1994 Ford Windstar Owner Complaints

TL* THE CONTACT OWNS A 1994 FORD WINDSTAR. WHILE DRIVING AT SPEEDS OF 15 MPH, THE CONTACT HEARD A LOUD, UNUSUAL NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE THE TECHNICIAN ADVISED THE SUSPENSION WAS CRACKED. THE TECHNICIAN MADE REPAIRS TO THE SUSPENSION ACCORDINGLY. THE DEALER WAS CONTACTED AND ADVISED THERE WERE NO RECALLS FOR THE VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE 125,000.

NHTSA ID

10331545

Incident

May 5, 2010

Mileage

125,000 mi

THE CONSUMER IS EXPERIENCING PROBLEMS WITH THE BRAKES. THE ABS LIGHT COMES ON AND NO ONE SEEMS TO KNOW WHY IT'S HAPPENING. ALSO, THE REAR WHEEL CYLINDERS ARE LEAKING. ALSO, THE BRAKE HOSES WERE REPLACED. OWNER HAS TAKEN THE VEHICLE TO THE DEALER FOR THESE BRAKE PROBLEMS ON NUMEROUS OCCASIONS BUT KNOW ONE CAN SEEM TO REPAIR THE PROBLEMS. *NM THE BRAKES WOULD LOCK UP AT TIMES. THE CONSUMER WOULD HAVE TO PUMP THE BRAKES A FEW TIMES. REFER TO RECALL CAMPAIGN #02V101000. WHEN THE VAN WAS STARTED FOR A 5TH OR 6TH TIME, IT WOULD SPUDDER/BUBBLE AND ON OCCASION, WOULD NOT START UP. THE SPARK PLUGS, PLUG WIRES AND EGR VALVE HAD BEEN REPLACED. THERE WERE ALSO ONGOING PROBLEM WITH THE ALIGNMENT WHEEL PULLING TO THE RIGHT. *SC *JB

NHTSA ID

10111739

Incident

Feb 10, 2005

Mileage

143,000 mi

BAD STRESS POINTS WITH 4 TO 6 INCH FRACTURES IN THE METAL. (NAR) *PH FORD WINDSTARS MADE FROM 1994 - 2000. *CB

NHTSA ID

10066970

Incident

Jan 1, 1901

WHILE DRIVING 30 MPH THE VEHICLE STALLED. THE DEALER WAS NOTIFIED OF THE PROBLEM. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM

NHTSA ID

10055815

Incident

Jan 17, 2004

Mileage

114,000 mi

WHEN VEHICLE IS AT A COMPLETE STOP OR IDLING AND GAS IS APPLIED, THE VEHICLE HESITATES TO ACCELERATE, THEN LAUNCHES FORWARD WHEN ACCELERATOR ENGAGES. THE DEALERSHIP INDICATED THAT THIS IS A RESULT OF A FAULTY PISTON IN THE TRANSMISSION, AND THIS IS A COMMON PROBLEM WITH THIS MODEL/YEAR VEHICLE. PLEASE PROVIDE MORE DETAILS. TS

NHTSA ID

10001449

Mileage

40,000 mi

CONSUMER STATED THAT WHILE DRIVING AT ANY SPEED AND WITHOUT THE TRANSMISSION FAILED CAUSING THE VEHICLE NOT TO ACCELERATE. DEALER NOTIFIED. TS

NHTSA ID

8024130

Incident

Nov 20, 2002

CONSUMER STATES THAT THE VEHICLE WOULD RUN ROUGH AND LOSES COOLANT WHILE DRIVING. DEALER NOTIFIED AND INFORMED THAT THE PROBLEM IS WITH A BLOWN HEAD GASKETS ON THEIR 3.8L V6 ENGINE. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. NLM

NHTSA ID

8019438

Incident

Sep 9, 2002

WHILE DRIVING AND WITHOUT WARNING VEHICLE BEGAN TO STALL, RESULTING IN A COMPLETE SHUTDOWN. DEALER WAS NOTIFIED.*AK

NHTSA ID

8015730

CONSUMER STATES WHILE DRIVING OVER 35 MPH WITHOUT WARNING THE SPEEDOMETER NEEDLE WILL MOVE BACK AND FOURTH EXTREMELY FAST RESULTING IN THE SPEED OF THE VEHICLE NOT TO REGISTER.*JB

NHTSA ID

8014768

A BLOWN HEAD GASKET REOCCURRED AFTER REPAIRS WERE MADE FOUR YES AGO. MANUFACTURER WAS NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

NHTSA ID

8012088

Incident

Jun 15, 2002

CONSUMER RECEIVED SERVICE PROGRAM 00M09 REGARDING HEAD GASKET FAILURE, CONSUMER WENT TO A LOCAL DEALER STATING THAT NO FAILURES HAD OCCURRED AND DEALER STATED ACTION WAS NOT NECESSARY, HOWEVER NOW THE HEAD GASKET HAS FAILED AND CONSUMER WAS INFORMED THE WARRANTY HAD EXPIRED FOR THE SERVICE PROGRAM, CONSUMER IS NOW LEFT HAVING TO PAY FOR REPAIRS. *SLC

NHTSA ID

564674

WHEN GOING TO PARK INTO REVERSE CONSUMER WILL HEAR A LOUD CLUNKING NOISE. PLEASE PROVIDE FURTHER INFORMATION.*AK

NHTSA ID

865422

PUSH THE BUTTON TO CLOSE THE SLIDING DOOR AND IT DIDN'T CLOSE ALL THE WAY. ANOTHER TIME, THE LIGHT CAME ON TO INDICATE DOOR AJAR, AND THE DOOR WAS AJAR WHILE DRIVING. CONTACTED DEALER. DEALER CHECKED THE DOOR AND REGREASED. THE SECOND TIME THEY ORDERED A PART. THE THIRD AT THE DEALER THEY READJUSTED THE DOOR. THE FOURTH TIME THE DOOR WAS REALIGNED. THE FIFTH TIME THEY PUT A NEW CONTROLLER.*AK

NHTSA ID

864770

ENGINE HEAD GASKETS HAVE FAILED PREMATURELY. DEALER HAS NO REASON. *AK

NHTSA ID

857444

THIS FAILURE CAUSES VEHICLE TO LOSE DRIVE POWER AT INTERSECTIONS AND IS VERY UNSAFE, WHEN I CONTACTED FORD THEY SAID NO RECALL HAD BEEN ORDERED AND THEY WOULD DO NOTHING UNTIL A RECALL IS ORDERED. THIS IS EXTREMLY UNSAFE TO LOSE POWER IN AN INTERSECTION, FORD HAS REDESIGNED THIS PART ON LATER MODELS BECAUSE OF FAILURE BUT THEY ARE NOT REPLACING PARTS ALREADY INSTALLED ON EXISTING VEHICLES. THEY SAID IT WOULD TAKE AN ORDER FROM NHTSA WOULD YOU PLEASE CHECK THIS OUT AND ORDER A RECALL, WHILE I WAS FORTUNATE ENOUGH TO AVOID AN ACCIDENT THIS FAULTLY CLUCTH IS UNSAFE AND NEEDS TO BE ADDRESSED. THANKS FOR YOUR CONCERN!

NHTSA ID

709367

Incident

Oct 18, 1998

WHILE SITTING AT A RED LIGHT ANOTHER VEHICLE REAR ENDED CONSUMER'S VEHICLE, AND DRIVER'S SIDE/PASSENGER'S SIDE AIR BAGS DIDN'T DEPLOY. *AK

NHTSA ID

835700

Incident

Mar 5, 1999

THE GAS FUMES ENTER IN THE VEHICLE WHILE DRIVING, CAUSING HEALTH PROBLEMS. DEALER CANNOT DETERMINE PROBLEM. CAUSE UNKNOWN. PLEASE PROVIDE FURTHER INFORMATION. *AK

NHTSA ID

831351

Incident

Aug 1, 1998

VEHICLE EQUIPPED WITHOUT REAR SEAT PASSENGERS' HEAD RESTRAINT SYSTEM. PROBABLE CAUSE: SEVERE HEAD OR NECK INJURIES UPON A CRASH. *SLC

NHTSA ID

819558

Incident

Apr 1, 1996

TRANSMISSION ENGAGES SLOWELY WHEN HOT, FALLS INTO NEUTRAL SLIPS ON START, AND A LOUD THUMP IS HEARD WHILE DRIVING, THE DEALER HAS BEEN NOTIFIED. *AK CONSUMER STATED FOWARD CLUTCH PISTON AND 3RD CLUTCH PISTON ALUMINUM CRACKED.*JB

NHTSA ID

816793

Incident

Sep 9, 1997

TRANSMISSION FAILED - VEHICLE DRIFTED BACKWARDS SEVERAL FEET, THEN SURGE FORWARD.

NHTSA ID

520649

Incident

Jul 1, 1997

MAIN BEARINGS FAILED SUDDENLY AT HIGHWAY SPEED. LOST POWER ON INTERSTATE WITHOUT WARNING.

NHTSA ID

521530

Incident

Jul 14, 1997

WAS DRIVING ALONG AT APPROXIMATELY 35MPH , PULLED OUT TO GET IN PASSING LANE AND TRANSMISSION SLIPPED AND THE VEHICLE WOULD NOT ACCELERATE. TOOK VEHICLE TO DEALER AND HE COULD NOT FIND THE PROBLEM. NOW THE VEHICLE WILL NOT GO INTO REVERSE. *AK

NHTSA ID

808351

Incident

Jan 16, 1997

APPLIED THE BRAKES AND THE ABS BRAKES DID NOT KICK IN . PLEASE DESCRIBE . *AK

NHTSA ID

805750