue. I bought this truck new, and it only has 98000 mikes on it.

The spare tire stabilizing bracket rusted away and fell off. The rear shackles for the springs broke on both sides, and is coming up through the bed. The frame has rusted apart and it’s not possible to bolt a new shackle for the rear springs on. The body is not rusting out. They used inferior steel on the frame and it has rusted away. They should do a recall on these like other manufacturers have. This is a serious safety issue. I bought this truck new, and it only has 98000 mikes on it.

THE FRAME OF MY RANGER HAS RUSTED BADLY , CAUSING THE REAR SPRING SHACKLES TO NO LONGER BE ATTACHED TO THE FRAME.ALSO THE BED OF THE TRUCK HAS RUSTED AWAY BADLY. I I SPOKE TO A GUY WHO SPECIALIZES IN FRAME / AXLE REPAIR . AFTER INSPECTING IT , HE TOLD ME THAT THE ONLY OPTION TO REPAIR MY TRUCK WAS TO REPLACE THE FRAME , BECAUSE THE FRAME IS RUSTED TOO BADLY TO BE ABLE TO BE WELDED , HE SAID THE ONLY OTHER OPTION WAS TO JUNK IT . THE TRUCK HAS 102,000 MILES ON IT AND IS OTHERWISE IN GOOD CONDITION . I HAD PLANNED TO OWN IT FOR YEARS TO COME . NOW I AM AFRAID TO TRUST IT . AND I WOULD NOT FEEL RIGHT ABOUT SELLING IT TO SOMEONE ELSE . I USE THIS TRUCK TO HAUL HAY TO FEED MY LIVESTOCK , BUT NOW I AM AFRAID TO LOAD IT UP AND DRIVE DOWN THE ROAD WITH IT .I HAD THE TIRES REPLACED AND THE SERVICE CENTER NOTED ON THE PAPERWORK THAT THE FRAME WAS BAD AND NEEDED TO HAVE THE SPRING MOUNTINGS FIXED ..,

THE VEHICLE WILL QUIT RUNNING WHEN I AM DRIVING IT, YOU CAN BE DRIVING AT FIFTY MILE AND HOUR BAND THEN IT QUIT RUNNING.TOOK IT TO FORD THEY SAY THERE NO RECALL AND THEY CANT FIND ANYTHING WRONG BUT THERE IS SOMETHING WRONG IT WILL JUST QUIT RUNNING WITH NO WARNING.

SITTING AT A STOP LIGHT ENGINE STARTED RUNNING ROUGH THE CHECK ENGINE LIGHT WAS FLASHING. I TOOK OFF AND IT WAS NOT RUNNING WELL AND COULDN'T GET SPEED GOING UNTIL AROUND A 1/4 MILE DOWN THE ROAD. IT HAS HAPPENED SEVERAL TIMES ALWAYS AT IDLE SPEEDS, ONCE I GET IT MOVING AND GO UP TO HIGHWAY SPEEDS THE PROBLEM SEEMS TO GO AWAY BUT THE CHECK ENGINE LIGHT STAYS ON. I HAVE HAD THE CODE READ AND THE LIKELY SOLUTION IS TO REPLACE CYLINDER HEAD ASSEMBLY. THE CODE WAS P0316 WHICH INDICATES TOO MANY MISFIRES AFTER STARTUP AND CODE P0304 WHICH IS CYLINDER NUMBER 4 MISFIRE. NEEDLESS TO SAY I HAD DRIVERS BEHIND ME HONKING AND FLASHING LIGHTS BUT THE TRUCK JUST WOULDN'T GO OVER ABOUT 5 MPH UNTIL I WAS DOWN THE ROAD A BIT. THE FIRST TIME IT HAPPENED IN APRIL OF 2018 AND IT HAS INTERMITTENTLY DONE IT SEVERAL TIMES SINCE THEN WITH THE LATEST TIME BEING YESTERDAY 11/5/18. I HAVE DONE SOME RESEARCH AND FOUND OUT THAT THERE ARE KNOWN ISSUES WITH THE HEADS ON THIS FORD RANGER. I HAVE CONTACTED THEM ABOUT THE ISSUE AND SEEMED TO HAVE NOT GOTTEN ANYWHERE WITH IT.

Problem with fuel pump city switch keeps burning up and causing my truck to to die while I’m driving it. I have got it checked by a mechanic shop and the problem keeps happening. The fuel pump, the cut off switch and the connector and wires have all been replaced and it still continues to happen. This has been happening for years and is causing me to almost get in a car accident.

WHILE DRIVING THE SPARE TIRE RACK FELL FROM THE TRUCK. SINCE THE EVAP CANISTER FROM THE GAS TANK IS ATTACHED TO THE SPARE TIRE RACK IT TO WAS DAMAGED WITH THE CANISTER BEING BROKEN OPEN WHILE THE RACK SCRAPPED ON THE ROAD. AFTER FURTHER INSPECTION OF THE FRAME IT WAS FOUND THAT THE GAS TANK SUPPORT BRACKETS HAD FALLEN COMPLETELY OFF LEAVING ONLY A THIN STRAP SUPPORTING THE GAS TANK. THE FRAME ALSO SHOWED EXTENSIVE CORROSION ON THE FRONT CROSSMEMBER WHICH SUPPORTS THE LOWER CONTROL ARMS. BRAKE LINE SUPPORT TABS ON THE FRAME WERE ALSO FOUND TO HAVE COMPLETELY SEPARATED FROM THE FRAME AT THE WELD. THESE ARE VERY DANGEROUS SITUATIONS AND FOR HIGHWAY SAFETY AND THE TRUCKS SHOULD BE RECALLED. THANK YOU IN ADVANCE FOR YOUR ATTENTION IN THIS MATTER.

Problem with fuel pump city switch keeps burning up and causing my truck to to die while I’m driving it. I have got it checked by a mechanic shop and the problem keeps happening. The fuel pump, the cut off switch and the connector and wires have all been replaced and it still continues to happen. This has been happening for years and is causing me to almost get in a car accident.

INERTIAL FUEL PUMP SHUT OFF SWITCH KEPT SHUTTING DOWN VEHICLE... IT HAPPENED TWICE IN TRAFFIC THAT I WAS LUCKY ENOUGH TO HAVE ENOUGH MOMENTUM TO COAST OUT OF HARMS WAY. LAST TIME IT OCCURRED WAS PARKED AND WOULDN'T RESET, SO I ELIMINATED IT AND WIRED DIRECT WITHOUT THE SWITCH. NO PROBLEM SINCE. NO OTHER VEHICLE HAS SWITCH LIKE THIS THAT I'M AWARE OF. I ELIMINATED IT!!!

TAKATA RECALL. MY VEHICLE WAS DAMAGED IN THE REPLACEMENT OF AN AIRBAG PART WHERE THE AIRBAG GOES IN THE DASH WHEN IT WAS IN THE DEALERSHIP MECHANIC AREA BEING WORKED ON. TO MY KNOWLEDGE THE VEHICLE WAS STATIONARY AND NOT RUNNING

TL* THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT THE DRIVER SIDE WINDOW FAILED TO MANUALLY OPEN OR CLOSE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CRANK AND TIMING GEAR NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 15V322000 (AIR BAGS) AND 16V036000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUES. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE FAILURE MILEAGE WAS 50,000.

WHILE DRIVING THE SPARE TIRE RACK FELL FROM THE TRUCK. SINCE THE EVAP CANISTER FROM THE GAS TANK IS ATTACHED TO THE SPARE TIRE RACK IT TO WAS DAMAGED WITH THE CANISTER BEING BROKEN OPEN WHILE THE RACK SCRAPPED ON THE ROAD. AFTER FURTHER INSPECTION OF THE FRAME IT WAS FOUND THAT THE GAS TANK SUPPORT BRACKETS HAD FALLEN COMPLETELY OFF LEAVING ONLY A THIN STRAP SUPPORTING THE GAS TANK. THE FRAME ALSO SHOWED EXTENSIVE CORROSION ON THE FRONT CROSSMEMBER WHICH SUPPORTS THE LOWER CONTROL ARMS. BRAKE LINE SUPPORT TABS ON THE FRAME WERE ALSO FOUND TO HAVE COMPLETELY SEPARATED FROM THE FRAME AT THE WELD. THESE ARE VERY DANGEROUS SITUATIONS AND FOR HIGHWAY SAFETY AND THE TRUCKS SHOULD BE RECALLED. THANK YOU IN ADVANCE FOR YOUR ATTENTION IN THIS MATTER.

THE TRUCK IS A TOTAL RUST BUCKET THREE SETS OF WHEEL BEARINGS, FOUR SETS OF BRAKES,AIR CONDITIONER LINES,TRANSMISSION LINES ALL RUSTED OUT.FOUR WHEEL DRIVE MOTOR SHOT,LATCH ON TAILGATE BROKEN,REAR END LEAKS UPPER AND LOWER REPAIRED. AT LEST THE RADIO WOKS GREAT . I CAN SEE WHY THEY STOPPED MAKING THIS TRUCK

ROUGH IDLE NOTICED WHILE STOPPED AT AN INTERSECTION. CATASTROPHIC MISFIRE UPON ACCELERATION THROUGH AN INTERSECTION. TRUCK WAS ONLY ABLE TO "LIMP" 5 OR LESS MILES PER HOUR. CHECK ENGINE LIGHT HAD BEEN TURNING OFF AND ON HOWEVER DIAGNOSTICS SHOWED MISFIRE FOR UNKNOWN REASONS. SPARK PLUGS AND WIRES HAD BEEN REPLACED TWICE WITHIN A YEAR AS WELL. DEFECTED HEAD MANUFACTURED BY FORD. *TR

RUNS ROUGH AT STOP. HESITATES WHEN ACCELERATES. COULD CAUSE ACCIDENT AT INTERSECTIONS. VALVE RECESSION PROBLEM AS DESCRIBED IN FORD ISSUED TSB. *TR

WHILE DRIVING THE SPARE TIRE RACK FELL FROM THE TRUCK. SINCE THE EVAP CANISTER FROM THE GAS TANK IS ATTACHED TO THE SPARE TIRE RACK IT TO WAS DAMAGED WITH THE CANISTER BEING BROKEN OPEN WHILE THE RACK SCRAPPED ON THE ROAD. AFTER FURTHER INSPECTION OF THE FRAME IT WAS FOUND THAT THE GAS TANK SUPPORT BRACKETS HAD FALLEN COMPLETELY OFF LEAVING ONLY A THIN STRAP SUPPORTING THE GAS TANK. THE FRAME ALSO SHOWED EXTENSIVE CORROSION ON THE FRONT CROSSMEMBER WHICH SUPPORTS THE LOWER CONTROL ARMS. BRAKE LINE SUPPORT TABS ON THE FRAME WERE ALSO FOUND TO HAVE COMPLETELY SEPARATED FROM THE FRAME AT THE WELD. THESE ARE VERY DANGEROUS SITUATIONS AND FOR HIGHWAY SAFETY AND THE TRUCKS SHOULD BE RECALLED. THANK YOU IN ADVANCE FOR YOUR ATTENTION IN THIS MATTER.

REAR LEAF-SPRING SHACKLES AND HANGERS ON MY 2006 FORD RANGER ARE RUSTED OUT, ONE OF THE SHACKLES BROKE FREE FROM THE FRAME WHILE I WAS DRIVING, MADE IT HARDER TO STEER BECAUSE THE TRUCK FELT NOWHERE NEAR AS STABLE AS IT WAS BEFORE IT BROKE, IT CAUSED ME TO SWERVE INTO THE LANE BESIDE ME WHICH VERY WELL COULD HAVE CAUSED A SERIOUS ACCIDENT IF SOMEONE WERE TO BE THERE. THE REST OF MY FRAME SEEMS TO HAVE EXCESSIVE RUST WHICH IS NOT TO BE EXPECTED FROM A 10 YEAR OLD TRUCK, ESPECIALLY BY THE SHACKLES AND HANGERS FOR THE LEAF SPRINGS, AND ALSO ALL AROUND THE SPARE TIRE MOUNT WHICH I COULD SEE TO BECOME A VERY SERIOUS SAFETY CONCERN WHILE DRIVING. I MEAN WHO WANTS A SPARE TIRE IN THEIR WINDSHIELD WHILE FOLLOWING SOMEONE DOWN THE ROAD? MY VEHICLE WAS IN MOTION ON THE HIGHWAY WHEN ALL OF THIS HAPPENED IM VERY CERTAIN THAT CHEAP FRAME METAL WAS THE CAUSE OF IT BREAKING, BECAUSE IM GENERALLY PRETTY EASY ON MY TRUCK. *TR

TL* THE CONTACT OWNS A 2006 FORD RANGER EQUIPPED WITH COOPER TIRES, TIRE LINE: TRENDSETTER A/W, TIRE SIZE: 27X10R16, DOT NUMBER: R7HCC2T0117. THE CONTACT STATED THAT THE SET OF TIRES WERE CRACKING AROUND THE RIM. THE VEHICLE WAS NOT TAKEN TO THE LOCAL DEALER TO BE DIAGNOSED. THE VEHICLE HAD NOT BEEN REPAIRED AS OF YET. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE AND INFORMED THE CONTACT THAT THE TIRES WERE NOT UNDER RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 190,000.

I WAS DRIVING DOWN THE ROAD AND I HIT A BUMP AND MY SPARE TIRE FELL DOWN AND OUT OF THE TRUCK ONTO THE HIGHWAY. I STOPPED IMMEDIATELY AND RETRIEVED MY WHEEL OF THE HIGHWAY AND SAW THAT IT WAS STILL CONNECTED TO PART OF THE MOUNT. THE NEXT DAY I DROVE TO A REPAIR SHOP TO PUT THE TRUCK ON A LIFT TO LOOK AT THE DAMAGE AND REALIZED THAT THE ENTIRE FRAME HAD ROTTED UNDER THE TRUCK. I LEFT THE REPAIR GARAGE AND WAS HEADING HOME WHEN I HIT A POTHOLE THE ENTIRE DRIVER SIDE FRONT FRAME ROTTED AND THE WHEEL FELL PARTIALLY OFF THE TRUCK, SO I HAD THE TRUCK TOWED TO MY OFFICE PARKING LOT AND PARKED IT, BECAUSE IT IS NOT DRIVABLE ANYMORE. I CONTACTED FORD THEY TOLD ME TO HAVE IT TOWED TO A LOCAL DEALERSHIP AND THEY WOULD SEND A REP OUT TO LOOK AT IT. SO I DID AND THE REP NEVER CAME OUT AND THEY TOLD ME TO HAVE IT REMOVED, THAT THE REP CALLED THEM AND SAID THEY WOULD NOT REPAIR ANYTHING, SO THE TRUCK STILL SITS ROTTED AND PARKED, AND REMEMBER IT ONLY HAS 17,900 MILES ON IT, THANK YOU. *TR

DRIVERS SIDE SEAT BELT THROUGH NORMAL OPERATION APPEARS TO WEAR A HOLE IN THE SEATBACK EXPOSING SEAT MATERIAL. THE METAL BRACING IN THE SEAT IS EXPOSED RUBBING ON THE SEATBELT CAUSING THE SEATBELT TO FRAY. FRAYING MAY CAUSE FAILURE OF THE SEATBELT IN A CRASH. *TR

I WAS IN STOP AND GO TRAFFIC IN MY 2006 FORD RANGER WITH APPROXIMATELY 3500 MILES ON IT WHEN ENGINE SPUTTERED AND STOPPED AS I TRIED TO ACCELERATE. THE GAS TANK WAS NEAR FULL AND THE TRUCK WOULD NOT RESTART AFTER I COASTED ACROSS A LANE OF MOVING TRAFFIC ONTO THE MEDIAN. HAVING EXPERIENCED A SIMILAR PROBLEM IN MY 1986 RANGER, I CALLED THE DEALER SERVICE CENTER TO ASK WHERE THE FUEL SAFETY SHUT OFF SWITCH WAS LOCATED. AFTER BEING ASSURED THAT THE SWITCH COULD NOT BE THE PROBLEM UNLESS I HAD BEEN IN A COLLISION OR HIT A VERY LARGE POT-HOLE, I RESET THE SWITCH AND THE TRUCK STARTED. THE SWITCHES IN THESE TRUCKS APPARENTLY HAS A DEFECT THAT HAS NOT BEEN CORRECTED FOR 20 YEARS. THE SERVICE PEOPLE SEEM TO BE UNAWARE OF THE ISSUE AND I SUSPECT THAT MANY PEOPLE HAVE BEEN SOLD FUEL PUMPS AND OTHER RELATED ITEMS THAT WERE NOT THE PROBLEM. I AM JUST GLAD IT DIDN'T HAPPEN AT 65 MPH. *JB

THE FRAME AND BED IS COMPLETELY RUSTED OUT. SO MUCH SO THAT THE ONE OF THE LEAF SPRINGS BROKE LOOSE AND CAME THROUGH THE BOTTOM OF THE BED WHILE DRIVING DOWN A STRAIGHT STRETCH OF ROAD. THE TRUCK IS NOW COMPLETELY NOT DRIVABLE. I HAVE HEARD SEVERAL COMPLAINTS ABOUT THIS SAME MAKE/MODEL/YEAR TRUCK. EVEN FROM PEOPLE WHERE THEIR CITIES DON'T SALT THE ROADS IN THE WINTER.

THE TRUCK IS A TOTAL RUST BUCKET THREE SETS OF WHEEL BEARINGS, FOUR SETS OF BRAKES,AIR CONDITIONER LINES,TRANSMISSION LINES ALL RUSTED OUT.FOUR WHEEL DRIVE MOTOR SHOT,LATCH ON TAILGATE BROKEN,REAR END LEAKS UPPER AND LOWER REPAIRED. AT LEST THE RADIO WOKS GREAT . I CAN SEE WHY THEY STOPPED MAKING THIS TRUCK

AUTOMATIC TRANSMISSION DOESN'T MAINTAIN ENOUGH PRESSURE TO PREVENT THE VEHICLE FROM ROLLING FORWARD OR BACKWARDS. EXTREME PRESSURE TO THE GAS IS NEED TO REBUILD THE PRESSURE IN THE TRANSMISSION TO STOP THE ROLLING ACTION. *NM

I BOUGHT MY TRUCK BRAND NEW LAST MONTH ON APRIL 18TH I HAVE JUST OVER 1000 MILES ON IT AND WITHIN THE FIRST 400 MILES I HAD PROBLEMS WITH STARTING THE TRUCK, WHEN I TURN THE KEY MOST OF THE TIME IT STARTS, BUT OCCASIONALLY IF I LET GO OF THE KEY ABOUT THE TIME IT NORMALLY STARTS THE ENGINE DIES AND ONCE WHEN I ATTEMPTED TO START IT AGAIN I HEARD THE STARTER MAKE THE NOISE LIKE IT DOES IF YOU TURN THE KEY AND THE ENGINE IS ALREADY RUNNING. ALSO MY TRANSMISSION WILL OCCASIONALLY JERK WHEN IT SHIFTS GEARS. I TOOK THE TRUCK BACK TO THE DEALER WHERE I BOUGHT IT AT AND THEY TOLD ME THAT THE TECH DROVE IT AND THE SHOP MANAGER DROVE IT TOO AND THEY COULD NOT REPRODUCE THE PROBLEM. I AM STILL HAVING THIS PROBLEM, I WOULD HATE TO HAVE THE PROBLEM CONTINUE AFTER THE WARRANTY EXPIRES AND THEN I AM STUCK WITH A HUGE BILL TO FIX IT. *JB

AWFUL BANGING SOUND WHILE DRIVING, INSPECTED TRUCK, FOUND REAR BUMPER HANGING HALF OFF. REAR PORTION OF BOTH FRAME RAILS HAD ROTTEN OFF. REAR SPRING SHACKLES ROTTEN AND NOT ATTACHED. I PULLED THE BUMPER OFF WITH MY BARE HANDS! IF IT HAD FALLEN OFF WHILE I WAS DRIVING IT COULD HAVE KILLED SOMEONE. THIS IS NOT AN OLD BEAT UP TRUCK, AS A MATTER OF FACT IT ONLY HAS 17,000 MILE ON IT. IT STILL LOOKS BRAND NEW. THE FORD RANGER XLT 4X4 EXTENDED CAB WAS BOUGHT NEW IN 2006 FOR $20,000, NOW ITS USELESS, CAN NOT EVEN FIX THE SPRING SHACKLES, NOTHING TO ATTACH THEM TO. *TR

REPLACED SEALS IN DRIVE TRAIN DUE TO LEAKAGE, WHICH CAUSED NEED TO REPLACE PINION BEARING. REPAIRS COST $936.13. *TR

TAKATA RECALL; I TOOK MY 06 FORD RANGER TO JIM BURKE TO HAVE MY RECALL FIXED ON MAY 31 2016 THEY KEPT IT ALL DAY. I PICKED IT UP AT END OF DAY ,MY AIR BAG LIGHT WAS STILL ON I ASKED THE SERVICE ADVISER ABOUT IT , THEY SAID I WOULD HAVE TO BRING IT BACK ANOTHER DAY AND I WOULD BE CHARGED TO CHECK IT OUT. TODAY IS 7/21/16 MY AIR BAG LIGHT STILL COMES ON .I DON'T THINK JIM BURKE FORD EVER REPLACED MY DEFECTIVE PART