2025 Ford Ranger Electrical Problems

The vehicle is equipped with a drive mode selector that switches between drive modes such as Normal, Sport, Eco, Mud/Ruts, Slippery, etc. My vehicle recently started switching drive modes by itself, with no human interaction with the switch, and is potentially dangerous both to the vehicle and it’s occupants as the drivetrain tries to switch into 4x4 and even 4-Low at speed, causing sudden and violent deceleration, difficulty turning, and potential loss of control of the vehicle.

NHTSA ID

11776120

Incident

Nov 5, 2026

On XXX Pulling out at an intersection to turn left, the vehicle pulled out normally but then went into neutral - coasting through the intersection for about 5 seconds - until it finally selected another gear. It then drove normally. On XXX, I slowed down and made a left turn, the vehicle again went into neutral seeming trying to find a gear - it didn’t. I stopped, put it in park, then back in drive. That reset worked and it again drove normally. No codes were tripped but it is a major safety issue if on random occasions the power is cut and you can’t safely operated the vehicle. The ford dealer said 1) no codes, 2) can’t replicate the problem, 3) Ford has no technical bulletin on it, so we can’t fix it. After experiencing this, I looked online and their are Ranger Forum and Reddit threads about it, so it is certainly a known issue. Hopefully, you can push Ford to acknowledge and address the issue before someone is killed or injured. This issue and lack of action from Ford leaves me with little confidence in reliability and safety. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11774487

Incident

Oct 18, 2026

2025 Ford Ranger XLT FX4 4x4, 2.3L EcoBoost. When I change the drive mode with the rotary dial and then return it to Normal, the drive modes begin cycling on their own with no input from me. A drive mode fault message then appears on the instrument cluster, and I am unable to select a drive mode. I first took the truck to a Ford dealer on 07/13/2026 at about 4,100 miles. The dealer recorded the cause as an all-terrain control module software fault and an ABS module communication concern with the ATCM. They reconfigured the ABS module and released the truck as operating as designed. The problem came back. I returned to the dealer on 10/15/2026 at about 6,745 miles. The technician verified the concern and found DTC P05D3 stored in the ABS module. The concern returned after the ABS module was configured again, and the dealer then replaced the electronic brake booster under warranty. Safety risk: the drive mode system changes traction control, throttle, and drivetrain behavior. Having it cycle modes on its own while driving, with no warning, could cause loss of control, especially while towing a trailer. The fault also points to a communication problem between the drive mode module and the brake system.

NHTSA ID

11772275

Incident

Jul 13, 2026

My 2025 Ford Ranger Raptor will shift drive modes by itself. I has tried to shift from normal drive mode to rock crawl mode or Baja mode. Rock crawl mode goes into 4 wheel drive low which would be very dangerous if it tried to shift into 4 low on the highway. It has happened multiple times. Sometime while parked, sometimes while driving.

NHTSA ID

11766922

Incident

Sep 10, 2026

Yes this is my second time filing a complaint regarding my new truck switching drive modes on its own. The first time it tried going into 4 low while i was going over 45 mph, with only 800 miles. The next time it did it was at around 1200 miles it switched drive modes completely and tried switching into 4 wd while at hoghway speeds. This is clearly a safety issue, their are numerous threads on reddit, facebook and ranger forums regarding it. Ford cannot replicate so they dont fix, what will it take one of us getting killed before we get a recall for whatever part or module is broken.

NHTSA ID

11763583

Incident

Sep 4, 2026

2025 Ford Ranger XLT experienced an electrical short-circuit causing a persistent speaker hiss with the vehicle turned off, accompanied by an electrical burning smell. The radio and audio became very staticky and a constant hissing sound with the radio and the truck turned off. By the time the dealer looked at the vehicle it was operating normally. Dealership refused to inspect wiring or ACM due to intermittent nature of the failure.

NHTSA ID

11761748

Incident

Aug 28, 2026

Vehicle received and installed an over-the-air software update to the Body Control Module, identified on the vehicle screen as BCM-26.6.3 and associated with Safety Recall 26S29 (A-pillar/sun visor wiring, NHTSA 26V238000). The update screen displayed a status of "Not Completed." Since that update the vehicle will not start and is inoperative. Current condition: opening the driver door wakes the center infotainment screen only. The instrument cluster does not illuminate. Pressing the brake pedal produces no response - no cluster illumination, no warning lamps, no chimes, no messages, no crank. 12V power is present; the manufacturer's telematics app still reaches the vehicle and returns status. Symptoms are consistent with a Body Control Module that is powered but not communicating on the vehicle network. No warning lamps, messages, or symptoms were present before the update. The vehicle operated normally until the update was installed. Safety risk: the vehicle became immobile without warning immediately following installation of a manufacturer-pushed safety recall remedy. The transmission cannot be shifted electronically, requiring the manual park release to move or tow the vehicle. Had this occurred away from home or in a traffic lane, the vehicle would have been stranded and unable to move under its own power. The BCM also governs exterior lighting and hazard lamp function. Note: the update screen header displayed "25S29" while the body text referenced completing Safety Recall 26S29. The vehicle has a dealer-installed Ford Performance ProCal calibration. The vehicle has not yet been inspected by the dealer or manufacturer. It is available for inspection upon request.

NHTSA ID

11757184

Incident

Aug 15, 2026

While driving at highway speeds vehicle changes the drive mode at random. Even attempting to go into 4 low at high speeds. If the vehicle is able to change into 4 low at high speeds this could send the vehicle into uncontrollable lock down to the drive train and potently creating uncontrollable spin out. Car has been at the dealership for this issue, but they cannot find any problems or able to replicate the issue.

NHTSA ID

11744966

Incident

May 21, 2026

My Ford Ranger is on a safety recall. They sold it to us on May 9,2025 then kept the truck. June 1 they told use the recall issue was solved. We were not given documents on this. We are now seeing the parts needed are not available until the end of June. A Fedaral and State law was broken in selling us a vehicle on a safety recall. We were not aware of this issue until we research the recall. I am so frustrated. We lost a month of use of this vehicle In waiting. So frustrated.

NHTSA ID

11742182

Incident

May 9, 2026

Became aware of open recalls circa 09.2025, and requested the parts be ordered at Ford Auto Nation (FAN) Panama City, FL. Was told by John, dealership would call when parts became available. Parts have not either been available and/or there have been no calls. Calling the dealer is ludicrous as all calls are answered by an incompetent call center. Dropped by the dealership today 04/25/2026, and Taylor could not book a service appointment, did not know if parts to fix recalls were available for my vehicle, and said I would need to speak with John whom was off today. It appears that Ford/FAN-PC is not interested in safety or repairing my vehicle.

NHTSA ID

11733759

Incident

Sep 10, 2025

Check engine light for CCV emesions system.

NHTSA ID

11717552

Incident

Feb 1, 2026

VIN: [XXX] Recall data refreshed on Aug 09,2025 0 Unrepaired Recalls associated with this VIN Please Amber alert the following for NATIONAL BROADCAST NHTSA 2025 Ranger Safety Recalls* Inspect seat bolt presence and torque - recall is unable to be performed at this time. Please check the fsa landing page for more details. Recall incomplete Front upper control arm to knuckle ball joint loose or missing fastener Recall incomplete Instrument panel cluster configuration Recall incomplete INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11679494

Incident

Aug 8, 2025