2019 Ford Ranger Fuel system Problems

My 2019 Ford Ranger 4x4 was bought new in April of 2019 and has approxiamatly 73,400 miles. Over time a slight glitch in the transission got to be more frequent. When first starting out within the first mile of operation, the vehicle would hang between gears and act like it ran out of fuel for a few seconds at low speed, as in pulling out from a stop sign or accelerating from a dead stop. My guess is inbetween first and second or second and third gear. It just wouldn'd go. Fortunatley I was not involved in any accidents. I can see where this could easily cause a mjor accident. There are several TSB's for this transmission and I believe Ford and General Motors use this same transmission. I have had my truck at the dealer for almost a month after it got scary to drive it got scary to drive. They are repairing this and contributing to the cost. I feel ike they no there is a problem and probably should have done a recall before someone gets killed.

NHTSA ID

11693113

Incident

Sep 23, 2025

When turning on to another road and accelerating, engine will suddenly loose all power. releasing accelerator will regain some power until vehicle speed increases. Throttle control is often erratic and transmission shifting is inconsistent resulting in hard clunks during shift. Pulling into traffic with a sudden loss of power leaves me vulnerable to a collision.

NHTSA ID

11636744

Incident

May 1, 2024

There is insufficient shielding to prevent water from reaching the top of the engine. This results in water dripping on the coil packs and also entering the spark plug wells, causing loss of spark and reduced engine output. Over time, this issue also leads to rust in the engine head, potentially resulting in engine failure. Additionally, water can reach the EGR DPFE sensor, causing the engine to hesitate and shutter at various speeds. Both of these issues together cause a misfire when applying the accelerator and will cause the vehicle to initially hesitate then surge forward. Even with the engine cover, the venting at the base of the windshield allows water to drip down on the engine head, causing the above issues. Ford does recognize that there is an issue and have written several TSBs on the it.

NHTSA ID

11604011

Incident

Jun 15, 2024

Unintended Aceleration Veheicle experienced normal stop with no anomaly. Upon release of brakes, experienced reported Wide Open Throttle" Brakes were ineffective. Vehicle accelerate thru intersection striking guardrail with significant damage. WOT stopped by shutting of engine. Vehicle currently in repair. Reported event to local dealer service dept, Insurance Rep and Ford referencing 2010 Class Action Lawsuit for similar events, All claim no knowledge of such an event. Vehicle had no previous reports of similar events

NHTSA ID

11561429

Incident

Oct 31, 2023

Unknown, My vehicle seems to stall in low gear. I already informed the dealership several times, and they stated that everything was fine. The stalling appears to be getting more frequent as time goes on, and worried that this could cause further damage to the vehicle. This is a safety concern as well.

NHTSA ID

11457217

Incident

Mar 17, 2022

Drive truck and park in garage and garage smells like gas. Only happens when parking truck in garage right after driving it. This has happened about 3-4 times now. I don't drive it that often. Just had an oil change at Ford and drove home. Then the next day i took it out and parked it in garage and gas smell again. Smell will last 2-3 days if truck stays parked. Have an appt. this coming week at Ford.

NHTSA ID

11456425

Incident

Mar 1, 2022

I CHANGED MY OIL AT 5,000 MILES, I HAVE APPROXIMATELY 8,400 MILES ON MY TRUCK NOW. I NOTICED EXCESSIVE FUEL BUILT UP IN MY OIL CATCH CAN. AFTER DOING SOME RESEARCH A LOT OF PEOPLE WITH THE 2019 FORD RANGER ARE HAVING THE SAME ISSUE. I CHECKED MY OIL AND MY OIL WAS SATURATED WITH FUEL. FUEL IS GETTING INTO THE ENGINE OIL.

NHTSA ID

11394340

Incident

Feb 2, 2021

Mileage

8,400 mi

CONSISTENT ISSUE WITH FUEL IN OIL. LATEST REPORT FROM THE OIL ANALYSIS HAVE 4.5 PERCENT FUEL IN OIL. DROPPING OIL IGNITION POINT TO 285 DEGREES. ISSUE OCCURS DURING NORMAL VEHICLE USE.

NHTSA ID

11386201

Incident

Dec 3, 2020

Mileage

14,136 mi

EXTREME FUEL DILUTION IN THE OIL. LIKELY FROM LEAKING HIGH PRESSURE FUEL PUMP. I HAVE ATTACHED THE RESULTS FROM OIL ANALYSIS AT 1860 MILES. THE TEST ONLY INDICATES THAT FUEL DILUTION IS ABOVE 5%, WHICH ITSELF LEADS TO SEVERE OIL DEGRADATION. WHEN I CHANGED THE OIL, I DRAINED 7.5 QUARTS OUT OF AN ENGINE WITH A 6.2 QUART CAPACITY. THIS WOULD INDICATE A 21% FUEL DILUTION, NOT INCLUDING FUEL THAT HAS EVAPORATED FROM THE CRANKCASE AND RETURNED TO THE COMBUSTION CHAMBER VIA THE PCV SYSTEM. IF I ABIDED BY THE MANUAL'S RECOMMENDED OIL CHANGE INTERVAL, I HAVE LITTLE DOUBT THE ENGINE WOULD EVENTUALLY CATCH FIRE, BASED ON THE RESULTS OF SEVERAL TESTS COMPARING FUEL DILUTION TO AN OIL'S FLASHPOINT. AFTER CHANGING THE OIL, IT SMELLED FINE FOR THE FIRST 20 MILES OR SO. AFTER THAT, THE OIL BEGAN TO FEEL OF GASOLINE AGAIN. AFTER GOING THROUGH FORD'S SERVICE MANUALS, I HAVE ASCERTAINED THAT THE PROBLEM MUST LIE IN THE HIGH PRESSURE FUEL PUMP. IT RUNS OFF THE CAMSHAFT, WHERE LEAKING FUEL COULD THEN MAKE IT INTO THE ENGINE AND MIX WITH OIL. THERE WOULD BE NO WARNING OR INDICATION, BESIDES RISING OIL LEVELS ACCOMPANIED BY THE SMELL OF GASOLINE IN THE OIL. IT DOES NOT MAKE ME HAPPY THAT MY DEALER IS NOT TAKING THIS ISSUE SERIOUSLY, ESPECIALLY BECAUSE A FUEL LEAK OF ANY KIND ALWAYS HAS THE POTENTIAL TO LEAD TO A FIRE OR EXPLOSION IN THE HOT ENGINE BAY. I PAID OVER $40K FOR THIS TRUCK, AND SHOULD NOT HAVE TO CHANGE THE OIL EVERY 500 MILES TO KEEP IT FROM SELF DESTRUCTING. THANK YOU FOR YOUR HELP IN THE RESOLUTION OF THIS ISSUE. I DON'T FEEL SAFE DRIVING MY FAMILY IN THIS VEHICLE, AND FORD HAS REPEATEDLY CHOSEN NOT TO ADDRESS THE ISSUE. I FIRST DETECTED THE ISSUE ON OCTOBER 20TH, BUT I HAVE NO DOUBT THAT IT HAS BEEN GOING ON SINCE THE TRUCK ROLLED OFF THE ASSEMBLY LINE. I PURCHASED THE VEHICLE ON AUGUST 30TH OF THIS YEAR.

NHTSA ID

11287662

Incident

Oct 20, 2019

Mileage

1,860 mi