2018 Ford Transit Connect Problems

Component Affected: Service Brakes / ABS Module / Hydraulic Braking System Description of Safety Defect: There is an active, intermittent, catastrophic failure in the front braking system/ABS module causing the front brakes to completely lock up mid-transit while operating at high speeds (60+ MPH). First Incident (April 24, 2026): During operation on a busy interstate at over 60 MPH, the front braking system experienced a sudden, catastrophic thermal lock-up. This caused violent vehicle shuddering, extreme friction heat, and heavy, thick, acrid smoke. The vehicle was brought to a dealer shop for repair. Second Incident (April 29, 2026): Four days after delivery, the identical catastrophic brake lock-up recurred mid-transit, creating an immediate fire hazard due to friction heat and smoke. An independent repair facility diagnosed the failure and replaced the ABS module. Third Incident (June 4, 2026): The identical component failure recurred while traveling at over 60 MPH on Interstate 694 with a minor child in the vehicle. The front brakes fully locked up mid-transit, creating an immediate risk of a high-speed collision, severe thermal friction, and heavy burning odors, rendering the vehicle entirely un-roadworthy. Current Status: > The vehicle has sat grounded at a repair shop for 30 cumulative days out of 54 days of ownership due to the persistent re-locking of the front hydraulic braking system. The vehicle is unsafe to operate on public roads. No crash or fire occurred, but the failure poses an imminent thermal and collision hazard.

One tire locks up gradually and then completely preventing the vehicle from being driven and causing damage to the other tires. The inability to drive the vehicle on the open road is very dangerous. There are no warning lamps. The vehicle may seem sluggish to accelerate. After towing to a service station, the ABS module failed and this caused damage to the brake master cylinder which had to be replaced.

Power steering failed without warning. Rack and pinion had to be replaced. You now have 5 complaints on this but still no investigation open. This is clearly a manufacturer defect. $2,700 to fix. Vehicle only had 65,000 miles on it when it failed.

Power steering failed without warning while vehicle was being driven at highway speeds. Vehicle required replacement of power steering rack. This is the 4th time this has happened with my Ford Transit Connect vans

The contact owns a 2018 Ford Transit Connect. The contact received notification of NHTSA Campaign Number: 24V294000 (Visibility); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that two dealers were made aware of the issue and informed the contact that there were no technicians at the dealer capable of performing the recall repair. The contact was promised a call back once a technician was able to service the vehicle. The manufacturer was made aware of the issue and referred the contact back to the dealer. The contact had not experienced a failure. Parts distribution disconnect.

I had been driving my car for a few minutes when I heard a loud pop and my rear window glass shattered. Covered in spider glass cracks and only held in place by the tint. No point of impact visible to show that it had been hit by an object. It was chilly, 43 F, and I had the heat/defrost on. Unfortunately, when arriving to work, I opened my sliding door look at the damage from the inside and doing so caused glass to fall out, so I have no picture of just the glass the way it was when it broke. A quick search shows this has happened to other vehicles including transit connects like mine, and caused by the heated glass.

Driving at higher speeds when going to brake, the vehicle drops gears and slows agressively. It started to do this occasionally a couple of month ago, now it happens every other day.

The contact owns a 2018 Ford Transit Connect. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted, with the traction and ABS warning lights illuminated. The vehicle was able to be restarted; however, the failure recurred. The contact also stated that while the vehicle was parked, the contact became aware that transmission fluid was leaking from the transmission. The dealer was not contacted, and the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 114,000. The VIN was not available.

Component Affected: Service Brakes / ABS Module / Hydraulic Braking System Description of Safety Defect: There is an active, intermittent, catastrophic failure in the front braking system/ABS module causing the front brakes to completely lock up mid-transit while operating at high speeds (60+ MPH). First Incident (April 24, 2026): During operation on a busy interstate at over 60 MPH, the front braking system experienced a sudden, catastrophic thermal lock-up. This caused violent vehicle shuddering, extreme friction heat, and heavy, thick, acrid smoke. The vehicle was brought to a dealer shop for repair. Second Incident (April 29, 2026): Four days after delivery, the identical catastrophic brake lock-up recurred mid-transit, creating an immediate fire hazard due to friction heat and smoke. An independent repair facility diagnosed the failure and replaced the ABS module. Third Incident (June 4, 2026): The identical component failure recurred while traveling at over 60 MPH on Interstate 694 with a minor child in the vehicle. The front brakes fully locked up mid-transit, creating an immediate risk of a high-speed collision, severe thermal friction, and heavy burning odors, rendering the vehicle entirely un-roadworthy. Current Status: > The vehicle has sat grounded at a repair shop for 30 cumulative days out of 54 days of ownership due to the persistent re-locking of the front hydraulic braking system. The vehicle is unsafe to operate on public roads. No crash or fire occurred, but the failure poses an imminent thermal and collision hazard.

LOUD NOISE W/VIBRATION AND FOUL ODOR COMING FROM HEATER BLOWER. DEALERSHIP DISCOVERED A RODENT'S NEST IN THE CLIMATE CONTROL BLOWER MOTOR. DEALERSHIP INDICATED THAT THERE IS NO REMEDY TO PREVENT RECURRENCE. DEALERSHIP ALSO MENTIONED THAT THE FORD ESCAPE HAS A HISTORY OF THE SAME PROBLEM. SEE FORD'S TSB 17-0034, PUBLISHED 3/21/17 RE FORD'S RECOMMENDED PREVENTION: "...INSTALL THE NEW INLET DUCT GASKET WITH SCREEN..." (EMPHASIS ADDED).

The contact's company owns a 2018 Ford Transit Connect. The contact stated that while an employee was driving at 30 MPH, the rear driver side sliding door unintendedly opened. The employee could not shut the door due to a defective latch. The contact stated that a zip tie was used to secure the door. The vehicle was not diagnosed or repaired. The manufacturer nor the dealer had been notified of the failure. The vehicle was not repaired. The failure mileage was approximately 80,000.

hello - this is not a safety issue with my car. for the moment. inputting the VIN it states that there is only 1 row of seats (D/P). this is not accurate. there are 3 seat rows in my van. (front x2, middle x3 and rear seats x2) total of 7 seats. thus this should be corrected for my VIN. if or when i have a complaint about the safety of the seats, belts, head rests etc... it will make sense. i do not have a cargo van. it's a seven passenger seat van.

Driving at higher speeds when going to brake, the vehicle drops gears and slows agressively. It started to do this occasionally a couple of month ago, now it happens every other day.

ABS light comes on as well as loss of traction control and hill assist. Steering is more difficult, and the speed ohmmeter will not work. This is the second time this has happen. First time mechanic replaced bad speed sensor on drivers' side front wheel and everything went back to normal it only had around 6K miles on it. Now it has around 7.5K on it and it has happen again. Have not taken it in for repair yet.

DRIVER'S SIDE FRONT LOW BEAM BULB BURNS OUT CONTINUOUSLY

The transmission is having a shuddering issue, and looking online there on tons and tons of people having the same issue and stating it’s the torque converter and this is over many different years and variants of my vehicle… how is this not a recall yet?? People are having this issue right after purchase?

I had been driving my car for a few minutes when I heard a loud pop and my rear window glass shattered. Covered in spider glass cracks and only held in place by the tint. No point of impact visible to show that it had been hit by an object. It was chilly, 43 F, and I had the heat/defrost on. Unfortunately, when arriving to work, I opened my sliding door look at the damage from the inside and doing so caused glass to fall out, so I have no picture of just the glass the way it was when it broke. A quick search shows this has happened to other vehicles including transit connects like mine, and caused by the heated glass.

HAVE TAKEN OUR VEHICLE TO FORD AT LEAST 12 TIMES AND HAVE THE EXTENDED WARRANTY, THEY HAVE SAID NOTHING IS WRONG WITH IT. WE BOUGHT BRAND NEW AND HAVE THREE SETS OF BRAKE PAD PLACED ON THE FRON AND TWO PAIRS ON THE REARS.. WE HAVE GONE THROUGH TWO SETS OF TIRES AND THE FRONT DRIVERS SIDE IS CLICKING... FORD HAS SAID THERE IS NOTHING WRONG.. NOT SURE WHAT ELSE TO DO BUT THE VEHICLE DOESN'T WANT TO STOP AND THE TIRES OR THE ONE ON THE FRONT IS COMPLETELY BALD AND THE VEHICLE ONLY HAS 15,000 MILES ON IT

HAVE TAKEN OUR VEHICLE TO FORD AT LEAST 12 TIMES AND HAVE THE EXTENDED WARRANTY, THEY HAVE SAID NOTHING IS WRONG WITH IT. WE BOUGHT BRAND NEW AND HAVE THREE SETS OF BRAKE PAD PLACED ON THE FRON AND TWO PAIRS ON THE REARS.. WE HAVE GONE THROUGH TWO SETS OF TIRES AND THE FRONT DRIVERS SIDE IS CLICKING... FORD HAS SAID THERE IS NOTHING WRONG.. NOT SURE WHAT ELSE TO DO BUT THE VEHICLE DOESN'T WANT TO STOP AND THE TIRES OR THE ONE ON THE FRONT IS COMPLETELY BALD AND THE VEHICLE ONLY HAS 15,000 MILES ON IT

Torque Converter failed. Confirmed by dealer service department. No warning indicators. Dealer repaired under warranty but it took 3 months from the first phone call. Looking online at user boards this should be a recall issue. I was told I could continue to drive it until parts came in and only found out later that the transmission could be damaged by doing so.